Invacare Compressor Operation & User’s Manual

Text of Invacare Compressor User Guide:

• Invacare Compressor, LABEL LOCATION Part No 1100873 9 HomeFill ® Compressor LABEL LOCATION DEALER INFORMATION NOTE:Invacarerecommendsleavingafullcylinderofoxygenwith thepatientaftersettinguptheHomeFillcompressor. BeforeleavingaHomeFillCompressorwithauser,the followingchecklistMUSTbecompleted: ❑ Makesurethepressuretestoncylinderhasnotexpired. ❑ Instructtheuseronthesafeoperationoftheconcentrator andrevi

• Invacare Compressor, SECTION 5—COMPRESSOR OPERATION HomeFill ® Compressor 26 Part No 1100873 Disconnecting the Cylinder from the Compressor NOTE:Forthisprocedure,refertoFIGURE5.3. 1. Pressthecompressorpow erswitch totheOff(O)position. 2. Graspthecylinderintheareabehindthecylinderfillport. 3. W iththeotherhand,grasptheouterring(sleeve) ofthe connectorfillportandpushDOWN. 4. Liftuponthecylindertoremove fromtheconnectorfillport. FIGURE 5.3 Disconnecting the Cylinder from the Compressor 5. Whenthecylinderfillportisdisconnectedfrom the�

• Invacare Compressor, SECTION 7—TROUBLESHOOTING HomeFill ® Compressor 32 Part No 1100873 NOTE:Refertothecylinder’smanualforproperfilltimes. NOTE:Fillingtimesar eapproximateandmay varyonenvir onmental conditions. O 2 BELOW NORMAL (YELLOW) light stays On 1. Ensure the concentrator has warmed up for at least 20 minutes.If it has not been 20 minutes, turn the compressor Off until the concentrator warms up. If the YELLOW light still remains on proceed to STEP 2. 2. Inspect the connection between the compressor and the concentrator for damage or pinching. • I

• SECTION 1—IMPORTANT SAFETY INSTRUCTIONS Part No 1100873 11 HomeFill ® Compressor SECTION 1—IMPORTANT SAFETY INSTRUCTIONS  WARNING Thissectioncontainsimportantinformationforthesafe operationanduseofthisproduct.  DANGER Risk of electric shock. DO NOT disassemble. Refer servicing to qualified service personnel. No user serviceable part

• Invacare Compressor, SECTION 4—CHECKLIST AND CYLINDER INSPECTION HomeFill ® Compressor 20 Part No 1100873 SECTION 4—CHECKLIST AND CYLINDER INSPECTION Compressor Operation Checklist EachtimetheHomeFillCompressorisusedtofillacylinder, completethefollowingchecklist: ❑ EnsuretheconcentratorhasbeenOnforatleastthirty minutes.RefertotheconcentratorOwner’sManual. ❑ Performtheprefillinspectiononthecylinder. ❑ Connectthecylindert

• Invacare Compressor, SPECIAL NOTES HomeFill ® Compressor 6 Part No 1100873  DANGER DO NOT SMOKE while using this device. Keep all matches, lit cigarettes or other sources of ignition out of the room in which this product is located and away from where oxygen is being delivered. NO SMOKING signs should be prominently displayed. Textiles and other materials that normally would not burn are easily ignited and burn with great intensity in oxygen enriched air. Failure to observe this warning can result in severe fire

• Invacare Compressor, SECTION 7—TROUBLESHOOTING Part No 1100873 31 HomeFill ® Compressor SECTION 7—TROUBLESHOOTING TROUBLESHOOTING PROBLEM SOLUTION No indicator lights on when compressor turned on. 1. Turn compressor Off. 2. Check that power cord is properly plugged into compressor and wall outlet. 3. Turn the compressor On. 4. Clean air filters. Refer to Cleaning the Compressor Filter on page 33. 5. If performing STEPS 1-4 does not cause any indicator lights to come on, contact your home health care pro- vider or Invacare for service. RED Light ON 1.Check the cylinder gauge to see if it is

• Invacare Compressor, WARNING HomeFill ® Compressor 2 Part No 1100873  WARNING DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner’s manuals, service manuals or instruction sheets supplied with this product or optional equipment. If you are unable to understand the warnings, cautions or instructions, contact a healthcare professional, dealer or technical personnel before attempting to use this equipment - otherwise, injury or damage may occur. NOTICE Theinformationcontainedinthisdocumentissubjectto changewithoutnotice.

• Invacare Compressor, SECTION 5—COMPRESSOR OPERATION Part No 1100873 29 HomeFill ® Compressor NOTE:TheO 2 BELOWNORMAL(YELLOW)lightmaycomeonif theoxygenlevel fr omtheconcentrato rhasnotyetreachedordrops below90%.Thecompr essorwillbeginorresumefillingwhen the oxygenlevelreaches90%.IflightdoesnotgoOffwithin 10minutes, refertoTr oubleshootingonpage 31. NOTE:IftheATTENTION(R ED)lightandaudiblealarmareon. RefertoTr oubleshootingonpage 31. FIGURE 5.5 Tur

• TYPICAL PRODUCT PARAMETERS HomeFill ® Compressor 8 Part No 1100873 Input Pressure Required: 14 - 21 psi Input Flow Required: 2 L/min Input O 2 % Required: >90% O 2 Width: 20 ¼ inches Height: 15 inches Depth: 16 inches Weight: 33 lbs Shipping Weight: 39 lbs No AP/APG: Not suitable for use in the presence of a flammable anaesthetic mixture. Electrical: No extension cords. Placement:

• Invacare Compressor, SECTION 3—INITIAL SETUP Part No 1100873 17 HomeFill ® Compressor Transporting the Compressor  WARNING NEVERtransportacompressorwithacylinderconnectedtoor storedonthecompressor,otherwiseinjuryordamagecanoccur. CAUTION Whentransportingthecompressor,becarefulnottobumpthe compressorortheconnectorsintoobstacles.Otherwise,damage tothecompressormayoccur. NOTE:Forthisprocedure,referto

• Invacare Compressor, SECTION 3—INITIAL SETUP Part No 1100873 19 HomeFill ® Compressor FIGURE 3.3 Connecting the Compressor to the Concentrator Insert End of Interconnect Hose into Inlet/Outlet Fitting Inlet/Outlet Fitting Metal Tab Interconnect Hose Compressor Inlet Fitting Power Cord Outlet Fitting CONCENTRATOR TOP VIEW DETAIL “A” DETAIL “C” DETAIL “B”

• Invacare Compressor, SECTION 8—MAINTENANCE Part No 1100873 33 HomeFill ® Compressor SECTION 8—MAINTENANCE Cleaning the Compressor Filter  WARNING PushthepowerswitchtotheOff(O)positionandunplugthe compressorbeforecleaning. DONOToperatethecompressorwithoutthefilterinstalled. CAUTION DONOTunplugbypullingoncord.Tounplug,grasptheplug notthecord,otherwisedamagemayoccur. NOTE:Forthisprocedure,refertoFIGURE8.1. NOTE:Allcompr essorshaveone

• Invacare Compressor, return authorization date. Do not return products to our factory without prior consent. C.O.D. shipments will be refused; please prepay shipping charges. LIMITATIONS AND EXCLUSIONS: THE FOREGOING WARRANTY SHALL NOT APPLY TO PRODUCTS SUBJECTED TO NEGLIGENCE, ACCIDENT, IMPROPER OPERATION, MAINTENANCE OR STORAGE, SOOT OR SMOKE-FILLED ENVIRONMENTS, OR OTHER THAN NORMAL APPLICATION, USE OR SERVICE, OR TO PRODUCTS MODIFIED WITHOUT INVACARE CORPORATION'S EXPRESS WRITTEN CONSENT (INCLUDING, BUT NOT LIMITED TO, MODIFICATION THROUGH THE USE OF UNA

• Invacare Compressor, SECTION 2—TECHNICAL DESCRIPTION Part No 1100873 15 HomeFill ® Compressor SECTION 2—TECHNICAL DESCRIPTION TheHomeFillOxygenSystem(IOH200)isan electro‐mechanicalprescriptionsystemforuseinthehome. Itsintendedfunctionanduseistosupplypressurizedoxygen tofillInvacareproprietarygascylindersforambulatoryuse whilethepatientreceivestherapeuticoxygenfroman accessoryoxygenconcentrator.TheIOH200gassystemis designedforusewithanInvacarePlatinumoxygen concentratorwithanintegralH

• SECTION 5—COMPRESSOR OPERATION HomeFill ® Compressor 28 Part No 1100873 Turning the Compressor On NOTE:Forthisprocedure,refertoFIGURE5.5onpage 29. 1. Makesuretheconcentratoris On.Refertotheconcentrator Owner’sManual. CAUTION TheconcentratorflowratetothepatientMU STbesetat maximum:3L/mino

• Invacare Compressor, TABLE OF CONTENTS HomeFill ® Compressor 4 Part No 1100873 Connecting/Disconnecting the Cylinder to/from the Compressor ..............................................................................................23 Connecting the Cylinder to the Compressor........................23 Disconnecting the Cylinder from the Compressor.............. 26 Turning the Compressor On .........................................................28 SECTION 6—INDICATOR LIGHTS .................... 30 SECTION 7—TROUBLESHOOTING ................... 31 SECTION 8—MAINTENANCE .......................... 33 Cleaning the Compres

• Invacare Compressor, SECTION 4—CHECKLIST AND CYLINDER INSPECTION HomeFill ® Compressor 22 Part No 1100873 The Hydrostatic Testing Date AluminumcylindersMUSTundergotestingeveryfiveyears.  WARNING DONOTfillcylindersthathavenotbeentestedinthepast fiveyears.Otherwise,seriouspersonalinjurymayresult. Contactyourdealerforreplacement. External Examination 1. Examinetheoutsideofthecylinderforthefollowing conditions,andreplacethecylinderiftheyexist: •Dentsordings •Arcburns •Oilorgrease •Anyothersignsofdamagethatmi

• Invacare Compressor, SECTION 3—INITIAL SETUP HomeFill ® Compressor 18 Part No 1100873 FIGURE 3.2 Installing the Power Cord Connecting the Compressor to the Concentrator NOTE:Forthisprocedure,refertoFIGURE3.3onpage 19. 1. Insertoneendoftheinterconnecthoseintotheoutletfitting  onthebackoftheconcentrator(De tail“A ” ) . 2. Inserttheoppositeendoftheinterconnecthoseintotheinlet fittingonthesideofthecompressor(Detail“B”). NOTE:Themetaltabsonthe

• Invacare Compressor, SECTION 5—COMPRESSOR OPERATION Part No 1100873 27 HomeFill ® Compressor  WARNING Thefillportcov eronthe connectorfillportandthecylinder fillportMUSTbereplacedafterfillingandwhenevernotinuse. Ifeitherofthefillportcove rsaremissingcontactyourhealthcare providerbeforeusing. 6. Placethefillportcov ersontotheconnectorfillportand cylinderfillport. NOTE:Whenusingthepostvalvetypecylinder,attachano

• SECTION 5—COMPRESSOR OPERATION Part No 1100873 23 HomeFill ® Compressor SECTION 5—COMPRESSOR OPERATION Connecting/Disconnecting the Cylinder to/from the Compressor  WARNING NEVERusetoolsofanykindtoconnect/disconnectthecylinder andthecompressor.Otherwise,sev ereinjuryand/ordamage mayoccur. Connecting th

• Invacare Compressor, SPECIAL NOTES Part No 1100873 5 HomeFill ® Compressor SPECIAL NOTES Checkallpartsforshippingdamage.Incaseofdamage,DO NOTuse.ContactInvacareforfurtherinstruction. Signalwordsareusedinthismanualandapplytohazardsor unsafepracticeswhichcouldresultinpersonalinjuryor propertydamage.Refertothefollowingtablefordefinitions ofthesignalwords. ACCESSORIES Therearemanydifferenttypesofoxygentubing,cannulas andmasksthatcanbeusedwiththisdevice.Youshould contactyourlocalhomecarepro

Related Products and Documents (Air Compressor):

Comparable Devices:

Similar Resources:

• Becker DT 4.16 (4 pages) NJOEV""DT 4.16MAX.PRESSUREMAX.Vm /h3mbarMade in GermanyyearNomin-1kWm /h3mbartypespeedpower requiredinlet capacitymax. pressureHzfrequencyD-42279 Wuppertalwww.becker-international.comMAX. PRESSUREMade in GermanyyearNomin-1kWm /h3mbartypespeedpower requiredinlet capacitymax. pressureHzfrequencyD-42279 Wupperta …

• HELIX Compressor 9600 (72 pages) HELIX TECHNOLOGY CORPORATIONhttp://www.helixtechnology.com©2007 Helix Technology Corporation Pub. No. 8040437, Rev. 104, 06/12/2007 ECO No.18068 Printed in USA9600 (High Voltage) Compressor Installation, Operation, and Maintenance Instructions …

• Will Burt 185 (8 pages) CONTROLLERType : NO 24 Volt DC with toggle switch +Type : deadman function Part No. 5057002COMPRESSOR MODEL 185Type : NO 230 Volt AC Part No. 5044201/BFINSTRUCTIONSGEBRUIKSAANWIJZINGMOUNTINGMount the compressor always inside a vehicle, shelter or container.Mark the fixing points and drill holes of Ø 7 mm. Fit the compressorwith minimum 4 screws M6. Mou …

• Panasonic S35C65KAU6 (2 pages) 1.11.21.31.41.51.61.71.81.92.0-20 -10 0 10 20 30 40Current (A)6080100120140160180200-20 -10 0 10 20 30 40Input Power (W)2003004005006007008009001,0001,1001,2001,300-20 -10 0 10 20 30 40Evaporating Temperature (°F)Capacity (BTU/H)110°F 120°F 130°FRated Performance DataCapacity . . . . . . . . . . . . . . 290 Btu/h ±10% *E.E.R. . . . . . . . . . . . . . …

• Parkside PKZ 180 A1 (34 pages) IAN 93472 COMPRESSEUR PKZ 180 A1 KOMPRESSOR Bedienungs- und Sicherheitshinweise Originalbetriebsanleitung COMPRESSEUR Instructions d‘utilisation et consignes de sécurité Traduction du mode d‘emploi d‘origine COMPRESSOR Operation and Safety Notes Translation of original operation manual93472_Kompressor_PKZ_180_A1_cover_LB2.indd 2 2 …

• Prematic AIRSTAR 45 (96 pages) ___________________________________________________________________________________________ Prematic AG Druckluft-Elemente und Kompressoren Märwilerstrasse 43, 9556 Affeltrangen TG, Schweiz Tel.: +43 (0) 60 44 / 71 918 60 60, Fax: +43 (0) 60 44 / 71 918 60 40 [email protected], www.prematic.ch Originalbetriebsanleitung für den …

Comments, Questions and Opinions: