Manualios.com

Electrolux FMV156DBE Service Manual

Electrolux FMV156DBE Manual Online:

4.6, 967 votes
Electrolux FMV156DBE User Manual
Electrolux FMV156DBE User Guide
Electrolux FMV156DBE Online Manual

Text of Electrolux FMV156DBE User Guide:

  • Electrolux FMV156DBE, 2 FMV156DBE FMV156DSE FMV156DQE FMV156DCF PRECAUTIONS TO BE OBSERVED BEFORE AND DURING SERVICING TO AVOID POSSIBLE EXPO- SURE TO EXCESSIVE MICROWAVE ENERGY (a) Do not operate or allow the oven to be operated with the door open. (b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other microwave source, and make repairs as necessary: (1) interlock operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and other damage), (4) damage to or loosening of hinges and latches, (5) evidence of dropping or ab

  • Electrolux FMV156DBE, 10 FMV156DBE FMV156DSE FMV156DQE FMV156DCF VENTILATION METHODS HOT AIR EXHAUST 1. VERTICAL VENTING For this venting method, hot air rising from the conventional range below is drawn in by the hood fan motor through the grease filters at the right and left sides of the base cover, up through the right and left sides of the oven cavity, then discharged vertically at rear center top of the oven, into the customer's vent system. 2. HORIZONTAL VENTING The air handing is the same as VERTICAL VENTING except that the final air discharge is directed horizontally out from the top rear of the oven into the customer's vent system. 3. RE-

  • Electrolux FMV156DBE, 19 FMV156DBE FMV156DSE FMV156DQE FMV156DCF TEST PROCEDURES PROCEDURE LETTER COMPONENT TEST J HOOD THERMAL CUT-OUT TEST 1. Disconnect the power supply cord, and then remove outer case. 2. Open the door and block it open. 3. Discharge high voltage capacitor. 4. A continuity check across the thermal cut-out terminals should indicate an open circuit unless the temperature of the thermal cut-out reaches approximately 140½F(60½C) or more. At that temperature, the contacts will clo

  • Electrolux FMV156DBE, 26 FMV156DBE FMV156DSE FMV156DQE FMV156DCF Maximum output 70% of maximum output H : GND L : -5V H : GND L : -5V ON ON OFF OFF OFF 24 sec. 8 sec. 16.7 msec. H : GND L : -5V 7 AN3 OUT Back light circuit (Light emitting diodes) driving signal. 8 AN2 IN To input signal which communicates the door open/close information to LSI. Door close "H" level signal (0V). Door open "L" level signal (-5V). 9-10 AN1-AN0 OUT Terminal not used. 11-13 P57-P55 OUT Terminal not used. 14 CNTR0 OUT Signal to sound buzzer (2.0 kHz). A: key touch sound.

  • Electrolux FMV156DBE, 31 FMV156DBE FMV156DSE FMV156DQE FMV156DCF the oven cavity top plate and release the snap band from the hood duct. 5. Remove the hood fan motor from the oven cavity top plate by lifting it up. 6. Now, the hood fan motor is free. 1. Disconnect the power supply cord , remove the oven from wall and remove outer case (Refer to procedure of "Removal of Oven from Wall" and "Outer case Removal".) 2. Open the door and block it open. 3. To discharge the high voltage capacitor, wait for 60 seconds. 4. Remove th

  • 11 FMV156DBE FMV156DSE FMV156DQE FMV156DCF SCHEMATIC NOTE: CONDITION OF OVEN 1. DOOR CLOSED. 2. COOKING TIME PROGRAMMED. 3. VA RI AB LE CO O KI NG CON T ROL "HIGH". Figure O-2. Oven Schematic-Cooking Condition Figure O-1. Oven Schematic-Off Condition SCHEMATIC NOTE: CONDITION OF OVEN 1. DOOR CLOSED. 2. CLOCK APPEARS ON DISPLAY. NOTES: 1.CI

  • Electrolux FMV156DBE, 25 FMV156DBE FMV156DSE FMV156DQE FMV156DCF DESCRIPTION OF LSI LSI The I/O signal of the LSI is detailed in the following table. Pin No. Signal I/O Description 1-2 VL2-VL1 IN Power source voltage input terminal. Standard voltage for LCD. 3-6 AN7-AN4 IN Terminal to change cooking input according to the Model. By using the A/D converter contained in the LSI, DC voltage in accordance with the Model in operation is applied to set up its cooking constant. TOUCH CONTROL PANEL ASSEMBLY OUTLINE OF TOUCH CONTROL PANEL Symbol Voltage A

  • Electrolux FMV156DBE, 18 FMV156DBE FMV156DSE FMV156DQE FMV156DCF TEST PROCEDURES PROCEDURE LETTER COMPONENT TEST H MONITOR SWITCH TEST SECONDARY INTERLOCK RELAY (RY2) 1. Disconnect the power supply cord, and then remove outer case. 2. Open the door and block it open. 3. Discharge high voltage capacitor. 4. Disconnect two (2) wire leads from the male tab terminals of the Secondary Interlock Relay. Check the state of the relay contacts using a ohmmeter. The relay contacts should be open. If the relay contacts are closed, replace the circuit board entirely or the relay itself. 5. Reconnect all leads remov

  • Electrolux FMV156DBE, 34 FMV156DBE FMV156DSE FMV156DQE FMV156DCF fixing plate. 14. Release the two (2) tabs holding the power unit to the key fixing plate. 15. Release the three (3) tabs holding the LCD to the LCD holder. 16. Release the two (2) tabs holding the LSI unit to the LCD holder. 17. Remove the LCD holder and the LED sheet. 18. Now, the control unit is free. 19. Remove the one (1) screw holding the key fixing plate to the control panel. 20. Release the six (6) tabs holding the key fixing plate to the control panel. 21. Remove the key fixing plate from the control panel. 22. Remove the key unit from the key fixing plate. 23. Now, the key unit is free NOTES FOR

  • Electrolux FMV156DBE, 23 FMV156DBE FMV156DSE FMV156DQE FMV156DCF CN - A VRS1 P T1 RY3 (J1) a c d b 7 TEST PROCEDURES PROCEDURE LETTER COMPONENT TEST STEPS OCCURRENCE CAUSE OR CORRECTION 1 Only pattern at "a" is broken. *Insert jumper wire J1 and solder. 2 Pattern at "a" and "b" are broken. *Insert the coil RCILF2003YAZZ between "c" and "d". 6) Make a visual inspection of the varistor. Check for burned damage and examine the transformer with a tester for the presence of layer short-circuit (check the primary coil resistance which is approximately 215Ω ± 10%). If any abnor

  • Electrolux FMV156DBE, 5 FMV156DBE FMV156DSE FMV156DQE FMV156DCF PRODUCT DESCRIPTION GENERAL INFORMATION OPERATION TROUBLESHOOTING GUIDE AND TEST PROCEDURE TOUCH CONTROL PANEL COMPONENT REPLACEMENT AND ADJUSTMENT PROCEDURE WIRING DIAGRAM PARTS LIST ELECTROLUX HOME PRODUCTS, INC. SERVICE MANUAL ELECTROLUX OVER THE RANGE MICROWAVE OVEN FMV156DBE / FMV156DSE FMV156DQE / FMV156DCF FOREWORD This Manual has been prepared to provide Electrolux Home Prod- ucts Service Personnel with Operation and Service Information for the ELECTROLUX OVER THE RANGE MICROWAVE OVENS, FM- V156DBE, FMV156DSE, FMV156DQE, FMV156DCF. It is recommended that service person

  • Electrolux FMV156DBE, 29 FMV156DBE FMV156DSE FMV156DQE FMV156DCF result in severe, possibly fatal, electric shock. (Example) High Voltage Capacitor, Power Transformer, Magnetron, High Voltage Rectifier Assembly, High Voltage Harness etc.. WARNING: Avoid possible exposure to microwave energy. Please follow the instructions below before operat- ing the oven. WARNING AGAINST HIGH VOLTAGE: Microwave ovens contain circuitry capable of producing very high voltage and current, contact with following parts may COMPONENT REPLACEMENT AND ADJUSTMENT PROCEDURE To prevent an electric shock,

  • Electrolux FMV156DBE, 42 FMV156DBE FMV156DSE FMV156DQE FMV156DCF REF. NO. PART NO. DESCRIPTION Q'TY CODE 47 PDUC-B114MRF0 Hood duct L 1 AQ 48 PDUC-B174MRP0 Fan duct 1 AH 49 PDUC-B117MRF0 Orice 1 AC 50 TINSEB386MRR1 Installation instructions 1 AC DOOR PARTS 51 CDORFB410MRK0 Door assembly [FMV156DBD] 1 BB 51 CDORFB413MRK0 Door assembly [FMV156DSD] 1 BB 51 CDORFB414MRK0 Door assembly [FMV156DQD] 1 BB 51 CDORFB411MRK0 Door assembly [FMV156DCE] 1 BB 52 FDORFB086MRT0 Door panel assembly [FMV156DBD/FMV156DCE] 1 AW 52 FDORFB089MRT0 Door panel assembly [F

  • 16 FMV156DBE FMV156DSE FMV156DQE FMV156DCF TEST PROCEDURES PROCEDURE LETTER COMPONENT TEST 1. Disconnect the power supply cord, and then remove outer case. 2. Open the door and block it open. 3. Discharge high voltage capacitor. 4. If the capacitor is open, no high voltage will be available to the magnetron. Disconnect input leads and check for short or open between the terminals

  • Electrolux FMV156DBE, 6 FMV156DBE FMV156DSE FMV156DQE FMV156DCF ITEM DESCRIPTION Power Requirements 120 Volts / 14.1 Amperes 60 Hertz Single phase, 3 wire grounded Power Output 950 watts (IEC TEST PROCEDURE) Operating frequency of 2450MHz Case Dimensions Width 29-15/16" Height 15- 9/16" Depth 16-1/4" Cooking Cavity Dimensions Width 17-11/16" Height 14-15/16" 1.5 Cubic Feet Depth 9-7/8" Hood lamp 2 bulbs, 20W x 2, Incandescent light bulbs Hood fan Approx. 300 C.F.M. (High mode) Control Complement Touch Control System Clock ( 1:00 - 12:59 ) Timer (0 - 99 min. 99 seconds) Microwave Power for Variable Cooking

  • Electrolux FMV156DBE, 13 FMV156DBE FMV156DSE FMV156DQE FMV156DCF TROUBLESHOOTING GUIDE Never touch any part in the circuit with your hand or an uninsulated tool while the power supply is con- nected. When troubleshooting the microwave oven, it is helpful to follow the Sequence of Operation in performing the checks. Many of the possible causes of trouble will require that a specific test be performed. These tests are given a procedure letter which will be found in the "Test Procedure "section. IMPORTANT: If the oven becomes inoperative because of a blown mo

  • Electrolux FMV156DBE, 28 FMV156DBE FMV156DSE FMV156DQE FMV156DCF 1. Precautions for Handling Electronic Components This unit uses CMOS LSI in the integral part of the circuits. When handling these parts, the following precautions should be strictly followed. CMOS LSI have extremely high impedance at its input and output terminals. For this reason, it is easily influenced by the surrounding high voltage power source, static electricity charge in clothes, etc. and sometimes it is not fully protected by the built-in protection circuit. In order to protect CMOS LSI. 1) When storing and transporting, thoroughly wrap them in aluminium foil. Also

  • Electrolux FMV156DBE, 14 FMV156DBE FMV156DSE FMV156DQE FMV156DCF CK = Check / RE = Replace P O S S I B L E C A S E A N D D E FE C T I V E P A R T S P R O B L E M T E S T P R O C E D U R E C O N D I T I O N O F F C O N D I T I O N I D L E C O N D I T I O N M IC R O W A V E C O O K I N G C O N D I T I O N H o m e f u s e b l o w s w h e n p o w e r c o r d i s p l u g g e d i n t o w a l l r e c e p t a c l e . M o n i t o r f u se b l o w s w h e n p o w e r co r d i s p l u g g e d i n t o w a l l r e ce p t a cl e .

  • 24 FMV156DBE FMV156DSE FMV156DQE FMV156DCF TEST PROCEDURES PROCEDURE LETTER COMPONENT TEST Q NOISE FILTER TEST 1. Disconnect the power supply cord, and then remove outer case. 2. Open the door and block it open. 3. Discharge high voltage capacitor. 4. Disconnect the leads to the primary of the power transformer. 5. Using an ohm-meter, check between the terminals as

  • Electrolux FMV156DBE, 45 FMV156DBE FMV156DSE FMV156DQE FMV156DCF 6 4 5 1 2 3 6 4 5 1 2 3 A B C D E F G H A B C D E F G H 31 TURNTABLE TRAY TOP PAD BOTTOM PAD PACKING CASE ACCESSORY PACK WRAP COVER DOOR PAD Non-replaceable items DOOR PROTECTOR GREASE FILTER (x 2) 77 INSTALL MATERIAL ASSEMBLY 61 69 OPERATION MANUAL 70 TOP/WALL TEMPLATE EXHAUST DAMPER ASSEMBLY 78 50 INSTALLATION INSTRUCTIONS PACKING AND ACCESSORIES

  • 17 FMV156DBE FMV156DSE FMV156DQE FMV156DCF TEST PROCEDURES PROCEDURE LETTER COMPONENT TEST 1. Disconnect the power supply cord, and then remove outer case. 2. Open the door and block it open. 3. Discharge high voltage capacitor. 4. Isolate the switch and connect the ohmmeter to the common (COM.) and normally open (NO) terminal of the switch. The meter should

  • Electrolux FMV156DBE, 48 FMV156DBE FMV156DSE FMV156DQE FMV156DCF COPYRIGHT © 2007 BY ELECTROLUX HOME PRODUCTS, INC. ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in retrieval systems, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher.

  • 27 FMV156DBE FMV156DSE FMV156DQE FMV156DCF 34 P26 OUT Key strobe signal. Signal applied to touch-key section. A pulse signal is input to P43-P46 terminal while one of G7 line keys on key matrix is touched. 35 P25 OUT Key strobe signal. Signal applied to touch-key section. A pulse signal is input to P43-P46 terminal while one of G6 line keys on key matrix is touche

  • Electrolux FMV156DBE, 32 FMV156DBE FMV156DSE FMV156DQE FMV156DCF 1. Disconnect the power supply cord, remove the oven from wall and remove outer case (Refer to procedure of "Removal of Oven from Wall" and "Outer case Removal".) 2. Open the door and block it open. 3. To discharge the high voltage capacitor, wait for 60 seconds. 4. Remove the three (3) screws holding the hood intake duct R to the oven cavity top plate, the oven cavity front flange and the fan duct. And remove the hood intake duct R. 5. Remove the one (1) screw holding the hood duct R to the oven cavity top plate. And remove the hood

  • Electrolux FMV156DBE, 4 FMV156DBE FMV156DSE FMV156DQE FMV156DCF MICROWAVE MEASUREMENT PROCEDURE A. Requirements: 1) Microwave leakage limit (Power density limit): The power density of microwave radiation emitted by a microwave oven should not exceed 1mW/cm 2 at any point 5cm or more from the external surface of the oven, measured prior to acquisition by a purchaser, and thereafter (through the useful life of the oven), 5 mW/cm 2 at any point 5cm or more from the external surface of the oven. 2) Safety interlock switches: Primary interlock switch shall prevent microwave radiation emission in excess of the requirement as above mentioned, secondary interlo

  • Electrolux FMV156DBE, P/N 316439263Publication # 5995505459 1 FMV156DBE FMV156DSE FMV156DQE FMV156DCF In the interest of user-safety the oven should be restored to its original condition and only parts identical to those specified should be used. WARNING TO SERVICE PERSONNEL: Microwave ovens contain circuitry capable of producing very high voltage and current. Contact with the following parts may result in a severe, possibly fatal, electrical shock. (High Voltage Capaci- tor, High Voltage Power Transformer, Magnetron, High Voltage Rectifier Assembly, High Voltage Ha

  • Electrolux FMV156DBE, 35 FMV156DBE FMV156DSE FMV156DQE FMV156DCF After adjustment, check the following. 1. In and out play of door remains less than 0.5mm when in the latched position. First check upper position of latch hook, pushing and pulling upper portion of door toward the oven face. Then check lower portion of the latch hook, pushing and pulling lower portion of the door toward the oven face. Both results (play in the door) should be less than 0.5mm. 2. The door sensing switch and primary interlock switch interrupt the circuit before the door can be opened. 3. Monitor switch contacts close when door is opened. 4. Re-install outer

Related Products and Documents (Microwave Oven):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 Kensington KeyCover Quick start manual kensington/keycover-E21.pdf 15 Apr 2023 88
2 CHICAGO 95904 Operating instructions chicago/95904-VVA.pdf 23 Nov 2022 4 1.14 Mb
3 Yale Real View Pro Operation & user’s manual yale/real-view-pro-372.pdf 25 Oct 2022 14
4 Elation TVL2000 User instructions elation/tvl2000-CYC.pdf 12 Oct 2022 10
5 AGASIO A632W Operation & user’s manual agasio/a632w-16A.pdf 24 Dec 2022 24
6 RCA AH56R Manual  rca/ah56r-63U.pdf 28 Oct 2023 1 0.05 Mb

Similar Resources:

  • LG

    MC-8483NL

    (36 pages)
    MICROWAVE OVENSERVICE MANUALMODEL: MC-8483NLCAUTIONBEFORE SERVICING THE UNIT, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.Website http://biz.lgservice.com P/NO : 3828W5S6029September, 2004Printed in Korea …
  • Hansa

    AMM20BIH

    (124 pages)
    RO INSTRUCŢIUNEDEUTILIZAREBG ИНСТРУКЦИЯЗАУПОТРЕБАRU ИНСТРУКЦИЯПОЭКСПЛУАТАЦИИKK ҚЫЗМЕТКӨРСЕТУНҰСҚАУЛЫҒЫEN INSTRUCTIONMANUALUK ІНСТРУКЦІЯЗЕКСПЛУАТАЦІЇAMM20BIH …
  • Samsung

    CE1110

    (3 pages)
    Code No.: DE68-02634A-01MICROWAVE OVENOwner’s Instructions and Cooking GuideCE1110 / CE1111T CE1112M / CE1113F“Quick” Look-up Guide...........................................................................2Using the Steam Cleaning .....................................................................2Oven................................................ …
  • Infiniton

    IMW-20BTN

    (77 pages)
    IMW-20BTNMANUAL DE USUARIOMicroondasLea estas instrucciones cuidadosamente antes de usar su microondas y guárdelas cuidadosamente.Si sigue las instrucciones, su microondas le brindará muchos años de buen servicio.GUARDE ESTAS INSTRUCCIONES CUIDADOSAMENTE …
  • GE

    JVM141J

    (24 pages)
    Spacemaker”Micrwave OvenContentsAdapter Plugs21Minute/Second Timer18Aluminum Foil4Model and Serial Numbers2Appliance Registration2Oven Shelf5, 16, 17Auto Defrost 14, 15Power Levels9-12, 18Auto Roast 12, 13Precautions2-5Auto Simmer13Problem Solver22Auto Start11Safety Instructions2-5Care and Cleaning19,20Temperature Cook11Consumer Services23Temperature Probe …
  • Samsung

    M1912

    (22 pages)
    MICROWAVE OVENM1912SERVICE ManualMICROWAVE OVEN CONTENTS1. Precaution 2. Specifications3. Operating Instructions4. Disassembly and Reassembly5. Alignment and Adjustments6. Troubleshooting7. Exploded Views and Parts List8. Wiring DiagramAMFO …

Comments, Questions and Opinions: