Manualios.com

Generac Power Systems 005802-2 Owner's Manual

Generac Power Systems 005802-2 Manual Online:

4.15, 1342 votes
Generac Power Systems 005802-2 User Manual
Generac Power Systems 005802-2 User Guide
Generac Power Systems 005802-2 Online Manual

Text of Generac Power Systems 005802-2 User Guide:

  • Generac Power Systems 005802-2, Thank you for purchasing this model by Generac Power Systems, Inc. This model is a compact, high performance, air-cooled, engine driven generator designed to supply electrical power to operate electrical loads where no utility power is available or in place of utility due to a power outage. If any portion of this manual is not understood, contact the nearest Authorized Dealer for starting, operating and servicing procedures. The operator is responsible for proper and safe use of the equipment. We strongly recommend that the operator read this manual and thoroughly understand all instructions before using the equipment. We also strongly recomme

  • Generac Power Systems 005802-2, 13 Use NGK BPR6HS spark plugs or equivalent. Replace the plugs once each year. This will help the engine start easier and run better. 1. Stop the engine and pull the spark plug wires off of the spark plugs. 2. Clean the area around the spark plugs and remove them from the cylinder heads. 3. Set the spark plug gaps to .76 mm (0.030 in.). Install the correctly gapped spark plug into each cylinder head (Figure 12). 4. Push the boots firmly on the spark plugs. Figure 12  Spark Plug Gap The engine will not run properly and may be damaged if using a dirty a

  • Generac Power Systems 005802-2, www.generac.com or 1-888-GENERAC Owner's Manual XG Professional Series Portable Generator MODEL: 005802-2 DEADLY EXHAUST FUMES! ONLY use OUTSIDE far away from windows, doors and vents! NOT INTENDED FOR USE IN CRITICAL LIFE SUPPORT APPLICATIONS. SAVE this Manual. Provide this manual to any operator of the generator.

  • Generac Power Systems 005802-2, Use a NEMA 14-50 plug with this receptacle. Connect a 4-wire cord set rated for 250 Volts AC at 50 Amps to the plug (Figure 6). Use this receptacle to operate 120/240 Volt AC, 60 Hz electrical loads requiring up to 10,000 watts (10.0 kW) of power at 41.6 Amps for 240 volts or two independent 120 Volt loads. This receptacle is protected by a 42 Amp 2-pole circuit breaker and must be in the ON position for all the other receptacles to provide output power. Figure 6 - 120/240 VAC, 50 Amp Receptacle % NOTE: Receptacles may be marked with rating values greater than generator output capacity. See the "To Start the Engine" section for how to safely start and

  • Under certain weather conditions (temperatures below 40° F (4° C) and a high dew point), the engine may experience icing of the carburetor and/or the crankcase breather system. To eliminate this problem, this generator engine is fitted with a winter/summer valve. This directs hot air into the carburetor during cold weather operation. Always make sure the winter/summer valve is in the cor

  • Figure 7  Generator Ground Location DO NOT connect 240 Volt loads to 120 Volt receptacles. DO NOT connect 3-phase loads to the generator. DO NOT connect 50 Hz loads to the generator.  Let engine stabilize and warm up for a few minutes after starting.  Plug in and turn on the desired 120 or 240 Volt AC, single phase, 60 Hz electrical loads.  Add up the rated watts (or a

  • Generac Power Systems 005802-2, 18 GENERAC POWER SYSTEMS “TWO YEAR” LIMITED WARRANTY FOR GP, LP, XG AND XT SERIES PORTABLE GENERATORS For a period of two (2) years from the date of original sale, Generac Power Systems, Inc. (Generac) warrants its GP, LP, XG and XT Series generators will be free from defects in materials and workmanship for the items and period set forth below. Generac will, at its discretion, repair or replace any part that, upon examination, inspection and testing by Generac or a Generac Authorized Warranty Service Dealer, is found to be defective. Repair or replacement pursuant to this limited warranty shall not renew or extend the original warranty period. Any repaired produ

  • Generac Power Systems 005802-2, 16 Warranty U.S. EPA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The United States Environmental Protection Agency (EPA) and Generac Power Systems, Inc. (Generac) are pleased to explain the Emission Control System Warranty (ECS Warranty) on your new 2011 and later equipment. New equipment that use small spark-ignited engines must be designed, built, and equipped to meet stringent anti-smog standards for the federal government. Generac will warrant the emission control system on your equipment for the period of time listed below provided there has been no abuse, neglect, unapproved modification

  • Generac Power Systems 005802-2, 3  Do not insert objects through unit’s cooling slots. • Do not operate the generator if connected electrical devices overheat, if electrical output is lost, if engine or generator sparks or if flames or smoke are observed while unit is running.  Keep a fire extinguisher near the generator at all times. In the absence of pertinent standards, codes, regulations and laws, the published information listed below may be used as a guideline for operation of this equipment. Always reference the latest rev

  • Generac Power Systems 005802-2, 15 PROBLEM CAUSE CORRECTION Engine is running, but no AC output is available. 1. Circuit breaker is open. 2. Poor connection or defective cord set. 3. Connected device is bad. 4. Fault in generator. 5. GFCI trips the 20 Amp outlet. 1. Reset circuit breaker. 2. Check and repair. 3. Connect another device that is in good condition. 4. Contact Authorized Service Facility. 5. Repair the "short" and reset the GFCI. Engine runs well but bogs down when loads are connected. 1. Short circuit in a connected load. 2. Generator is overloaded. 3. Engine speed is too slow. 4. Shorted generator circuit. 1. Disconnect shorted ele

  • 19 THIS WARRANTY IS IN PLACE OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED. SPECIFICALLY, GENERAC MAKES NO OTHER WARRANTIES AS TO THE MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Any implied warranties allowed by law shall be limited in duration to the terms of the express warranty provided herein. Some states do not allow limitations on how long an implied warranty lasts, so

  • Generac Power Systems 005802-2, Introd uction ............................................................. 1 Read this Manual Thoroughly ................................. 1 Safety Rules ........................................................... 1 Standards Index .............................................................3 General Information ................................................ 4 1.1 Unpacking ......................................................................4 1.2 Assembly .......................................................................4 Operation ................................................................

  • Generac Power Systems 005802-2, The Environmental Protection Agency (EPA) requires that this generator comply with exhaust and evaporative emission standards. This generator is certified to meet the applicable EPA emission levels on gasoline. The emission control system on this generator consists of the following:  Air Induction System  Ignition System ~ Intake Pipe / Manifold ~ Spark Plug ~ Air Cleaner ~ Ignition Module  Fuel System  Exhaust System ~ Carburetor ~ Exhaust Manifold ~ Fuel Tank / Cap ~ Muf

  • Generac Power Systems 005802-2, 14 Figure 14  Spark Arrestor Screen The generator should be started at least once every seven days and be allowed to run at least 30 minutes. If this cannot be done and the unit must be stored for more than 30 days, use the following information as a guide to prepare it for storage. NEVER store engine with fuel in tank indoors or in enclosed, poorly ventilated areas where fumes may reach an open flame, spark or pilot light as on a furnace, water heater, clothes dryer or other gas appliance. Allow unit to cool entirely before stor

  • Generac Power Systems 005802-2, 17 Warranty EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty (ECS Warranty) for equipment using small spark-ignited engines: (a) Applicability: This warranty shall apply to equipment that uses small off-road engines. The ECS Warranty period shall begin on the date the new equipment is purchased by/delivered to its original, end-use purchaser/owner and shall continue for the lesser of: (1) The period of time specified in the Generac Limited Warranty enclosed herewith, but not less than 24 months, or (2) For engines equipped with hour meters, a number of operating hours equal to half of the engine’s useful life. The useful life is specified on the Emissi

  • Generac Power Systems 005802-2, *Submersible Pump (1 HP) . . . . . . . . . . . . . . . . . . . . . . . . . . . 2000 *Submersible Pump (1/2 HP) . . . . . . . . . . . . . . . . . . . . . . . . . . 1500 *Sump Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .800 to 1050 *Table Saw (10") . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1750 to 2000 Television . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .200 to 500 Toaster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1000 to 1650 Weed Trimmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 500 * Allow 3 times the listed watts for starting

  • Generac Power Systems 005802-2, 5 Read the entire Owner’s Manual and Safety Rules before operating this generator. Compare the generator to Figures 3 through 6 to become familiarized with the locations of various controls and adjustments. Save this manual for future reference. 1. Choke Knob – Used when starting a cold engine (Pull/Push). 2. Engine Switch – Controls the operation of the generator. On this electric start model the switch is Start/Run/Stop. 3. Fuel Shut Off – Valve between fuel tank and carburetor. Turn off and run carburetor out of fuel for extended storage. 4. Panel LED's – Provide illumination of the control panel while the generator is operating. 5. 120/240 Volt AC

  • Generac Power Systems 005802-2, 2  Never use the generator or any of its parts as a step. Stepping on the unit can stress and break parts, and may result in dangerous operating conditions from leaking exhaust gases, fuel leakage, oil leakage, etc.  On electric start models, disconnect the POSITIVE (+) battery cable from the engine starter OR the NEGATIVE (-) battery cable from the battery terminal, whichever is easier, before transporting the generator. EXHAUST & LOCATION HAZARDS • Never operate in an enclosed area or indoors! NEVER use in the home, in

More Instructions:

DOWNLOAD

Related Products and Documents (Portable Generator):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 Pioneer MRX-5 Advanced manual pioneer/mrx-5-5G9.pdf 29 Aug 2023 275
2 1Life Simplify GM:shooter Operation & user’s manual 1life-simplify/gmshooter-QA3.pdf 23 Jul 2023 32
3 Casio CTK-500 Service manual casio/ctk-500-QE2.pdf 25 Jan 2024 21 1.64 Mb
4 Delfield 403 Standard Specification sheet delfield/403-standard-RQZ.pdf 13 Dec 2023 2 0.17 Mb
5 Doyon PIZ3G Manual  doyon/piz3g-64C.pdf 18 Dec 2022 57 1.52 Mb
6 Toshiba HCV-1JBU Vacuum Contactor, 1.5kV - 600A HCV-1KAU Vacuum Contactor, 1.5kV - 720A Instruction manual toshiba/hcv-1jbu-vacuum-contactor-1-5kv-600a-hcv-1kau-vacuum-contactor-1-5kv-720a-Z73.pdf 20 Mar 2023 30 0.96 Mb

Similar Resources:

  • MULTIQUIP

    DCA-180SSV

    (84 pages)
    PARTS AND OPERATION MANUALOPERATION AND PARTS MANUALRevision #1 (04/14/10)THIS MANUAL MUST ACCOMPANYTHE EQUIPMENT AT ALL TIMES.WHISPERWATTTM SERIESMODEL DCA-180SSV60 Hz GENERATORPARTS LIST NO. C0870301204Serial Number 3770213~ …
  • Mecc Alte

    ECO 28 S

    (76 pages)
    Mecc alte spaAlternateurs Alternators Alternadores Generatoren Alternatori SERIE ECO Réf. constructeur : Settembre 2003 - rev.12 Réf. GPAO : 33522044201 ind1 Manuel d’utilisation et d’entretienUsers guide and maintenance manual Manual de servicio y de mantenimiento Bediens- und Gebrauchanleitung Manuale d’uso e d …
  • Grandstream Networks

    005261-0

    (64 pages)
    STANDBY GENERATOROWNER'S MANUALThis manual should remain with the unit.A new standard of reliabilitySerial NumberQT2.4L45kWModel: 005261-0—CAUTION—ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!Cover043 Rev. 0 02/06Part No. 0G0201 …
  • Briggs & Stratton

    30348

    (48 pages)
    Manual No. 203476GS Revision A (04/16/2007)BRIGGS & STRATTON POWER PRODUCTS GROUP, LLCJEFFERSON, WISCONSIN, U.S.A.3500 Watt Portable GeneratorOperator’s Manual …
  • EcoFlow

    River 600

    (12 pages)
    Contact us:[email protected] Guide WARNING1. Please keep the product dry, do not expose it to high heat. Pay attention to the safety when carrying the product.2. Never disassemble, puncture, shock, crash, or incinerate the product or the accessories.3. After removing the package, the Max Module must be installed with RIVER 600 in time. P …
  • Wacker Neuson

    G 240

    (200 pages)
    www.wackerneuson.com0620301 11009.2010Mobile GeneratorsMobile GeneratorenGeneradores MóvilesGroupes électrogénesG 240Parts BookErsatzteileLista de RepuestosListe de Pièces de RechangePlantas de luz wacker G 240s | VENTA y RENTAAutek Maquinaria ¡Llámenos! (55) 5392-7077 …

Comments, Questions and Opinions: