Marshall AIR AUTOTOAST HT18 Owner's Manual
|
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV072214 3 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. “AL4” This is an alarm message that indicates the Right Platen is too hot. Unit shuts off. Contact your local qualified service agency. PREVENTIVE MAINTENANCE DAILY CLEANING: 1. Remove conveyor carriage from toaster body. Take conveyor carriage to sink and spray with water. 2. Clean platen sheet three (3) times daily as listed below: a. After lunch rush – Clean sheet in place using a damp cloth
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV082813 6 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. C. Make sure all setscrews on gears are tight. D. Check motor to make sure it is turning with carriage removed. QUALIFIED SERVICE TECHNICIAN CHECK: A. Check that there is power at receptacle. Verify voltage is correct based upon the voltage listed on the toaster nameplate. B. Check the fuses inside the right panel. Replace with type A
Marshall AIR AUTOTOAST HT18, DETAIL A Copyright © 2004 Marshall Air Systems, Inc. All rights reserved 144328FIG8 RV082907 A STEP 1 REMOVE CARRIAGE, UNPLUG AND TURN UNIT UPRIGHT TOP PIN DO NOT USE MIDDLE PIN 208V BOTTOM PIN 230V STEP 4 USING A SMALL FLAT HEAD SCREW DRIVER, REMOVE THE JUMPER FROM THE 208V PIN AND MOVE IT DOWN TO THE 230V PIN, DO NOT USE TOP PIN WITH 208 OR 230V OR DAMAGE WILL OCCUR. STEP 3 USING A SMALL FLAT HEAD SCREW DRIVER REMOVE JUMPER COVER CONTROL, ECM3 MODULE PART # 144779 (MM2A) PART # 148301 (MM2G) MODEL: HT18 CONTROLLER VOLTAGE CONVERSION FIGURE 8 !CAUTION!: BE SURE THE UNIT IS UNPLUGGED OR ELECTRICAL SHOCK MAY OCCUR. CONTROL, ECM
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV082813 7 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. F. Control Generation 2 – Check for 24 Vdc from control board to motor relay (R3). If relay is getting 24 Vdc, check for 208 volts on output side of relay. If no 208 volts, replace relay. 6. PROBLEM: Product is over or under toasted. SOLUTION: OPERATOR CHECK: A. Check the gap settings. There must be compression of the bun as it feeds into the toaster. Decre
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV031915 12 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. CONTROL GENERATION 2 ELECTRICAL REPLACEMENT PARTS (NOTE: BUTTON LAYOUT UNDER DISPLAY) PART # DESCRIPTION FIGURE 504017 Circuit Board, 230V (MM2A, MM2B, MM2B-ARB, MM2H) Schematic 504107 Circuit Board, 230V (MM2G, MM2GINTL, MM2J) Schematic 163975 Control Interface Board (LED Control) Schematic 163582 Control I/O Board (MM2B-NC, MM2G-NC) Schematic 164653 Contr
Copyright © 2004 Marshall Air Systems, Inc. All rights reserved 144328FIG5 RV082813 MODEL:MM2J MM2B MM2BINTL MM2-EP MM2BINTLCE HT18 CARRIAGE ASSEMBLY FIGURE 5 CONVEYOR, TOASTER PART # 504001 CONVEYOR, RETURN PART # 504015 SPACER, CONVEYOR PART # 144405 SPROCKET, CONVEYOR ASBY PART # 144078 SPROCKET/ IDLER KIT PART # 149276 SHAFT, CONVEYOR DRIVE PART # 14400
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV041714 11 Copyright 2012 Marshall Air Systems, Inc. All Rights Reserved. CONTROL GENERATION 1 ELECTRICAL REPLACEMENT PARTS (NOTE: BUTTON LAYOUT TO RIGHT OF DISPLAY) PART # DESCRIPTION FIGURE 504017 Circuit Board, 230V (MM2A, MM2H) Schematic 504107 Circuit Board, 230V (MM2G, MM2GINTL, MM2J) Schematic 143852 Control, 3 Digit Schematic 144779 Control, ECM3 Module (MM2A) Schematic 159718 Control, ECM3 Module (MM2B-1) Schematic 148301 Control, ECM3 Module (MM2G, MM2-EP) Schematic 157400
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV031915 Copyright 2012 Marshall Air Systems, Inc. All Rights Reserved. PRODUCT DESCRIPTION The Marshall Model HT18 Horizontal Toaster produces caramelized buns hot and fast for building sandwiches to customer orders. This model has a slim horizontal footprint. Buns are loaded at the top and released onto a product slide at the bottom. The variable speed drive ranges from 20 seconds to 2 minutes. Heat controls are fully adjustable from 200- 565F with the LED Control. Left and right side toasting temperatures can be zoned for flexibility. All contro
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV031915 Copyright 2012 Marshall Air Systems, Inc. All Rights Reserved. WIRING SCH (208 or 240V, 50/60HZ, 1PH) VARIABLE SPEED (MM2H)........................DWG #150891 WIRING SCH (208 or 240V, 50/60HZ, 1PH) VARIABLE SPEED (MM2J) ........................DWG #150881 WIRING SCH (208 or 240V, 50/60HZ, 1PH) VAR SPEED (MM2B, MM2C, MM2-EP) .....DWG #152229 WIRING SCH (240V, 50/60HZ, 1PH) VARIABLE SPEED (MM2BINTL, MM2BINTLCE)..DWG #158451 WIRING SCHEMATIC (240V, 50/60HZ, 1PH) VARIABLE SPEED (MM2B-1) ..................DWG #15
Marshall AIR AUTOTOAST HT18, Copyright © 2007 Marshall Air Systems, Inc. All rights reserved 144328FIG10 RV072214 MODEL: HT18 ADDITIONAL HANG-ON PARTS MM2H MM2J MM2B MM2B-ARB MM2BINTL MM2BINTLCE MM2-EP FIGURE 10 MM2H WRAP, BUN TRAY PART # 150941 (MM2H ONLY) MM2J MM2B MM2BINTL MM2BINTLCE MM2-EP SLIDE, PRODUCT RETURN PART # 158454 SLIDE SHEET ONLY #158195 MM2B-ARB SLIDE, PRODUCT RETURN PART #164521 (HAS HOLES) SLIDE SHEET ONLY #164652 BUTTERWHEEL KIT #150425 INCLUDES HOUSING AND WHEEL FOOT, 4" TALL # 500263 CRUMB PAN PART # 164522 MM2B-ARB ONLY
OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV090514 9 Copyright 2012 Marshall Air Systems, Inc. All Rights Reserved. REPLACEMENT PARTS: (See page 11 and 12 for electrical components) When ordering parts, make sure to specify the model number and serial number as shown by the label attached on the back of toaster. WARNING: Use of
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV082813 4 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. TOASTER CONTROL DESIGNATION Before any troubleshooting or replacement parts are ordered, it is necessary to determine the style of control that your toaster has. Generation 2 started in March 2014, but older toasters may or may not have been field upgraded from Generation 1 to Generation 2. GENERATION 1 GENERATION 2 Buttons to the right o
OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV121814 1 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. INSTALLATION PRE-INSTALLATION 1. The toaster is packaged to minimize the risk of shipping damage. Immediately upon receipt, make certain to inspect the unit for damage. FILE ALL CLAIMS WITH THE FREIGHT CARRI
Marshall AIR AUTOTOAST HT18, OWNER’S MANUAL MODEL HT18 AUTOTOAST™ HORIZONTAL TOASTER 144328 RV121814 2 Copyright 2013 Marshall Air Systems, Inc. All Rights Reserved. toaster belt is 8 – 70 seconds; the MM2B and MM2G series is 9 – 105 seconds. 14. Test at least 3 buns before putting the toaster into service. Uniform surface toasting and bun temperature are achieved when the gap described in step 12 is set correctly. 15. If necessary, the speed of the conveyor can be changed. The speed control is located behind a box on the front of the unit. (See Figure 2) which can be removed using
DETAIL A Copyright © 2004 Marshall Air Systems, Inc. All rights reserved 144328FIG1 RV072214 DIRECTION OF TOP TOASTER CONVEYOR DIRECTION OF BOTTOM RETURN CONVEYOR A OPTIONAL 4" LEGS NOT SHOWN SEE FIGURE 10 MODEL: HT18 W/ PUSHBUTTON OVERALL DIMENSIONS FIGURE 1 MODEL: HT18 OVERALL UNIT ISOMETRIC FIGURE 2 REMOVABLE HEAT GUARD HEEL LOADING AREA CROWN
Marshall AIR AUTOTOAST HT18, Copyright © 2004 Marshall Air Systems, Inc. All rights reserved 144328FIG7 RV062707 MODELS: HT18 HEATING PLATEN ASSEMBLY FIGURE 7 PLATEN SUPPORT PLATE ELEMENT TERMINAL COVER PLATEN PART # 503981 PLATEN MOUNTING PLATE PLATEN ADJUSTMENT LINKAGE ARMS TOP PANEL TOASTER FRAME TOASTER HEATING PLATEN HEIGHT ADJUSTMENT KNOB #504009 KNOB NUT #501358
Marshall AIR AUTOTOAST HT18, Copyright © 2007 Marshall Air Systems, Inc. All rights reserved 144328FIG9 RV071414 MODEL:MM2J MM2B MM2BINTL MM2-EP MM2BINTLCE MM2B-ARB HT18 CARRIAGE ASSEMBLY FIGURE 9 BELT WRAP, CONVEYOR PART #504297 (MM2B MM2BINTL MM2-EP MM2BINTLCE MM2B-ARB ONLY) CONVEYOR, TOASTER ROD PART #150878 SPROCKET, CONVEYOR ASBY PART #144078 SHAFT, CONVEYOR DRIVE PART #144004 BEARING KIT PART #149275 GEAR, RETURN AND DRIVE KIT PART #149277 CONSISTS OF (1) TOASTER AND (2) DRIVE GEARS THIS CARRIAGE NEEDS ONLY (1) TOASTER GEAR AND (1) DRIVE GEAR FOR MOTOR PLATE, TENSION PART #144402 SPRING, TENSION PART #504046 LOADING RAMP REMOVED FOR CLARITY SHEET, LOADING SLIDE PART #1
Kenwood TT410 series Toaster Operation & user’s manual
TT410 series |
Roundup HCT-2010 Toaster Owner's manual
HCT-2010 |
T-Fal Emeril Toaster User manual manual
Emeril |
BOMANN TA 1358 CB Toaster Instruction manual
TA 1358 CB |
Holman QCS1-350-120V Toaster Installation and operation instructions manual
QCS1-350-120V |
H.Koenig VIEW6 Toaster Instruction manual
VIEW6 |
Exido Alu Line 243-024 Toaster Specifications
Alu Line 243-024 |
Breville BTO350 Toaster User manual manual
BTO350 |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Sony | CDXGT430U - CD Receiver Head Unit | Operating instructions manual | sony/cdxgt430u-cd-receiver-head-unit-842.pdf | 06 May 2023 | 27 | |
2 | Altec Lansing | 4156-8A LF SPEAKER | Dimensions | altec-lansing/4156-8a-lf-speaker-3OL.pdf | 09 Oct 2023 | 2 | 0.15 Mb |
3 | Patton electronics | SMARTNODE 4960 | Quick start manual | patton-electronics/smartnode-4960-47S.pdf | 07 Sep 2023 | 12 | 0.25 Mb |
4 | LG | DLEX2901W | User's manual & installation instructions | lg/dlex2901w-774.pdf | 19 Feb 2023 | 133 | |
5 | Kenmore | 721.62342 | Use and care manual | kenmore/721-62342-NKJ.pdf | 26 Aug 2023 | 20 | |
6 | RocketFish | RF-LTRMS | Operation & user’s manual | rocketfish/rf-ltrms-3UH.pdf | 17 Feb 2024 | 16 | 0.58 Mb |
Cuisinart
Cuisinart® Custom SelectTM 4-Slice ToasterCPT-640INSTRUCTION BOOKLETFor your safety and continued enjoyment of this product, always read the instruction book carefully before using.
…
Custom Select CPT-640(16 pages) |
Groupe SEB USA - T-FAL
Grille-painBrödrostBroodroosterToasterTostafetteTostadorTorradeiraEkmek kızartmamakinesiGuide d’utilisationGebruiksaanwijzingBedienungsanleitungInstructions for useIstruzioni per l’usoInstrucciones de usoInstruções de utilizaçãoKullanım KılavuzuNeftis Basic - Ref 3311484.indd 1 11/02/2005, 10:37:29
…
Neftis(12 pages) |
Orbegozo
MULTI TOSTADOR – MANUAL DE INSTRUCCIONES MULTI TOASTER – OPERATION MANUAL MULTI GRILL – MANUEL D’INSTRUCTIONS MULTI TORRADEIRA – MANUAL DE FUNCIONAMENTO TO 1015 Sonifer,S.A. Avenida de Santiago, 86 30007 Murcia España [email protected] Made in PRC Lea atentamente este manual antes de utilizar este aparato y guárdelo para futur …
TO 1015(24 pages) |
nedis
a Quick start guide2-Slice ToasterKABT300EALFor more information see the extended manual online: ned.is/kabt300ealIntended useThis product is a toaster with 7 browning settings.This product is intended to toast normal size slices of bread.The product is intended for indoor use only.The product is not intended for professional use.Do not let persons with redu …
KABT300EAL(12 pages) |
MWf
EDELSTAB 4-in-1LINEOGebrauchsanweisung 6Operating Manual 14Mode d’emploi 22Istruzioni per l’uso 30Instrucciones de uso 38Gebruiksaanwijzing 46Brugsanvisning 54Användarguide 60Käyttöohje 66Bruksanvisning 72nldasvfinodeenfrites
…
lineo(41 pages) |
Nostalgia
All products are trademarks of Nostalgia Products LLC. Worldwide design & utility patented or patents pending. © 2015 Nostalgia Products LLC.www.nostalgiaproducts.com(rev. 09/04/15)
…
Retro Series(28 pages) |
FujiFilm Racks & Stands SONOSITE X-PORTEFujiFilm Product User Guide: SONOSITE X-PORTE PDF Mobile printer installation instructions - 2479E7 SONOSITE X-PORTE, 8 |
Oki Printer C6100dnOki C6100dn Manual (Doc Type: Printer Safety information manual) C6100dn, 44 |
turck I/O Systems FGEN-AIM SeriesPDF User Manual (@21954C), turck FGEN-AIM Series I/O Systems (11/01/2024) FGEN-AIM Series, 203 |
Bard Air Conditioner EIFM-3CBard Air Conditioner Installation instructions manual (File: bard-eifm-3c-installation-instructions-manual-13, 02/10/2023) EIFM-3C, 13 |
Harman Kardon Tape Deck CD101Harman Kardon Tape Deck Owner's manual (File: harman-kardon-cd101-owner-s-manual-9, Thu 01.2024) CD101, 9 |
Gardena Water Pump 13000 aquasensor13000 aquasensor Operator's manual - QO38S4 13000 aquasensor, 14 |
GE Microwave Oven JES1334#B1DRII JES1334: GE Microwave Oven Owner Documentation JES1334, 40 |
Nvidia Video Card GEFORCE GTX 460Nvidia Video Card GEFORCE GTX 460 Installation manual GEFORCE GTX 460, 31 |
Crosley Washer Laundry CenterLaundry Center Use & care manual - 1V2WDE Laundry Center, 20 |
Wilks USA Pressure Washer TX750Wilks USA Pressure Washer Manual (File: wilks-usa-tx750-manual-22, Monday 11-12-2023) TX750, 22 |
Integra DVD Player DPS-6.5DVD Player #E21264 DPS-6.5, 65 |
Opel Automobile Vivaro#JS9673: Vivaro Automobile Owner's manual Vivaro, 205 |