Honda CD Changer Installation Instructions Manual

Text of Honda CD Changer User Guide:

• Honda CD Changer, © 2001 American Honda Motor Co., Inc - All Rights Reserved. AII 23268 (0110) 1 of 10 INSTALLATION INSTRUCTIONS Accessory Application Publications No. Issue Date OCT 2001 08B26-S3Y-1000-91 INSIGHT CD CHANGER ATTACHMENT KIT PARTS LIST CD Changer Attachment Kit: P/N 08B26-S3Y-100 CD changer trim Front bracket Rear bracket Front base bracket Rear base bracket 6 EPT sealers 10 Cushion tapes 13 Short wire ties (1 not used) 8 Washer-screws, 4 x 8 mm 4 Washer-bolts, 6 x 16 mm 4 Clip nuts 2 Clips 4 Self-tapping screws 4 Flange nuts

• Honda CD Changer, 2 of 10 AII 23268 (0110) © 2001 American Honda Motor Co., Inc - All Rights Reserved. TOOLS AND SUPPLIES REQUIRED #2 Phillips screwdriver Flat-tip screwdriver Stubby Phillips screwdriver 10 mm Combination wrench Ratchet 10 mm Socket Diagonal cutters Utility knife Tape measure Gloves BUS CORD BOLTS CD CHANGER (sold separately) GLOVE BOX Illustration of the CD Changer Installed on the Vehicle INSTALLATION Customer Information: The information in this installation instruction is intended for use only by skilled technicians who have the proper tools, equipment, and

• Honda CD Changer, © 2001 American Honda Motor Co., Inc - All Rights Reserved. AII 23268 (0110) 3 of 10 5. Remove the self-tapping screws that fasten the radio, and pull the unit out toward you. Unplug the vehicle harness connector and the antenna lead from the rear of the radio. 6. Remove the driver's door sill trim (four retaining clips). 7. Detach the clips, and pull the driver's side cowl carpet down and out of the way. ANTENNA LEAD 8. Remove the B-pillar lower trim panel (four retaining clips). Take care not to damage the retaining cl

• Honda CD Changer, 4 of 10 AII 23268 (0110) © 2001 American Honda Motor Co., Inc - All Rights Reserved. 9. Remove the four expansion clips that fasten the floor carpet, and fold the carpet down and out of the way. Routing the BUS Cable 12. Route the BUS cable above the steering shaft, and secure it to the vehicle harness with four short wire ties in the areas shown. FLOOR CARPET (Fold down.) 13. Route the BUS cable down alongside the fuse box, and secure it to the body panel with one cushion tape. Secure the BUS cable to the vehicle harness with the two short wire ties. (Position the BUS cable connector flush with the radio co

• Honda CD Changer, © 2001 American Honda Motor Co., Inc - All Rights Reserved. AII 23268 (0110) 5 of 10 14. Continue routing the BUS cable toward the rear of the vehicle. Measure 35 mm below the door opening, and secure the BUS cable to the body with four cushion tapes. 16. Open the tailgate, and remove the cargo floor mat. 15. Secure the BUS cable to the vehicle harness with one short wire tie in the area shown. VEHICLE HARNESS 18. Remove the rear side trim panel (three expansion clips). CARGO BOX SHORT WIRE TIE 35 mm CUSHION TAPES CARGO FLOOR MAT TAILGATE 17. Remove the cargo box. RELAY EXPANSION CLIP LEFT TRUNK SIDE BOARD WASHER-BOLT 19. Remove the left trunk side

• Honda CD Changer, 6 of 10 AII 23268 (0110) © 2001 American Honda Motor Co., Inc - All Rights Reserved. 22. Remove the three clips, and fold down the top portion of the middle carpet. If the vehicle you are working on is equipped with rear speakers, remove the speakers and rear speaker holders. 24. Attach one cushion tape around the lower edge of the hole in the inner panel; then route the BUS cable toward the rear over the cushion tape. Secure the BUS cable to the inner panel with additional cushion tape. BUS CABL

• Honda CD Changer, © 2001 American Honda Motor Co., Inc - All Rights Reserved. AII 23268 (0110) 7 of 10 Installing the CD Changer 26. Carefully unpack the CD changer. Remove the three shipping clips, and discard the shipping cover. Save the shipping clips for your customer in the event the unit needs to be serviced. 28. Visually check the location of the spring adjusting pins on both sides of the CD changer. If the spring adjusting pins are not in the vertical (V) position, move the pins to the vertical (V) position with a small flat-tip screwdriver. 29. Remove the backing from the two adhesive covers, and attach one cover to

• 8 of 10 AII 23268 (0110) © 2001 American Honda Motor Co., Inc - All Rights Reserved. 32. Place the CD changer trim on the CD changer, and install the four self-tapping screws. 35. Remove the vehicle harness clip from the hole in the inner panel. 36. Slide one clip nut onto each of the four holes in the inner panel. CD CHANGER TRIM CLIP NUT 33. Remove 40 to

• Honda CD Changer, © 2001 American Honda Motor Co., Inc - All Rights Reserved. AII 23268 (0110) 9 of 10 REAR BRACKET STUDS EPT SEALER EPT SEALER 6 x 16 mm WASHER-BOLT FRONT BASE BRACKET REAR BASE BRACKET 6 x 16 mm WASHER-BOLT EPT SEALER (Cut in half.) FRONT BRACKET STUDS FLANGE NUTS 38. Cut one piece of EPT sealer in half. Attach the halves to the rear clip nuts you installed in step 36. 42. Position the CD changer on the studs extending from the front and rear base brackets, and install the four flange nuts. Install the CD changer first on the front bracket, then the rear br

• 10 of 10 AII 23268 (0110) © 2001 American Honda Motor Co., Inc - All Rights Reserved. BUS CABLE Cut across. BASE BRACKET LONG WIRE TIE BUS CABLE CONNECTOR CD CHANGER BASE BRACKET CLIPS LEFT TRUNK SIDE BOARD A B C BACK OF LEFT TRUNK SIDE BOARD D CD CHANGER 135 mm 45. Secure the BUS cable connector to the vehicle harness 135 mm away from the vehicle harness clip with one long wir

Related Products and Documents (CD Player):

Comparable Devices:

Similar Resources:

• Sony MZ-E10 (40 pages) Battery life1)(Unit: Approx. hours) (JEITA2))Batteries SP Stereo LP2 LP4(normal) Stereo StereoLithium-ion 23 33 40built-inrechargeablebattery3)1) Measured with the power save function on (see “ Preserving battery power” ).2) Measured in accordance with the JEITA (Japan Electronics and Information Technology Industries Association) standard (using a So …

• Philips CD713 (2 pages) CD713CD Player700+ Series CD Player•Bitcheck D/A Conversion Provides digital to analogue conversion down to the last bit; thereby optimally translating the bitstream back into the original audio signal•CD-Rewritable playback Allows Audio playback of CD-Rewritable discs (and CD Recordable discs) recorded on either PC or CD-Rewritable recorders•Edit and …

• Sony CDX-GT34W - Fm/am Compact Disc Player (36 pages) SERVICE MANUALSony CorporationAudio&Video Business GroupPublished by Sony Techno Create CorporationSPECIFICATIONS9-889-584-012009G04-1© 2009.07US ModelCDX-GT34W/GT340Canadian ModelCDX-GT34WVer. 1.0 2009.07• The tuner and CD sections have no adjustments.Model Name Using Similar Mechanism CDX-GT23W/GT24/GT24EECD Drive Mechanism Type MG-101L-188//QOpti …

• Harman Kardon HD720 (20 pages) Harman KardonHD720Compact Disc PlayerOwner’s ManualStop/Clear SearchPlay Pause PhonesPhones LevelDisplayTimeRandomProgramProgramCheckRepeatSkipOpen/CloseTOTALOVER ›MIN SECTRACK1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20flHD720 –120V Owner's Manual 9/17/98 9:54 AM Page 18 …

• Philips EXP3373 (2 pages) Portable MP3-CD PlayerComplete MP3-CD experience• More than 10 hours of MP3 or 20 hours WMA music on one CD• Play CD, CD-R and CD-RW discs• Dot matrix LCD displays artist name and song titleSound Station• Intergrate charging, amplifying and audio output in one system• 2 x 1.5W power for good sound quality• PDA type connector with visible LED indi …

• Trigon Recall II (16 pages) OPERATING INSTRUCTIONS FOR CD-PLAYER Recall IIRecall IIRecall IIRecall II OPEN << < > >> START STOPREPEATPROGRAMTIMERecall II Version 2, Feb. 2009 …

Comments, Questions and Opinions: