Manualios.com

Frymaster Gas Cooker GBC Service And Parts Manual

Frymaster Gas Cooker GBC Manual Online:

3.5, 2316 votes
Frymaster Gas Cooker GBC User Manual
Frymaster Gas Cooker GBC User Guide
Frymaster Gas Cooker GBC Online Manual

Text of Frymaster Gas Cooker GBC User Guide:

  • Frymaster Gas Cooker GBC, 1-16 WIRING DIAGRAMS 6C 23C 29C 27C 71C 70C 59C 2C 7C 24V 55C 43C 22C 5 6 7 8 4321 SWITCH CENTRIFUGAL COMPUTER LIGHT TROUBLE TEMP. SOUND DEVICE 24 VAC NC NCNC NC SENSOR WATER NORMAL SENSOR WATER LOW PROBE 151413121110987654321 SOLENIOD 1 2 3 4 8 7 6 5 SPLICE SPLICE CORDSET 120 VAC WHITE BLACK VALVE GAS BLOWER 9C 11C 51C 12C 108C 34C GM N.C. N.O. SWITCH MICRO GM GEAR MOTOR BASKET LIFT SHOWN IN UP POSITION SPLIC E SPLIC E LINE LOAD LOAD LINE 24VAC TRANS RELAY. C 9 7 4 6 C A B 2 5 7 24VDC BASKET LIFT 24VAC BASKET LIFT (OPTIONAL) 110

  • Frymaster Gas Cooker GBC, 2-11 ITEM PART # COMPONENT 1 900-7532 Box, Control 2 807-1396 Relay, 24VDC SPDT (Basket Lift Relay – GSMS and GBC units only) 3 810-0045 Bushing, .875 Diameter Hole 4 807-0067 Block, 8-Pin Terminal 5 807-0255 Strip, Terminal 6 Transformer 807-0800 120VAC/24VAC, 50/60 Hz, 50VA 807-0680 208-240VAC/24VAC, 50/60 Hz, 43VA 7 807-3366 Module, Honeywell Dual-Spark FV Ignition (See NOTE below.) 8 807-0670 Relay, 24V DPDT (Heat Relay – all units) 9 900-1924 Guard, Finger 10 826-1371 Screw, #8 x ½-inch Drill Point Hex Head Zinc Plated (Pkg. of 25) 11 807-1713 Sound Device

  • Frymaster Gas Cooker GBC, 1-1 GAS COOKERS GSMS, GBC, AND GC SERVICE AND PARTS CHAPTER 1: SERVICE PROCEDURES 1.1 Functional Description The GSMS, GBC, and GC Gas Cookers all have a 12.7-gallon (48.1-liter) stainless steel cookpot. The water in the cookpot is heated by a high-efficiency infrared heating system that requires approximately 43% less energy than conventional burner systems to heat the same volume of water. Two self-contained combustion chambers (commonly referred to as burners) are located beneath the cookpot. Each combustion chamber is fitted with special ceramic tiles that are heated by the

  • 2-14 2.7.2 Cookpot Insulation 4 5 1 2 9 10 11 12 3 8 7 6 NOTE: Cookpot shown for reference only. Refer to Page 2-13 for cookpot components. Refer to Page 2-8 for ignitor components. ITEM PART # COMPONENT 1 900-4563 Retainer, Cookpot Front Insulation (19.7-inches x 7.5-inches) 2 816-0152 Insulation, Cookpot Front (19.5-inches x 7.5-inches x .25-inches) 3 816-0153 Insula

  • Frymaster Gas Cooker GBC, 2-6 2.3.2 GSMS and GSMS/GBC Batteries NOTE: GSMS-GBC Battery cabinetry consists of one GSMS cabinet and one GBC cabinet battered together using Fryer Joining Plates (9100404), Cabinet Joining Braces (9100177), and Flue Cap Joining Strips (9103122). 1 2 3 4 5 6 7 8 9 10 34 11 12 16 14 15 13 5 17 18 19 20 21 22 23 24 2 29 30 31 32 33 28 27 26 25 See Page 2-4 for Legs

  • 1-13 PROBLEM PROBABLE CAUSES CORRECTIVE ACTION A. Failed 24VAC (blower) relay. Test: Check for 24VAC on Pin 4 of 15-pin connector. A. If voltage is present, replace relay. Burner will not light; trouble light is NOT on, blower is NOT running. B. Failed controller. B. Replace controller. A. Failed blower centrifugal switch. Test: Check for 24VAC at botto

  • Frymaster Gas Cooker GBC, 1-5 1.3.4 Replacing the Pressure Regulator or Solenoid Valve 1. Drain the cookpot and disconnect the cooker from the electrical power supply. Turn off or disconnect the water supply to the cooker. 2. Disconnect the solenoid leads at the push-on connectors. Disconnect solenoid and regulator subassembly at the compression fittings on the water lines running to and from these components. Remove the two screws in the mounting bracket and remove the solenoid and regulator subassembly from the unit. (NOTE: If the cooker is not equipped with the optional Autofill feature, the cookpot wat

  • Frymaster Gas Cooker GBC, 2-17 ITEM PART # COMPONENT 1 826-1374 Screw, #10 x ½-inch Hex Head (Pkg. of 25) 2 810-0691 Tube, Vent 3 Valve, Honeywell Gas (Non-CE) 826-1122 Natural or Manufactured Gas (See NOTE 2.) 826-1123 Propane Gas 4 811-0800 Tube, 12.5-inch Enrichment (See NOTE 1.) 5 813-0004 Elbow, ⅛-inch NPT 90° BM 6 813-0016 Nipple, ⅛-inch NPT x Close BM 7 813-0022 Nipple, ½-inch NPT x Close BM 8 Nipple, ¾-inch NPT BM 813-0137 28.5-inch (used on GSMS units) 813-0257 24.5-inch (used on GBC/GC units) 9 813-0154 Plug, ⅛-inch Hex Head Pipe 10 813-0301 Tee, ¼-inch NPT Male x ⅜-inch Tube Brass (See NOTE 2.) 11 813-0304 Bushing

  • Frymaster Gas Cooker GBC, 2-7 ITEM PART # COMPONENT 1 To p ca p 824-0433 GSMS 824-0473 GSMS/GBC Battery (for rinse tank on left use 824-0921) 2 809-0266 Screw, #10 x ½-inch Philips Truss Head Zinc Plate d 3 806-5487SP Control Panel Assembly, GSMS 4 900-1759 Bracket, Pot Hol d -Down 5 Side, Left or Right Cabinet 910-7377 Stainless Steel 900-7377 Enameled Mild Steel 6 900-4651 Shield, Control Box Wate r 7 900-4644 Mount, GSMS Control Box 8 900-8631 Shield, Cookpot-side Vapo r 9 806-9744 Door Assembly (does not include handle) 806-4487SP Door Pin Assembly 826-1343 Spring, Door Hinge (Pkg. of 10) 810-

  • A-1 APPENDIX A NOTES AND PARTS UNIQUE TO GSW/GWB VARIANTS A relatively small number of GSW/GWB variants have been manufactured. These two variants are very similar to the GC cooker. The principal differences are the use of a thermostat control rather than a computer and button-type water level sensors in the cookpot as opposed to the rod-type used in the GC cooker. There are also minor

  • Frymaster Gas Cooker GBC, 2-19 ITEM PART # COMPONENT 1 806-5565 Valve Assembly, Solenoid 2 826-1374 Screw, #10 x ½-inch Hex Head (Pkg. of 25) 3 809-0454 Nut, ½-inch Conduit 4 810-0907 Elbow, ⅜-inch NPT Compression 5 810-1208 Valve, Pressure Regulator 6 813-0022 Nipple, ½-inch NPT x Close BM 7 813-0302 Elbow, ¼-inch NPT x ⅜-inch Tube Compression 8 813-0412 Faucet, Double-Jointed Pantry 9 813-0448 Elbow, ¼-inch NPT Brass 10 813-0449 Tee, ¼-inch NPT Brass 11 813-0472 Nipple, ¼-inch NPT x 2.5-inch Brass 12 813-0473 Nipple, ¼-inch NPT x

  • Frymaster Gas Cooker GBC, GAS COOKERS GSMS, GBC, AND GC SERVICE AND PARTS CHAPTER 2: PARTS LIST 2-1 2.1 Accessories 5 3 4 8 2 7 6 1 ITEM PART # COMPONENT 1 803-0018 Cup, Single Pasta Portion (Beige) 2 810-2229 Hanger, Wire-Form Basket (extruded aluminum P/N 803-0028 no longer avail- able) 3 803-0205 Rack, Support 4 806-5848SP Kit, Hose (Swirl and Straight w/Fittings) 5 809-0171 Thumbscrew, ¼-20 x 1⅜ 6 823-1910 Basket, GSMS Bulk 7 826-0900 Kit, Chain Restraint 8 910-7540 Strip, GSMS Top Connecting * 803-0200 Rack, 12 Portion Cup * 803-0238 Basket, 5½ x 8½ SS Round Pasta * Not illustrated.

  • 1-3 1. Disconnect the unit from the electrical power supply, the gas supply and the water supply. 2. Disconnect any attached restraining devices. 3. Relocate the unit for service accessibility. 4. After servicing is complete, reconnect the unit to the water supply and the gas supply. Reattach the restraining devices, and reconnect the unit to the electrical power supply.

  • Frymaster Gas Cooker GBC, 2-13 2.7 Cookpot, Rinse Tank, and Associated Components 2.7.1 Cookpot and Rinse Tank Components (Other than Cookpot Insulation) 5 6 3 2 17 8 129 1210 11 13 12 1 4 7 12 14 15 16 ITEM PART # COMPONENT 1 823-4090SP Cookpot, GSMS (Use 823-4227SP for units with manual fill. See NOTE be- low.) 2 806-5497SP Flue Assembly, GSMS (See NOTE below.) 3 823-1994SP Tank, GSMS Rinse * 106-2797SP Complete Burner, Frypot, Flue Auto Fill assembly, NAT * 106-2798SP Complete Burner, Frypot, Flue Auto Fill assembly, PRO * 106-3055SP Complete Burner, Frypot, Flue Manual Fill assembly, NAT * 106-3056SP Complete Burn

  • Frymaster Gas Cooker GBC, 1-11 extinguishing the burners. This process repeats as required to maintain the temperature at the setpoint programmed into the controller. The controller is the interface between the operator and the other components of the equipment. In the water heating system, its function is to control the firing of the burners. 1.4.5 How the Basket Lift System Works When the Start switch is pressed to start the cooking cycle, logic circuits in the controller activate the basket lift motors, lowering the basket into th

  • 1-4 5. Replace the component box cover, and reinstall the controller being sure to reconnect the ground wire and trouble light wires. Reconnect the cooker to the electrical power supply. 1.3.3 Replacing a Water-Level Sensor or the Temperature Probe 1. Drain the cookpot and disconnect the cooker from the electrical power supply. 2. Remove the screws in the

  • Frymaster Gas Cooker GBC, 2-10 2.5 Control Box and Related Components 1 4 5 10 8 26 262 3 1054 266 277 12 11 9 10 17 14 13 15 12 17 16 18 19 9 20 21 22 23 24 25 28 See NOTE NOTE: Item 23 is for use with 807-3366 ignition module (Item 7) and requires a RAJAH connector (Item 28). Item 24 is for use with 807-1006 ignition module and does not require a RAJAH connector.

  • Frymaster Gas Cooker GBC, A-5 Item Part # Component 1 806-7551 Valve Assembly, GSMS Solenoid 2 809-0454 Nut, ½-inch Conduit 3 810-0907 Elbow, ⅜-inch NPT Compression 4 810-1025 Fitting, ¼-inch Straight Compression 5 810-1208 Valve, Water Pressure Regulator 6 812-1292 Tubing, Straight 21.75-inch Regulator to Solenoid Valve 7 812-1293 Tubing, 90° Formed 39.22-inch Regulator to Solenoid Valve 8 813-0022 Nipple, ½-inch Close BM NPT 9 813-0302 Elbow, ¼-inch NPT X ⅜-inch Tube 10 813-0448 Elbow, ¼-inch Brass NPT 11 813-0

  • Frymaster Gas Cooker GBC, 2-18 2.10 Water Supply System Components Item 6 (nipple) is threaded into item 1 (solenoid). Item 3 (nut) is threaded onto item 6 to secure item 14 (mount) to item 1. 1 6 2 3 14 Detail A 4 15 13 7 5 11 7 9 12 10 8 See Detail A. Autofill Piping Assembly with Faucet 4 15 5 11 7 1 16 17 Autofill Piping Assembly without Faucet Manual Fill Piping Assembly 7 23 24 22 21 20 18 19

Related Products and Documents (Cooktop):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 LG WT-R10806 Owner's manual lg/wt-r10806-Z1Z.pdf 22 Mar 2023 36
2 NetComm N150 Operation & user’s manual netcomm/n150-41V.pdf 03 Oct 2023 61
3 Haier HRF15N3 Installation and user manual haier/hrf15n3-UJ5.pdf 31 Dec 2022 44
4 Champion Power Equipment 71330 Owner's manual & operating instructions champion-power-equipment/71330-485.pdf 20 Feb 2024 30 7.35 Mb
5 TEFAL LE HACHOIR 1800 Manual  tefal/le-hachoir-1800-G52.pdf 26 May 2023 90 1.28 Mb
6 GE GXSF30V Owner's manual and installation instructions ge/gxsf30v-I3C.pdf 25 Jul 2023 72 5.46 Mb

Similar Resources:

  • AGA

    DC5

    (20 pages)
    105/18 EOPI 516636AGA DUAL CONTROLDC3 & DC5(External Vent & Room Vent Option)For use in GB & IEPLEASE READ THESE INSTRUCTIONS BEFORE USING THIS APPLIANCE AND KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.User GuideCAUTION: THIS UNIT IS HEAVY, PROPER EQUIPMENT AND ADEQUATE MANPOWER MUST BE USED IN MOVING THE RANGE TO AVOID DAMAGE TO THE UNIT OR THE F …
  • Smeg

    PGF75SCU3

    (5 pages)
    Important Safety Instruction3IMPORTANT SAFETY INSTRUCTIONSREAD AND SAVE THESE INSTRUCTIONS – Your Safety And the Safety of Others Are Very Important.We have provided many important safety messages throughout this manual and on your appliance.Read all instructions before using your appliance and always obey all safety messages.RECOGNIZE SAFETY INFORMATIONTh …
  • Kenmore

    79075232310

    (20 pages)
    INSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER.IMPORTANT: SAVE FOR LOCAL ELECTRICAL INSPECTOR'S USE. READ AND SAVE THESEINSTRUCTIONS FOR FUTURE REFERENCE.Tip Over Hazard• A child or adult can tip the rangeand be killed.• Verify the anti-tip device has beeninstalled to floor or wall.• Ensure the anti-tip device is re-engaged wh …
  • AGA

    GC3 (P/F)

    (20 pages)
    03/10 EINS 515926PLEASE READ THESE INSTRUCTIONS BEFORE INSTALLING THIS APPLIANCEREMEMBER: when replacing a part on this appliance, use only spare parts thatyou can be assured conform to the safety and performance specification that werequire. Do not use reconditioned or copy parts that have not been clearlyauthorised by AGA.For use in GB and IEInstallationIn …
  • Miele

    KM 6310

    (72 pages)
    Operating and Installation instructionsCeramic Cooktop with inductionKM 6310KM 6344To prevent accidents andappliance damage,read these instructionsbeforeinstallation or use.M.-Nr. 09 166 590en-CA …
  • Hotpoint

    RGA524EW

    (2 pages)
    Created 8/96RGA524PW—24" Compact Gas RangeDimensions (in inches) Installation Information (in inches)All GE ranges are equipped withan Anti-Tip device. The installationof this device is an important,required step in the installation of the range.Electrical Rating: 120V, 60Hz, 5AInstallation Information: Beforeinstalling, consult installation instruct …

Comments, Questions and Opinions: