Hawk HWKAC6 Operator's Manual
|
ITEM DATA Model HWKAC6 FL FL-50L Power 2.2Kw/3HP Voltage 120V/127V 220V/230V/240V Frequency 60HZ 50Hz Motor Poles 2P 2P Rated Speed 1150r/min 950 r/min Current 25A 15A Theoretic Discharge Discharge Discharge Pressure Discharge Delivery (at 115PSI/0.8MPa) 10.2CFM 290L/min Discharge Pressure 115PSI/0.8MPa Restart Pressure 70
Hawk HWKAC6, MAIN COMPONENTS 3 1. Pressure Gauge 2. Regulator Valve 3. Handle 4. Coupler 5. Safety Valve 6. Pressure Switch 7. Pump Head 8. Motor 9. Wheel 10. Tank 11. Power Cord 12. Drain Cock 8 7 6 5 4 2 1 11 9 10 12 3
Hawk HWKAC6, PREPARATION 4 1. Check all nuts and bolts are tight before starting. 2. Before Starting the Compressor; remove cover, connect breather pipe to the oil-hole and attach the air lter. 3. Make sure compressor is in a clean, dry and well ventilated area. 4. Keep voltage within +4% of the rated value. 5. Keep the oil level in the red circle of the oil leveller. 6. For use above 10°C use SAE30 or L-DAB100 compressor oil, For use below 10°C SAE10 or L-DAB68 compressor oil is recommended. 7. Open the outlet valve, set the pressure switch to the “on” position and let the compressor run
Hawk HWKAC6, OPERATION & ADJUSTMENT 5 1. There are two pressure gauges on the compressor: The gauge on the right hand side show the current pressure in the reservoir tank. The gauge on the left shows the outlet pressure, this can be adjusted with the regulating valve. 2. The output pressure of compressed air can be adjusted by the regulating valve. Pull out the regulating valve knob and turn it clockwise to increase pressure. 3. When the running compressor needs to be stopped, set the pressure switch to the o position. 4. As soon as the compressor has been turne
Hawk HWKAC6, 6 1. Never unscrew any connecting parts while the tank is pressured. 2. Never disassemble any electrical parts before disconnecting the plug. 3. Never adjust the safety valve carelessly. 4. Never use the compressor when the voltage is too low or too high. 5. Never use an electric wire more than 5m long with less than a 1.5mm² section rated to 16A. 6. Never disconnect the plug to stop the compressor. Set the switch knob to “o” and follow instructions on page 5. 7. If the release valve doesn’t work when the motor is stopped nd the cause immediately so as not to damage motor. 8. Lubricating oil must be clean;
Hawk HWKAC6, MAINTENANCE 7 1. Do not carry out any maintenance whilst compressor is on - ensure motor is not running, compressed air and condensation is bled and compressor is disconnected from any power supply (see pages 5 + 6). 2. Clean crank case and renew lubricating oil after the rst 10 working hours. 3. Check the oil levels after every use and replenish if necessary. 4. To replenish oil, remove bolt from sump, drain o any old oil and replace with new. Never mix old and new oil. 5. Clean a
Hawk HWKAC6, 8 Trouble Possible causes Remedies Motor unable running, Running too Slow, or Getting hot (1) Fault in line, or voltage insufficient (2) Power wire too thin or too long (3) Fault in pressure switch (4) Fault in motor (5) Sticking of main compressor (1) Check the line (2) Replace the wire (3) Repair or replace (4) Repair or replace (5) Check and repair Sticking of main compressor (1) Moving parts burnt due to the oil insufficient (2) Moving parts damaged, or stuck by
NO PART QTY NO PART QTY 1 Bolt M6×45 8 36 Starting capacitance 1 2 Spring washer 6 8 37 Operation capacitance 1 3 Three angle connecter 1 38 Capacitance cover 1 4 Cylinder head 2 39 Screw ST3.9 x 16 6 5 Cylinder head gasket 2 40 Overload reset 1 6 Valve plate 4 41 Discharge pipe 1 7 Valve slice 4 42 One-way valve 1 8 Aluminiu
Hawk HWKAC6, SAFETY 11 1. Prior to use, become familiar with the instructions given in this manual. In particular, become familiar with the ON/OFF control for stopping the compressor in the event of an emergency. 2. When operating the air compressor, always use eye protection such as goggles, making sure that other people in the work area are also using eye protection. 3. Eye protectors must provide protection from ying particles both from the front and from the side. 4. Hearing protection should be worn when operating this compressor, use ear plugs or ear defenders. 5. Never place your hand near any moving par
Porter-Cable JOB BOSS C3550 Air Compressor Instruction manual
JOB BOSS C3550 |
Craftsman 919.157251 Air Compressor Owner's manual
919.157251 |
Draper DA50 Air Compressor Instruction manual
DA50 |
Air Lift 72000 Air Compressor Installation manual
72000 |
Craftsman 919.155730 Air Compressor Parts manual
919.155730 |
Wagan SKU 47801 Air Compressor Operation & user’s manual
SKU 47801 |
DeVilbiss MG4-OLENG-2B Air Compressor Operation & user’s manual
MG4-OLENG-2B |
Craftsman 919.15216 Air Compressor Owner's manual
919.15216 |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Minolta | EP2051 | Operator's manual | minolta/ep2051-XC4.pdf | 01 Sep 2022 | 101 | |
2 | Hitachi | 2.5-Inch Mobile 5400 RPM 9.5mm Travelstar HTS547575A9E384 | Datasheet | hitachi/2-5-inch-mobile-5400-rpm-9-5mm-travelstar-hts547575a9e384-862.pdf | 21 Feb 2023 | 2 | 0.29 Mb |
3 | Hitachi | EDS-3170A | Brochure & specs | hitachi/eds-3170a-79V.pdf | 27 Sep 2023 | 2 | 0.35 Mb |
4 | Canon | DR-M1060 | Operation & user’s manual | canon/dr-m1060-DID.pdf | 06 Nov 2023 | 88 | |
5 | Ripmax | Super X-Blaze RTR | Instruction manual | ripmax/super-x-blaze-rtr-955.pdf | 07 Aug 2023 | 11 | |
6 | EM Acoustics | Quake MSE-118 | Operation & user’s manual | em-acoustics/quake-mse-118-5G5.pdf | 04 Oct 2023 | 11 |
Craftsman
Owner’s ManualPermanently Lubricated Single Stage PortableAIR COMPRESSOR• Safety Guidelines• Assembly• Operation• Maintenance• Service and Adjustments• Troubleshooting• Repair PartsModel No.919.168700CAUTION: Read the Safety Guidelines and All Instructions Carefully Before Operating.Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S …
919.168700(48 pages) |
Airpress
COMPRESSOR KOMPRESSOR COMPRESSOR COMPRESSEUR COMPRESOR Handleiding Gebrauchsanleitung Instruction manual Manuel d’instructions Manual de instrucciones HL 310/2536839
…
HL 310(48 pages) |
Craftsman
SEARSOWNERSMANUALMODEL NO.919.176850IMPORTANT:Read the Safety Guidelinesand All InstructionsCarefully Before OperatingCRAFTSMAN AIR COMPRESSORASSEMBLYOPERATIONMAINTENANCEREPAIR PARTSRecord in the spaces provided,(1) The model number which can befound on the label on the rear of theair tank.(2) The code number which can befound on the foil label on the rear o …
919.176850(17 pages) |
Airpress
OIL FREEAIR COMPRESSORAIRPRESS LMO 5-240PRODUCT REF.: 36575USER MANUALENFRRUPLNLDEInstruction manual for owner’s use (Translation of the original instructions)Manuel d’utilisation (Traduction des instructions originales)Betriebsanleitung (Übersetzung der Originalanleitung)Gebruiksaanwijzing (Vertaling van de originele instructies)Instrukcje obsługi (T� …
LMO 5-240(21 pages) |
Parkside
IAN 300633AKKU-KOMPRESSOR / CORDLESS COMPRESSOR COMPRESSEUR SANS FIL PAK 20-Li A1 AKKU-LUFTPUMPE / CORDLESS AIR PUMP POMPE À AIR SANS FIL PALP 20-Li A1 COMPRESSEUR SANS FILPOMPE À AIR SANS FILTraduction des instructions d’origine AKKU-KOMPRESSOR AKKU-LUFTPUMPEOriginalbetriebsanleitung CORDLESS COMPRESSORCORDLESS AIR PUMPTranslation of the original in …
PALP 20-Li A1(105 pages) |
Craftsman
Owner's ManualI (RRFTSMRNqPermanently LubricatedPortableAIR COMPRESSORModel No.919.165282• Safety Guidelines• Assembly• Operation• Maintenance• Service and Adjustments• Troubleshooting• Repair PartsCAUTION: Read the Safety Guidelinesand All Instructions Carefully BeforeOperating.Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.Visit …
919.165282(48 pages) |
MTD Snow Blower 31A-2M1A729Manual: MTD 31A-2M1A729 (2AMF85, Upd.09.12.2023) 31A-2M1A729, 48 |
Kettler Fitness Equipment ClassicKettler Classic Fitness Equipment Assembly instructions manual Classic, 24 |
Exo Terra Fog Machine FOGGERExo Terra Fog Machine FOGGER Operating instructions FOGGER, 2 |
Mitsubishi Air Conditioner MSC-GA20VBMitsubishi MSC-GA20VB Air Conditioner Operating instructions manual MSC-GA20VB, 12 |
SLX Extender 27823BMRSLX 27823BMR User Manual (Operation & user’s manual), @5U55NQ 27823BMR, 6 |
NEC Other POWERMATE 2000 POWER-SAVING MODENEC POWERMATE 2000 POWER-SAVING MODE User Manual (Using), @EHL7W4 POWERMATE 2000 POWER-SAVING MODE, 1 |
Sony Digital Camera Cyber-shot 3-295-460-12(1)Digital Camera Handbook (Sony Cyber-shot 3-295-460-12(1)) Cyber-shot 3-295-460-12(1), 154 |
Acer Laptop TravelMate 4150PDF Manual (@K5D3UF), Acer TravelMate 4150 Laptop (Sunday 01-10-2023) TravelMate 4150, 67 |
Konica Minolta Copier bizhub PRO C6501/C6501Pbizhub PRO C6501/C6501P Additional information - 9762T6 bizhub PRO C6501/C6501P, 28 |
Nintendo Video Game Kirby Super Star Ultra 658A61A#QH74VU Kirby Super Star Ultra 658A61A: Nintendo Video Game Owner Documentation Kirby Super Star Ultra 658A61A, 34 |
BMW Automobile 4 seriesBMW 4 series Automobile Owner's manual 4 series, 247 |
Swisher Lawn Mower RT1250ESwisher Product User Guide: RT1250E PDF Owner's manual - 87RK94 RT1250E, 12 |