Ingersoll-Rand SS3 Owner's Manual
|
Ingersoll-Rand SS3, ingersoll Owner's Manual Installation, Operation and Maintenance Instructions for Models SS3 and SS5 Stationary Air Compressors IMPORTANT INFORMATION! READ AND FOLLOW THESE INSTRUCTIONS. RETAIN FOR REFERENCE. ll_*-]r-1=1ulli" DEFINITIONS /k_ WILL cause DEATH, SEVERE INJURY or substantial property damage WARNING CAN cause DEATH, SEVERE INJURY or substantiaI property damage, CAUTION WILL or CAN cause MINOR INJURY or property damage. GENERAL SAFETY PRECAUTIONS ,_ _ iNTAKE AIR, Can contain carbon m
Ingersoll-Rand SS3, SELECTINGA LOCATION GENERAL° Select a clean, dry, welt-lighted indoor area with plenty of space far proper cooling air flow and accessibility. Locate the unit at least 12 inches (30 cm) from wails, and make sure the main power supply is clearly identified and accessible TEMPERATURE.. Ideal operating temperatures are between 32"F and 100°F (0°C and 37.B_C) If temperatures consistently drop below 32°F (0"C), locale the unit inside a heated building !f th_s is not possible, you must protect safety!relief valves and drain valves from freezing CAUTION Never operate in temperatures below 20°F (_6.6°C) or above 125°F (5t.0°C).. HUMID AREAS. In frequently humid areas, moisture ma
Ingersoll-Rand SS3, connected to the same circuit, the total electrica! load must be considered in selecting the proper wire size DO NOT USE UNDERSIZE WIRE FUSES., Refer to the National Electric Code to determine the proper fuse or circuit breaker rating required. When selecting fuses, remember the momentary starting current of an electric motor is greater than its full load current Time-delay or "slow-blow" fuses are recommended. Single-Phase Wiring uJ L=J L1 T = Supply Line Terminal L = Load Terminal used disconnecLorclrcu_tbreaker Pressure switch (inctltde_ on/auto-off switch) Singie phase m_or COMPRESSOR
NORMAL START-UP 1 Set the pressure switch lever to "OFF" 2 Close the service valve 3 Attach hose and accessory 4., Move the pressure switch lever Io "ON/AUTO _ The coil will start 5. Allow tank pressure to build The motor will stop when tank pressure reaches cut-out pressure, 6 Open the service valve The unit is now ready for use. NOTE When the receiver tank
Ingersoll-Rand SS3, Followthe procedures outlined below to correctfy set and measure belt tension 1. Lay e slraight edge across the top outer surface of the belt drive from pulley to sheave 2. At the cen_.arof the span. perpendicular !o the bait. apply pressure to the outer surface of the bell with a tensiongauge Force the belt to the deflection indicated in the table at right Compare the reading on the tension gauge to the following t.able t0.9, I .0 I 0.o J Ensure the pulley and sheave are properly aligned and fhe motor anchor screws are adequately retightened prior to restarting the compressor CAUTION Impro
Ingersoll-Rand SS3, ld :(0] II :| II:l"l_'[*Ia]l dI_ [{glm m,_ PROBLEM POSSIBLE CAUSE Abnormal piston, ring or 1 Lubricant viscosity too tow cylinder wear 2 Lubricant level too law 3 Detergent type lubricant being used 4 Cylinder(s) or piston(s) scratched, worn or scored 5 Extremely dusty atmosphere 6 Worn cylinder finish Air delivery drops off U_it does not come up to speed Unit ts slow Io come up to speed Unit runs excessively hot Excessive noise durtng operation Excessive starting and stepping High ellconsumption 1 Ctogged or dirty inlet and/or discharge line fitter 2 Atr leaks tn air discharge piping 3 Lubricant viscosity too high 4 Compressor valves lea
Ingersoll-Rand SS3, PROBLEM Knocking or retlting Lights flicker or dim when running Moisture in crankcase or "milky" appearance in pelroleum lubricant or rusling in cylinders Motor ovedoad trips or draws excessive current Motor will not start Oit in discharge air (oil pumping) Oil leakinc 1from shaft seal Safety/relief valve "pops" POSSIBLE CAUSE t, Loose beltwheel or motor pulley, excessive end play in motor shaft or loose drive belts 2 Compressor valves leaky, broken, carbonized or loose 3, Carbon build-up on top elf piston(s) 4 Cylindei'{s} or piston(s) scratched, w
WARRANTY Ingersoll-Rand Company warrants that the Equipment manufactured by it and defivered hereunder shall be free of defects in material and workmanship for a period of twelve (I2) months from the date of placing the Equipment in operation or eighteen (18) months from the date of shipment, whichever shall occur first. The foregoing warranty period shall apply to all Equipmen
Ingersoll-Rand SS3, INGERSOLL-RANDo AIR COMPRESSORS Ingersoll-Rand Company 800-B Beery Street P.O Box 1803 Davidson, NC 28036 1-800 AIR SERV www_atr ingersoU-rand 1corn PARTS LIST FOR MODEL SS5 BARE COMPRESSOR PUMP 45 LISTA DE PIEZAS PARA MODELO SS5 BOMBA COMPRESORA SIN ACCESORIOS LISTE DE PII_CES POUR COMPRESSEUR NU, MODELE SS5 Piston R}ng S_quenc_ Se_encla de ani_lo_;de ptst6n S_quence des segments 47 / 4 32 25-- 30 31 _| 35 8 9 42 19 18 2O 27 35 -- / 44 6-3 @Ingersoll-Rand Company Printed in U S A Form SCD-876 December 1999
Ingersoll-Rand SS3, DESCRIPCt0N DESCRIPTION REF NO PART NO QTY N_ DE REF. N_ DE PIEZA DESCRIPTION CANT. N= DE REP. N" DE PIECE QTY. REF, 97334148 PUMP, BARE COMPRESSOR BDMBA COMPRESORA SIN ACCESORIOS COMPRESSEUR NU X 1 20102703 SET, PISTON RING CON JUNTO DE ANILLOS DE PISTON JEU DE SEGMENTS 2 2 NSS e RING, COMPRESSION • ANILLO DE COMPRES{0N • SEGMENT DE COMPRESSION 1 3 NSS • RING, SCRAPER e ANILLO RASCADOR I SEGMENT RACLEUR A _PAULEMENT 1 4 NSS • RIND, OiL CONTROL SPACER • ANILLO ESPACIADOR REGULADOR DE ACEfTE • SEGMENT D'ESPACEMENT 2 5 NEE • RIND, OIL CONTROL • ANILLO REGULADOR DE ACEWE • SEGMENT RACL
Ingersoll-Rand SS3, ingersoliRand Parts List for Models SS5L5 & SS5N5 7 ..4 22.24 -- 3 • 26- 10- 23.2.5 - 11- ', -- " " ....... <_-17, ,_ . " 15 21 iTq--_,-', F4"-,_ i 13 REF NO PART NO DESCRIPTION OTY 84G03724 CAPSCREW 4 2 95750394 WASHER, SPRING LOCK 4 3 9733.148 PUMP. BARE COMPRESSOR I 4 ASSEMBLY, COMPLETE BELTGUARD 1 5 _188518 BRACE, BELTGUARD 1 8 56280159 SCREW, HEX _ SERRATED FLANGE -- I MS-1.0 X 12MM 7 54416730 BELTGUARD. FRONT 1 8 5441574_ BELTGUARD. BACK 1 9 97173595 CAPSCREW, SELF TAP -- I14-20 X 1/2 4 9A 9591S078 WASHER, FLAT 1/4 ZINC 4 9
Ingersoll-Rand SS3, START-UP KIT Each slart_Up kit contI31n._enough Ingersoll-Rand synthetic compressor _ubricant _nd _Ir ISlet etem_nts tD starbup and mglnfaln your _,8 fo_"lh_ first y_at PART NO DESCRIPTION 20100251 KIT. START*UP INGERSOLL-RAND SYNTHETIC COMPRESSOR LUBRICANT PART NO, DESCRIPTION 3231867,5 LUBRICANT, 1 QUART BOTTLE 32318683 LUBRICAN'E CASE OF 1 QUART BOTTLES AIR FILTER ELEMENT PART NO, DESCRIPTION 32170979 ELEMENT_ AIR FILTER STEP SAVER KITS Stop S_ve_ K_I_ provide _;t of lhe parta _quiroct 1o gaff otto common repair task_ _uch as pit_lon timj t_placemt_n! or v_tVe _'opfscomgnt PART NO. DESCRIPTION 26109277 Kil_ VALVE/GAS
Ingersoll-Rand 2340 Air Compressor Owner's manual
2340 |
Ingersoll-Rand SSR UP5-4 Air Compressor Operation and maintenance manual
SSR UP5-4 |
Ingersoll-Rand DD2T2 Air Compressor Owner's manual
DD2T2 |
Ingersoll-Rand TS4 Air Compressor Owner’s manual with parts lists
TS4 |
Ingersoll-Rand IRN37-160K-CC Air Compressor Operation and maintenance manual
IRN37-160K-CC |
Ingersoll-Rand P1.5IU-A9 Air Compressor Owner's manual
P1.5IU-A9 |
Ingersoll-Rand ARO 650442-XXX Air Compressor Operator's manual
ARO 650442-XXX |
Ingersoll-Rand CENTAC Air Compressor Instruction manual
CENTAC |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Country Living | D71 M80756 | Owner's manual | country-living/d71-m80756-5N5.pdf | 03 Sep 2023 | 3 | 0.18 Mb |
2 | Samsung | SGH-E640 | Operation & user’s manual | samsung/sgh-e640-79I.pdf | 28 Jul 2023 | 105 | |
3 | Panasonic | KX-TEB308 | Features manual | panasonic/kx-teb308-261.pdf | 05 Sep 2023 | 270 | |
4 | Garmin | nuvi 30 | Important safety and product information | garmin/nuvi-30-P4N.pdf | 13 Jul 2023 | 4 | 0.24 Mb |
5 | Sitecom | WLR-1000 | Operation & user’s manual | sitecom/wlr-1000-H63.pdf | 11 Mar 2023 | 62 | 2.53 Mb |
6 | Pentair | PRC Series | Brochure | pentair/prc-series-RQ8.pdf | 14 Nov 2022 | 2 | 0.24 Mb |
Sealey
INSTRUCTIONS FOR: COMPRESSORS 50LTR/3.0HP, 100LTR/3.0HP, 150LTR/3.0HP, 200LTR/3.0HP - DIRECT DRIVEMODEL No's: SAC1503B, SAC1103B, SAC1153B, SAC1203B Thank you for purchasing a Sealey product. Manufactured to a high standard this product will, if used according to these instructions and properly maintained, give you years of trouble free performance.1. …
SAC1503B(6 pages) |
Powermate
200-2487Revision AOperator-Parts ManualManuel de l’opérateur - Manuel de piècesManual del operador - Manual de piezasSingle Stage, Direct Drive, Oil Lubricated, Electric Air CompressorsD’une seul étape, à prise directe, graissé à avec de l’hule, compresseursd’air électriquesDe una sola etapa, de mando directo, Lubricado con aceite, compresores …
200-2487(24 pages) |
Invacare
User: Before using the product, read this manual and save for future reference.Dealer: This manual must be given to the end user.For more information regarding Invacare products, parts, and services, please visit www.invacare.com User ManualHomeFill® Compressor
…
Compressor(36 pages) |
Becker
29 kg64 lbsSV 5.250MAX.VACUUMMAX.Vm /h3mbarMade in Germany-1m /h+-yearNominkW3mbarmbartypespeedpower requiredinlet capacityvacuumpressureHzfrequencyMAX. VMade in Germany-1m /h+-yearNominkW3mbarmbartypespeedpower requiredinlet capacityvacuumpressureHzfrequencyMAX. PRESSUREMAX. VACUUMMAX.PRESSUREL = 64 dB(A) - 50Hz L = 66 dB(A) - 60HzK = 3 d …
SV 5.250(4 pages) |
Powersmart
INSTRUCTION MANUAL 6 Gallon Air Compressor Model # PS65 Have product questions or need technical support? Please feel free to contact us! Website: www.Amerisuninc.com Toll free: 1-800-791-9458 M-F 9-5 EST Email: [email protected]
…
PS65(14 pages) |
Dorin innovation
CDSSERIESCO2COMPRESSORES PARA APLICAÇÃO SUBCRÍTICA CO2COMPRESORES PARA APLICACIONES SUBCRÍTICAS CO2COMPRESSORS FOR SUB-CRITICAL APPLICATIONSCDS35 RANGECO2SUB-CRITICAL APPLICATION2,28 a 58,58 m3/h
…
CDS Series(12 pages) |
Juniper Network Router M320M320 Hardware manual - 43P6BU M320, 320 |
Western Digital Storage My CloudWestern Digital Storage My Cloud Setup manual My Cloud, 2 |
Siemens Refrigerator KG39FSB45Siemens Product Guide: KG39FSB45 PDF User manual manual - 3OUA1G KG39FSB45, 55 |
Sony MP3 Player Accessories CKH-NWS630MP3 Player Accessories #39H64B CKH-NWS630, 2 |
Dell Laptop XPS 14zPDF Manual (@B4UM2K), Dell XPS 14z Laptop (06.09.2023) XPS 14z, 2 |
Fortinet Network Router FortiGate FortiGate-300FortiGate FortiGate-300 Quick start manual - VRZG42 FortiGate FortiGate-300, 2 |
Extech Instruments Test Equipment ET28BTest Equipment Operation & user’s manual (Extech Instruments ET28B) ET28B, 2 |
Planet Network Hardware NVR-400Network Hardware PDF Operation & user’s manual NVR-400, 43 |
DCS Grill CAD1#5J94F2 CAD1: DCS Grill Owner Documentation CAD1, 52 |
Philips Home Theater System HTS8100Philips Home Theater System Operation & user’s manual (File: philips-hts8100-operation-user-s-manual-56, 18/09/2023) HTS8100, 56 |
Marshall Electronics Microphone 880Specifications for Marshall Electronics 880 Microphone 880, 2 |
Curtis LCD TV LCD2622PDF Guide (@XW2DS2), Curtis LCD2622 LCD TV (Wed 09.2023) LCD2622, 25 |