Manualios.com

Master Bilt IM-23GB Installation & Operation Manual

Master Bilt IM-23GB Manual Online:

3.5, 2149 votes
Master Bilt IM-23GB User Manual
Master Bilt IM-23GB User Guide
Master Bilt IM-23GB Online Manual

Text of Master Bilt IM-23GB User Guide:

  • Master Bilt IM-23GB, IM-23GB Installation & Operations Manual With TLY 25 Controller Master-Bilt Products 908 Highway 15 North New Albany, MS 38652 Phone: (800) 684-8988 LN_ 09/26/06

  • Master Bilt IM-23GB, 3 TABLE OF CONTENTS INTRODUCTION................................................................................................................................................................4 STORE CONDITIONS........................................................................................................................................................4 WARNING LABELS AND SAFETY INSTRUCTIONS.......................................................................................................4 NOTICE .................................................................................................................................

  • Master Bilt IM-23GB, 4 INTRODUCTION Thank you for purchasing Master-Bilt Ice Merchandiser. This manual contains important instructions for installing, using, cleaning, and servicing Master-Bilt Indoor Ice Merchandiser. A parts list is included with this manual. Read all documents carefully before installing or servicing your equipment. STORE CONDITIONS The Master-Bilt Ice Merchandisers are designed to operate in a controlled environment. The temperature should be at 75°F or below for an indoor ice merchandiser, with relative humidity of 55% or less. At higher temperature or humidity conditions, the performance of these merch

  • Master Bilt IM-23GB, 5 NOTICE Read this manual before installing, cleaning, or performing any maintenance on your cabinet. Keep the manual and refer to it before doing any service on the equipment. Failure to do so could result in personal injury or damage to the cabinet. DANGER Improper or faulty hook-up of electrical components on the refrigeration units can result in severe injury or death. All electrical wiring hook-ups must be done in accordance with all applicable local, regional or national standards. NOTICE Installation and service of the refrigeration and electrical components of the cabinet must be performed by a refrigeration mechanic and/or a licensed ele

  • Master Bilt IM-23GB, 6 MECHANICAL Remove front grille and check refrigeration lines to see that they are free (not touching each other or compressor). Spin condenser fan blade to see that it is free. The compressor is hermetic so it is internally spring mounted and ready to run. ELECTRICAL WARNING Before servicing electrical components in the case or the doors or door frames make sure all power to case is off. Always use a qualified technician. Check voltage and amps drawn on (Page 12-13) to determine proper line and fuse or circuit breaker size. Check power supply for low voltage. If voltage reads “115” with no load, and it

  • Master Bilt IM-23GB, 7 MICROPROCESSOR-BASED DIGITAL ELECTRONIC FREEZER CONTROLLER 712 136511 8 9 10 3 4 1 2 Aux -OK+ Fan AuxDefOut AL TLY 25 1 - Key P: Used for setting the Set point and for programming the function parameters 2 - Key DOWN/Aux: Used for decreasing the values to be set and for selecting the parameters. It can also be programmed via the parameter “Fbd” to carry out other functions such as activating the Aux output, starting up the continuous cycle, selecting the active set point or turning on and o

  • 8 OPERATION Fan The fan will run constantly except when a defrost is initiated, or when the evaporator temp is above 35 o F. When in defrost mode the fan is off until the end of the defrost and the 2 minute drip time has passed. There is 2 minutes delay after a defrost before the fan comes on. The difference of the evaporator and room temperature of more than 9 o F will

  • Master Bilt IM-23GB, 9 LIST OF PARAMETERS Here is a list of factory set parameters the value of which can not be change in the field without the password. Symbols Descriptions Range M/B Setting SPAt Active Set point 1 ÷ 2 1 SP1 Set Point 1 SPLL ÷ SPHL 20 SP2 Set Point 2 SPLL ÷ SPHL 20 SEnS Probes Type Ptc - ntc ntc Unit Unit of measurement °C - °F °F diSP Normal Display (Room Temperature) OFF - Pr1 - Pr2 - SP - CL Pr1 HSEt Differential 0 ÷ 30 °C/°F 5 tonE Compressor will run for 6 minutes OFF ÷ 99.59

  • Master Bilt IM-23GB, 10 ELECTRICAL CONNECTIONS The controller is provided with screw terminal block to connect cables with a cross section up to 2,5 mm 2 . Before connecting cables make sure the power supply complies with the control’s requirements. Separate the probe cables from the power supply cables, from the outputs and the power connections. Do not exceed the maximum current allowed on each relay, in case of heavier loads use a suitable external relay. PROBE CONNECTIONS The probes shall be mounted with the bulb upwards to prevent damage due to casual li

  • Master Bilt IM-23GB, 11 TROUBLE SHOOTING Symptom-System Operates Long or Continuously Possible Problem Possible Cause Remedy How Long do the doors stay open? Door closer need adjust. Adjust door closer and keep doors closed. Is the condenser clean? Dirty condenser. Clean condenser Are the condenser fans running? Fans not running. Repair or replace Is the evaporator dirty or iced up? Iced or plugged evaporator coil(s). Defrost or clean (check control settings) Are the evaporator fans running? Fans not running. Repair or replace Have you checked the refrigerant level? Shortage of refrigerant. Repair leak and

  • 12 CABINET CLEANING PROCEDURES WARNING! To avoid electrical shock, disconnect main power supplies to the merchandiser before beginning this procedure. May have more than one disconnect switch. The exterior of the ice merchandiser should simply be wiped clean with a damp cloth daily. This will be sufficient to keep the unit looking its finest.

  • Master Bilt IM-23GB, 13 PARTS LIST PART DESCRIPTION IM-23 Condensing unit/1st run units 01-01733 Compressor (AEA44440YXA) 03-50330 Bottom Shelf 33-01453 Light Switch 23-50562 Ballast 23-00349 evaporator coil 07-13288 evaporator fan motor 13-13198 evaporator fan blade 15-13106 evaporator fan guard 25-01324 Wall Gard 25-01344 drain flanges with adapter 11-01410 drain line heater wire 17-00404 heater clip 17-09431 drier 09-09308 grill 256-28900 rear Cover 255-11714 Cap Tube 11-01450 heater safety 19-01164 vinyl tube 11-00876 coil defrost heater 17-09407 TLY-25 Control w/ Sensors 19-13952 TLY Controller 19-13992 Sensors 19-13953 glass do

  • Master Bilt IM-23GB, 14 SALE AND DISPOSAL OWNER RESPONSIBILITY If you sell or give away your Master-Bilt Ice Merchandiser you must make sure that all safety labels and the Installation - Service Manual are included with it. If you need replacement labels or manuals, Master-Bilt will provide them free. Contact the customer service department at Master-Bilt at (800)-647-1284. The customer service department at Master-Bilt should be contacted at the time of sale or disposal of your cabinet so records may be kept of its new location.

Related Products and Documents (Freezer):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 Patton electronics 1058 Operation & user’s manual patton-electronics/1058-EK8.pdf 25 Oct 2022 17 0.51 Mb
2 Texas Instruments THS3001 Operation & user’s manual texas-instruments/ths3001-N37.pdf 02 Jul 2023 20
3 Sanitas SMG 45 User manual manual sanitas/smg-45-5TO.pdf 12 Feb 2023 24
4 Thermador MET27E Installation manual thermador/met27e-694.pdf 13 Jun 2023 44 3.54 Mb
5 Philips MCD177/12 Quick start manual philips/mcd177-12-7CD.pdf 08 Sep 2023 4 0.74 Mb
6 Hamilton Beach Blender Instructions manual hamilton-beach/blender-55I.pdf 12 Nov 2022 12 0.37 Mb

Similar Resources:

  • Whirlpool

    ET12DC

    (12 pages)
    I / i ’ Ill / CYCLE DEFROST c3 REFRIGERATOR- FREEZERS Model ET12DC and Model ET14DC , rreerers. Aelr~geratar-Freezers Ice Makers Dlshwasherr BUIU In Ovens and Surface Units. Ranges Microwave Ovens Trash Compactors Room Air Condllloners Oehumldllf …
  • Duke

    DQ GEN-102

    (105 pages)
    185232 April 2018Printed in U.S.A.OPERATOR’S MANUALwith Illustrated Parts ListH. C. DUKE & SON, LLC2116 - 8th Avenue • East Moline, Illinois 61244Twin TwistSoft Serve FreezerModel GEN-102 185232— 4/18 …
  • True Fitness

    TSSU-60-24M-B-ST

    (2 pages)
    Specications subject to change without notice.Chart dimensions rounded up to the nearest ⁄" (millimeters rounded up to next whole number).Rough-In Data2001 East Terra Lane • O’Fallon, Missouri 63366(636)240-2400 • Fax (636)272-2408 • (800)325-6152 • Intl Fax# (001)636-272-7546Parts Dept. (800)424-TRUE • Parts Dept. Fax# (636)272-9 …
  • Mobicool

    MV26

    (12 pages)
    mobicool.comMobile refrigerating applianceOperating and safety instructionsМобильное охлаждающее устройствоРуководство по эксплуатации и правила техники безопасностиMV26/MV30 AC/DCMobile thermoelectric coolerMobilusis šaldymo aparatasNaudojimo ir saugos instrukcijosMobila auks …
  • Heinner

    HC-V268F+

    (49 pages)
    COMBI FRIDGE Model: HC-V268F+ / HC-V268SF+ / HC-V268BKF+  •  •  •  …
  • Hoshizaki

    SafeTemp FH1-AAC

    (23 pages)
    Hoshizaki“A Superior Degreeof Reliability”www.hoshizaki.comCommercial Refrigerators & FreezersHoshizaki America, Inc.Issued: 2-12-2008Revised: 5-22-2008INSTRUCTION MANUALModelsTempGuard & SafeTemp®® …

Comments, Questions and Opinions: