Manualios.com

Crathco 3312 Operator's Manual

Crathco 3312 Manual Online:

4.15, 2558 votes
Crathco 3312 User Manual
Crathco 3312 User Guide
Crathco 3312 Online Manual

Text of Crathco 3312 User Guide:

  • Crathco 3312, 26 Crathco ® Model 3312 Beverage Freezer Wiring Diagram and Parts List (continued) 220V Air-Cooled Model Item No. Part No. Description Item No. Part No. Description 70 W0570871 Transformer 76 W0570940 Toggle Switch 71 W0570667 Run Capacitor 77 W0570018 Indicator Light 72 W0570876 Compressor Relay 78 W0570054 Light Socket 73 W0570666 Start Capacitor 79 61468 Ballast 74 W0570651 Time Delay Relay 80 W0570055 Bulb 75 W0570235 Terminal Block 81 W0650427 Ranco Controller Micro Switch Micro Switch

  • Crathco 3312, 4 Crathco ® Model 3312 Beverage Freezer General Information Freezer Application and Specifications Model 3312 The freezer consists of two freezing cylinders with rotating internal augers (dashers) that are belt-driven by electric motors. The augers scrape frozen product off of the inside of the refrigerated cylinders. Torque sensing mechanisms control compressor operation to maintain desired product consistency. The freezer utilizes an air-cooled refrigeration system to freeze the product. Self-closing dispensing valves are attached to the front of the freezing

  • Crathco 3312, 6 Crathco ® Model 3312 Beverage Freezer Installation (continued) Installing Your Unit (continued) 4. The side panels should still be removed. Cut the cable tie used to secure motor during shipment. Make sure motor rocks freely. See Figure D. 5. 220V/50Hz Units: These units come with a plugless cord that requires the appropriate plug configuration be connected. This must be determined by the power outlets at the specified location. See wiring diagram at back of manual for assistance. It is recommended that a service technician performs this operation. 6. Review contents from hopper to make sure all parts a

  • Crathco 3312, Model 3312 Beverage Freezer Crathco ® 11 Cleaning and Maintenance (continued) Reassembly NOTICE: Allow all parts to dry completely before reassembly. 1. Reassemble drip tray and re-install on front of unit. 2. Wet the inner rubber lip of the rotary half of the seal and the back end of the dasher shaft with water. Slide rotary half of assembly onto the dasher shaft, RUBBER FIRST, with the smooth sealing surface facing the back of the dasher. (See Figure U.) Be sure the rotary half is fully seated against the shoul

  • 11. Pour sanitizing solution into the mix storage hopper and allow the solution to fill freezing cylinder. Use a large brush to sanitize all hopper surfaces. (See Figure DD.) 12. Turn panel switch on each side to “CLEAN” and allow freezer to run for 5 minutes. 13. Open dispensing valves and drain solution. Allow the dasher to push remaining sanitizer

  • Grindmaster-Cecilware 4003 Collins Lane, Louisville, KY 40245 USA Phone: 502.425.4776 Toll Free: 800.695.4500 Fax: 502.425.4664 Web: gmcw.com Email: [email protected] Grindmaster-Cecilware provides the industry’s BEST warranty. Visit gmcw.com for warranty terms and conditions. ©2016 Grindmaster-Cecilware Printed in USA 0516 Form # WH-313-07 Part # 390-00048 Refrigeration Schematic (AC Units

  • Crathco 3312, Model 3312 Beverage Freezer Crathco ® 25 Wiring Diagram and Parts List 115V Air-Cooled Model Item No. Part No. Description Item No. Part No. Description 70 W0572032 Transformer 76 W0570912 Switch 71 W0570617 Run Capacitor 77 W0570018 Indicator Light 72 W0570638 Compressor Relay 78 W0570044 Light Socket 73 W0570603 Start Capacitor 79 W0570045 Ballast 74 W0570651 Time Delay Relay 80 W0570043 Bulb 75 W0570235 Terminal Block

  • Crathco 3312, Model 3312 Beverage Freezer Crathco ® 23 Parts Diagram and List (continued) Electrical Box Assembly 115V Air-Cooled Model Item Part No. Description Item Part No. Description 1 W0572301 Electrical Box, 3312 15 83151 Washer, Lock, #8, Ext. Tooth 2 W0570044 Socket, Light-Leviton 16 W0630006 Heyco Snap Bushing 3 W0570235 Terminal, Block, 4 Circuit 17 86600 Tie, Wire, Nylon, T18R 4 W0630811 Clip, Capacitor-Small 18 W0631619 Electrical Box Lens, 3312 5 W0570603 Start Capacitor 19 W0570043 Bulb, Fluorescent 6 W0570617 Capacitor, Run 20 W0610132 8-32 x 1/4” S

  • Crathco 3312, 22 Crathco ® Model 3312 Beverage Freezer Parts Diagram and List (continued) Base Assembly 220V Air-Cooled Model Item Part No. Description Item Part No. Description 1 W0211204 Plate, Frame Bottom 3312 12 W0200413 Compressor Mount Grommet 2 W0211210 Frame Assy 13 W0201419 Suction Line 3 W0200132 Compressor, 240/220V, 50Hz 14 Comp/Tee Hot Gas Line 4 W0200256 Condenser Coil 15 Evap/Tee Hot Gas Line 5 W0321040 Fan Assy, 115V 16 Low Side Process Tube 6 W0200411 Bracket Fan Motor Mounting 17 High Side Process Tube W0320216 Motor, Fan 230V 50 HZ 18 Comp/Access Valve Line W0320286 Propeller, Axial Flow 9.5" 19 Tee, 1/2 x 3/8 x 3/8 Copper 7 W0611410 Rivet, Magna Lok 20 T

  • Crathco 3312, How to Clean Condenser (Air-Cooled Unit Only) NOTICE: Loss of refrigeration efficiency will result if condenser is allowed to become dirty. Excessive compressor run time or loss of capacity is a good indication that the condenser needs to be cleaned. 1. Disconnect electrical power. 2. Remove side panels. 3. Place a damp towel over the side of the condenser opposite the fan motor. 4. Using compressed air or CO2, blow out dirt from the fan side of the condenser. An alternate cleaning method is to use a condenser brush and vacuum cleaner. CAUTION: Procedure can create a loud no

  • Crathco 3312, Beverage Freezer Operator Manual Model 3312 Grindmaster-Cecilware 4003 Collins Lane, Louisville, KY 40245 USA Phone: 502.425.4776 Toll Free: 800.695.4500 Fax: 502.425.4664 Web: gmcw.com Email: [email protected] Model 3312 Safety Information .....................................2 Specifications..............................................3 General Information ..................................4 Installation..................................................5 Accessory Installation .................................6 Operation and Adjustments ......................8 Cleaning and Maintenance.............

  • Crathco 3312, 24 Crathco ® Model 3312 Beverage Freezer Parts Diagram and List (continued) Electrical Box Assembly 220V Air-Cooled Model Item Part No. Description Item Part No. Description 1 W0572297 Electrical Box, 3312 15 0076 8-32 x 3/8 Hex Head Ground Screw 2 W0570054 Socket, Light-Leviton 16 83151 Washer, Lock, #8, Ext. Tooth 3 W0570235 Terminal, Block, 4 Circuit 17 W0630006 Heyco Snap Bushing 4 W0630812 Clip, Capacitor-Large 18 86600 Tie, Wire, Nylon, T18R 5 W0630811 Clip, Capacitor-Small 19 W0631619 Electrical Box Lens, 3312 6 W0570666 Start Capacitor 20 W0570055 Bulb, Fluorescent 7 W0570667 Capacitor, Run 21 W0610132 8-32 x 1/4” Screw 8 W

  • Crathco 3312, Model 3312 Beverage Freezer Crathco ® 21 Drive Motor Assembly (See figure on left) Parts Diagram and List (continued) Base Assembly 115V Air-Cooled Model Item Part No. Description 1 W0210075 Base Pan Assembly, 3312 2 W0211210 Frame Assembly 3 W0200806 Compressor 4 W0200807 Condenser Assembly 5 W0321029 Fan Assembly, 115V 6 see below Motor, 1/4HP 7 W0611410 Rivet, Magna-Lok 8 W0611247 1/4 Int. Tooth Lk Washer 9 W0611082 Nut, 5/16-18 Flange, Lg 10 P043A Nut, Hex 1/4-20 11 W0200412 Compressor Spacer 12 W0200413 Compressor Grommet Item Part No. Description 1 W0210169 Motor Cradle 2 W0320019 Motor, Dr

  • Crathco 3312, Sanitizing and Refilling 1. Reassemble carburetor by installing the two O- rings at the bottom of the carb tube. 2. Place the carburetor assembly in the bottom of the hopper. 3. Install the O-rings on valve plunger and lay plunger assembly on a clean piece of paper towel. 4. Prepare a minimum of 2.5 gallons (9.5 liters) of sanitizing solution (Kay-5 Sanitizer/Cleaner or equivalent) following the manufacturer’s instructions. NOTICE: Add 1 ounce (28 gm) of Kay-5 to 2.5 gallons (9.5 liters) of 120°F (50°C) water to achieve a concentration of 100 parts per million. 5. Dip a medium sized brush int

  • Crathco 3312, REVISIONS REV. DESCRIPTION D A RE-DRAWN IN SOLIDWORKS. 2/ 1 Eva p orator/Base Assemb DWG NO. THIS DRAWING CONTAINS PROPRIETARY AND CONFIDENTIAL INFORMATION OF THE GRINDMASTER CORP. & SHALL NOT BE REPRODUCED, COPIED, LOANED OR SUBMITTED TO OUTSIDE PARTIES FOR EXAMINATION WITHOUT OUR CONSENT. COMMON: TITLE: TOLERANCES NOT SPECIFIED: ±0.016" ANGLES: ±1° NOT TO EXCEED 0.031 LINEARLY DIMS. OFF FORMED FEATURES: ±0.031" HOLE TOLERANCE: ±0.005" W0210400SH2 2 2 3 6 5 4 11 10 9 12 7 T NO. (220V) DESCRIPTION 5 0416 Valve, 1/4" Schrader 0 1319 Line, Compressor/ Condenser 0 0809 Solenoid/Drier Assembly, 3312 5 0427 Low Pressure Controller C

  • Crathco 3312, Model 3312 Beverage Freezer Crathco ® 19 Parts Diagram and List Exploded View 115V Air-Cooled Model ITEM NO. PART NO. DESCRIPTION ITEM NO. PART NO. DESCRIPTION 1 W0201302 Evaporator Assy 3312 26 W0430024 Rear Stator Bearing 2 W0210075 Base Pan Assy 3312 27 W0430026 Dasher, Standard 3 W0211210 Frame Assembly 28 W0430028 Stator Weldment Pickled 4 W0200806 Compressor Assembly 3312 115V 29 W0430032 Stator Flange Bearing 5 W0200807 Condenser Assembly, 3312 30 W0480450 Valve Body 6 W0321029 Fan Assembly, 115V 31 W0611728 FasPin, Valve 7 W0321035 Motor Assembly, 1/4 HP 32 W0630711 Valve Knob 8 W0110013 Stud, Valve New Style 33 W0480445 Valve Handle 9 W0611085 Nut, 5/16-18 S.S. Hex Nut 3

  • Crathco 3312, • Concealed Air Filter - Prevents dust from clogging the condenser. Ideal for applications near beaches. Helps maintain maximum air flow and optimum freezer performance. See Figure F. NSF approved. Part # W0890200 stainless steel; W0890208 black. • Exposed Air Filter - Similar to concealed air filter. Not NSF approved. Part # W0890206. See Figure G. • Valve Lock Security Bracket - Part # W0471135. Ideal for self-service locations to prevent unauthorized use. Lock must be purchased separate

Related Products and Documents (Freezer):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 WELLTECH WellGate 3511N Technical manual welltech/wellgate-3511n-K16.pdf 28 Sep 2023 108
2 ProForm CLUBVTP Owner's manual proform/clubvtp-Q7H.pdf 12 Jul 2022 16
3 SMART TA250 Installation and operation manual smart/ta250-95J.pdf 01 Jan 2023 5 0.24 Mb
4 Yamaha WaveRunner XL1200Ltd Service manual yamaha/waverunner-xl1200ltd-X1E.pdf 04 Nov 2023 244
5 Audio Note M3 Phono Owner's information audio-note/m3-phono-3UR.pdf 27 Sep 2022 6 0.09 Mb
6 DYSON, INC DC18 Operation manual dyson-inc/dc18-1J3.pdf 28 Nov 2023 8 3.25 Mb

Similar Resources:

  • Electrolux

    10 GN2/1

    (3 pages)
    Electrolux Blast Freezers Blast Chiller/ Freezer - 56 kg 10 GN2/1Chilling means bringing the temperature of cooked food from +90ºC to +3°C in a short time lap which does not allow bacterial growth .Electrolux Blast Chillers/Freezers reduce temperature from +90ºC to +3°C at food core in less than 90 minutes and down to -18ºC in less than four hours: the …
  • Miele

    F 7102 S

    (32 pages)
    Operating and installation instructionsFreezerF 7102 STo avoid the risk of accidents or damageto this appliance, it is essentialto read these instructionsbefore it is installed or used for the first time.GM.-Nr. 05 969 280 …
  • Randell

    20042RF

    (22 pages)
    OPERATORS MANUALNOTIFY CARRIER OF DAMAGE AT ONCE.It is the responsibility of the consignee to inspect the container upon receipt of same and to determine the possibility of any damage, including concealed damage. Randell suggests that if you are suspicious of damage to make a notation on the delivery re-ceipt. It will be the responsibility of …
  • Miele

    FN 4697 S

    (40 pages)
    Operating and installation instructionsFrost-free freezersFN 4697 SFN 4897 STo avoid the risk of accidents ordamage to the appliance, it isessential to read these operating instructionsbefore it is installed or used for thefirst time.GM.-Nr. 06 413 700 …
  • Montgomery Ward

    762903

    (8 pages)
    Instruction ManualItem: 762903Wards.com 1•888•557•3848Montgomery Ward Customer Service3650 Milwaukee Street, Madison, WI 537148:00 am to Midnight, Monday through FridayKeep your cool!Wards.com 1•888•557•38485.0 Cu. Ft. Chest Freezer®® …
  • Smeg

    VI100A

    (18 pages)
    Instructions for Use9Upright Freezer GBThank you for your trust and for buying this appliance. We hope it willsuccessfully serve the purpose for many years.The upright freezer for domestic use is intended for freezingfresh food and for long-term storing of frozen food (up t …

Comments, Questions and Opinions: