Manualios.com

Clenergy PV-ezRack SolarTripod Installation Manual

Clenergy PV-ezRack SolarTripod Manual Online:

3.05, 2285 votes
Clenergy PV-ezRack SolarTripod User Manual
Clenergy PV-ezRack SolarTripod User Guide
Clenergy PV-ezRack SolarTripod Online Manual

Text of Clenergy PV-ezRack SolarTripod User Guide:

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 1 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] PV-ezRack SolarTripod Single/Adjustable and Double Code-Compliant Planning and Installation guide Based on AS/NZS 1170.2-2011 Amdt 3 2013 CONTENTS 1. Introduction…………………………………………………………………………………………………… 2

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 2 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 1 Introduction Clenergy PV-ezRack SolarTripod is suitable for home, commercial, flat roof and even for large scale solar installations. SolarTripod divides 2 solutions, single row and double rows in portrait of modules. The advantage of SolarTr

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 3 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 2 Planning This document is designed to support installations using SolarTripod, manufactured by Clenergy (Xiamen) Technology Co., Ltd. Follow the six steps below and the installation instructions section to install Clenergy PV-ezRack SolarTripod in compliance with the AS/NZS1170.2-2011 Amdt 3 2013. Before proceeding, note the following:  This document addresses only

  • PV-ezRack SolarTripod (double and single) Installation guide V2 Page 4 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 2.2 Determine the height of the installation site This document provides sufficient i

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 5 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 2.3 Determine the Maximum Rail Support Spacing Please use the following table to determine the base rail support spacing for sheet metal roof installations. The spacing below is suitable for a tilt angle of maximum 30° or less. 10m high roof

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 6 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 20m high roof

  • PV-ezRack SolarTripod (double and single) Installation guide V2 Page 7 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 2.4 Determine the number of fixing points The following fixing requirements are ba

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 8 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 3 Component List Overview Of The Components Inter Clamp End Clamp T Rail 50 Spice for T Rail 50 Tripod Support (single or double or adjustable) T Rail Clamp

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 9 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 4 Array Planning As the drawing above, mounting details are as follow: 1) Module orientation: portrait. 2) Length of rail in the same row: L1= Number of modules per row x (module width + 18mm) + 32mm. 3) Distance between the two rows: L2 must be determine based on the location to avoid shading 4) Distance betwe

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 10 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 4.1 System dimensions Single/Adjustable Tripod 4.2 System dimensions Double Tripod

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 11 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 5 Step by step installation 5.1 Installation of the Tripod support (based on Double tripod) 5.1.1 Unfold the tripod support. Check the purlin distance and pre drill the holes on the base of the Tripod sup

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 12 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 5.1.2 Unfold the middle tubes in the upper support (if you use double Tripod), fix them to the base support by using hex head bolts M10*65 and Spring Washer, Flat Washer and Hex nuts M10. 5.1.3 Repeat the step above for each support that you need to install. Fix the support Tripod to the purlin following the planning guide.

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 13 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 5.1.2 Tighten the screws through the leg strug to go along with the positioning groove on the leg tube, in order to achieve accurate positioning purposes. (Every 2 degrees set a positioning groove) 5.3 Installing T rails 5.3.1 Use T-rail clamp to fix the T-rail 50 on to the upper support, two per rails and per support. 5.3

  • PV-ezRack SolarTripod (double and single) Installation guide V2 Page 14 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] 5.3.3 Fix all the rails on to the upper support as the step above. 5.4 Ins

  • Clenergy PV-ezRack SolarTripod, PV-ezRack SolarTripod (double and single) Installation guide V2 Page 15 of 15 11/20 Duerdin St Tel: +61 3 9017 6688 Clayton VIC 3168, Australia Fax: +61 3 9017 6668 www.clenergy.com.au Email: [email protected] Service 10 year limited Product Warranty, 5 year limited Finish Warranty Clenergy co. Ltd warrants to the original purchaser (“Purchaser”) of product(s) that it manufactures (“Product”) at the original installa

Related Products and Documents (Solar panel):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 Bose FreeSpace 360P Owner's manual bose/freespace-360p-U89.pdf 29 Sep 2023 11 1.94 Mb
2 Solflower SFPCI -VME SERIES User manual and installation manual solflower/sfpci-vme-series-1J8.pdf 18 Dec 2022 56
3 Supersonic SC-196 Specifications supersonic/sc-196-FJR.pdf 19 Jun 2022 1
4 SignVideo DR1000 Operation manual signvideo/dr1000-XNS.pdf 17 Nov 2023 3
5 Winco PSS30/F Installation and operator's manual winco/pss30f-LS7.pdf 16 Apr 2023 20
6 Hitachi WH 18DSDL Safety instructions and instruction manual hitachi/wh-18dsdl-D4D.pdf 31 Aug 2022 68 1.67 Mb

Similar Resources:

  • ALDEN

    PACK KITECO

    (28 pages)
    modèles déposés • photos non contractuelles • document établi sous réserve de modifications techniques.Geschütztes Modell • Bilder und technische Änderungen vorbehalten.Register pattern • Design and specifications are subject to change without noticemodelli registrati • Foto non contrattuali • documento soggetto a variazioni.tecnichePACK K …
  • Schweizer

    Solrif

    (10 pages)
    Ernst Schweizer AGBahnhofplatz 118908 Hedingen, SwitzerlandTelephone +41 44 763 61 [email protected] www.ernstschweizer.chShort installation manual – Solrif® Inner cornersTechnical data subject to changeNovember 2021© Ernst Schweizer AGPage 1/10 Solar systems by Schweizer:Short installation manual – Solrif® Additional information for the m …
  • Viessmann

    Vitosol 300-T

    (28 pages)
    Installation instructionsfor contractorsVIESMANNVitosol 300-TType SP3AVacuum tube collector based on the heat pipe principleVITOSOL 300-T5369 537 GB 9/2009Dispose after installation. …
  • Aleo

    P19

    (24 pages)
    Please read this carefully prior to installation. Store in a safe place for maintenance.Quick Reference Manual Rel. 4.4, 12/2018, en-GB-DE (1)JD00000 10-ENwith standard frames 50mm S19 S25 S59 S75 S79with frames for roof integration S79 solFor the aleo moduleswith standard frame 35mm P19INSTALLATION MANUALwith standard frames 42mm X59 X79 …
  • Sunways

    SM 230M

    (4 pages)
    1 Safety first!Follow the setup instructions!Safe handling and trouble-free operation of the Sun-ways Solar Modules requires knowledge of the basic safety precautions.This setup document provides an overview of the safe installation and commissioning procedures for Sunways Solar Modules.In addition, the rules and regulations for accident prevention applica …
  • Hewalex

    KS2000 Series

    (5 pages)
    - 1 - INSTRUCTION FOR THE MONTAGE OF ROOF FLASHING FOR KS2000 COLLECTORS 1. Roof area. Picture and table describe the amount of place needed for mounted collectors and flashings. Measurement [ m ] Number of collectors in a battery 2 3 4 5 6 7 8 A 2,6 3,7 4,8 5,9 7,0 8,1 9,2 Collector KS2000 Collector KS2000 …

Comments, Questions and Opinions: