Moffat Cobra CT6 Installation And Operation Manual
|
Moffat Cobra CT6, The reproduction or copying of any part of this manual by any means whatsoever is strictly forbidden unless authorized previously in writing by the manufacturer. In line with policy to continually develop and improve its products, Moffat Ltd. reserves the right to change the specifications and design without prior notice. © Copyright Moffat Ltd. April 2014. MANUFACTURED BY Moffat Limited Christchurch New Zealand INTERNATIONAL CONTACTS AUSTRALIA Moffat Pty Limited E.Mail: [email protected] Main Office: (tel): +61 (03)
Moffat Cobra CT6, Contents CT6 Gas Griddle Toaster Part 1 Introduction .................................................................................... 2 Part 2 Specifications ................................................................................. 3 Part 3 Installation ........................................................................................ 5 Part 4 Operation ......................................................................................... 8 Part 5 Cleaning and Maintenance .......................................................... 9 Part 6 Gas Conversion ....................................................
Moffat Cobra CT6, We are confident that you will be delighted with your Cobra Series Gas Griddle Toaster and it will become a most valued appliance in your commercial kitchen. To ensure you receive the utmost benefit from your new Cobra Series Appliance, there are two important things you can do. Firstly: Please read this instruction book carefully and follow the directions given. The time taken will be well spent. Secondly: If you are unsure of any aspect of the installation, instructions or performance of your appliance, contact your Cobra Series appliance dealer promptly. In many cases a phone call could answer your question. CE Only: These instructions
Moffat Cobra CT6, 3 Part 2 Specifications - All Other Markets: (*)NOTE: Burner operating pressure is measured at the manifold test point with both burners operating at the 'High Flame' setting. NAT, LPG & Butane Only - Operating pressure is ex-factory set and is not to be adjusted, apart from when converting between gasses, if required. TOWN GAS Only - Burner operating pressure is to be adjusted using the Town Gas adjustable gas regulator supplied. Refer to the ‘Gas Conversion and Specifications' section of this manual for further details. Gas Connection Gas supply connection point is locate
Moffat Cobra CT6, 5 Part 3 Installation Check that the following parts have been supplied with the appliance: Enamelled Crumb Tray 1 Toasting Rack 1 Toasting Rack Tray (St/Steel) 1 Grease Drawer 1 Adjustable Legs 4 Gas Regulator 1 Location 1. Installation must allow for a sufficient flow of fresh air for the combustion air supply. Combustion Air Requirements Natural Gas 10 m³/hr minimum. LPG / Propane 9 m³/hr minimum. 2. Installation must include adequate ventilation means, to prevent dangerous build up of combustion products. 3. Position the appliance in its approximate working position. 4. All air for burner com
Moffat Cobra CT6, 6 Part 3 Installation NOTE: The gas pressure regulator provided with this appliance is convertible between Natural Gas and LPG as per the ‘Gas Conversion Section’ in this manual. Ensure the regulator is converted to the correct gas type that the appliance will operate on. The regulator outlet pressure is fixed ex-factory for the gas type that the regulator is converted to and it is NOT to be adjusted. The regulator connections are 1 / 2 " BSP female. The connection to the appliance is
Moffat Cobra CT6, 7 Part 3 Installation Commissioning The following commissioning checks must be carried out before the Gas Griddle Toaster is handed over for use, to ensure that the unit operates correctly and the operator(s) understand the correct operating procedure. 1. Before leaving the new installation; a. Check the following functions in accordance with the operating instructions specified in the “Operation” section of this manual. Light the Pilot Burners. Light the Main Burners. Check the Low Fire Burner
Moffat Cobra CT6, 8 Part 4 Operation Operation Guide 1. Cobra Gas Griddle Toasters have been designed to provide simplicity of operation and 100% safety protection. 2. Improper operation is therefore almost impossible, however bad operation practices can reduce the life of the appliance and produce a poor quality product. To use this gas griddle toaster correctly please read the following sections carefully before use. Lighting the Pilot Burners. Using the Griddle. Using th
Moffat Cobra CT6, 9 Part 5 Cleaning and Maintenance CORRECT LEVEL FOR FRYING MEDIUM WHEN AT FRYING TEMPERATURE, KEEP TOPPED UP INDICATES CORRECT FRYING MEDIUM LEVEL WHEN COLD 1. Clean the griddle with a scraper tool to remove any food debris. 2. Always ensure that the scraper tool blades are changed regularly to ensure that the scraper tool works efficiently and prevents damage to the griddle plate surface. Daily Cleaning 1. The crumb tray / grease drawer should be checked and emptied frequently to prevent overflow and spillage. Remove the grease drawer while still warm so that the grease is in a liquid state. Empty any grease from the drawer and wash thoroughly in the
Moffat Cobra CT6, 10 Part 5 Cleaning and Maintenance Periodic Maintenance NOTE: All maintenance operations should only be carried out by a qualified service person. To achieve the best results cleaning must be regular and thorough and all controls and mechanical parts should be checked and adjusted periodically by a qualified service person. If any small faults occur, have them attended to promptly. Don't wait until they cause a complete breakdown. It is recommended that the appliance is serviced every 6 months. Gas Control Valve Re-Greasing The gas control valve should be dismantled and greased every 6 months to ensure the correct operation of
Moffat Cobra CT6, 11 Part 6 Gas Conversion 3. Re-connect the following:- Gas supply tube to pilot burner. Tighten gas supply tube at gas control end. Refit piezo igniter. Re-connect lead to piezo igniter. Low Fire Adjustment 1. Set burner low fire adjustment. Low fire screw should be screwed fully 'In', then unscrewed by measurement shown in ‘Gas Specifications’ table at end of this section. NOTE: ‘Low Fire Screw’ should be sealed with coloured paint on completion of low fire adjustment. 1. Refit control panel. 2. Refit gas control knob. Gas Conversion Procedure NOTE: Thes
12 Part 6 Gas Conversion Gas Regulator NOTE: The gas regulator supplied is convertible between Natural Gas and LP Gas, but it’s outlet pressure is fixed ex-factory and is NOT to be adjusted. - NAT Gas / LPG / Butane Only. - Town Gas Only. 1. Remove slotted cap from regulator. 2. Turn ‘On’ gas supply and appliance. 3. Adjust pressure adjusting screw to achiev
Moffat Cobra CT6, 13 Part 6 Gas Conversion Gas Specifications - Australia: - New Zealand: - UK Only: Category: II 2H3P. Flue Type: A 1. NOTE: * Measure burner operating pressure manifold test point with both burners operating at full setting. Operating pressure is ex-factory set, through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion. (Refer to ‘Gas Conversion’ information for details). Nat Gas LP Gas (Propane) Main Burner Injectors Ø 2.10mm Ø 1.30mm Pilot Burner Injectors 0.35 0.23 Low Fire Adjustment 1 turn out (ccw) ½ turn out (ccw) Burner Operating Pressure (*) 1.0 kPa (*) 2.5 kPa (*) Gas Regulato
Moffat Cobra CT6, 14 Part 6 Gas Conversion - All Other Markets: NOTE: (*) Measure burner operating pressure at the manifold test point with both burners operating at 'High Flame' setting. NAT, LPG & Butane Only - Operating pressure is ex-factory set and is not to be adjusted, apart from when converting between gasses, if required. (**) TOWN GAS Only - Adjusted Burner operating pressure using the adjustable gas regulator supplied. Refer to information in this section for further details. LP Gas (Propane)
15 Part 7 Replacement Parts List Replacement Parts List When ordering spare parts, please quote the part number and the description as listed below. If the part required is not listed below, request the part by description and quote model number and serial number which is shown on the rating plate. Controls 231558 Burner - Griddle Toaster. 037210 Burner Injector
T-Fal Emeril Toaster User manual manual
Emeril |
Moffat Blue Seal G55T Toaster Technical data sheet
Blue Seal G55T |
Morphy Richards 44732 Toaster Operation & user’s manual
44732 |
Haier TST1000 - 07-01 Toaster Operation & user’s manual
TST1000 - 07-01 |
Moffat GT8600G Toaster Technical data sheet
GT8600G |
Goldair GT302 Toaster Operating instructions manual
GT302 |
Silvercrest SLTG 1100 A1 Toaster Operating instructions manual
SLTG 1100 A1 |
APW Wyott X*Treme-3 Toaster Specifications
X*Treme-3 |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Chilin | SNX55LBHa | Features | chilin/snx55lbha-481.pdf | 03 Sep 2022 | 2 | |
2 | Sharp | R-4A62 | Service manual | sharp/r-4a62-6SO.pdf | 02 Oct 2022 | 11 | 1.18 Mb |
3 | QFX | PBX-1202BT | Operating instructions manual | qfx/pbx-1202bt-GUE.pdf | 28 Dec 2023 | 6 | |
4 | Craftsman | 919.724110 | Owner's manual | craftsman/919-724110-G4O.pdf | 11 Jan 2023 | 38 | 0.66 Mb |
5 | EuroLite | LED PAR-56 | Operation & user’s manual | eurolite/led-par-56-4BJ.pdf | 07 Oct 2022 | 42 | |
6 | Vicon | kollector KOL-8000 | Operation manual | vicon/kollector-kol-8000-VGI.pdf | 06 Jul 2022 | 72 |
Bimar
1/40 LIBRETTO ISTRUZIONI INSTRUCTION BOOK NOTICE D'INSTRUCTIONS BEDIENUNGSANLEITUNG Tostapane Toaster Grille-pain Toaster type PMS150 (mod. T368)
…
T368(40 pages) |
Silvercrest
IAN 313476SANDWICHERA / TOSTIERA SSMW 750 C3 SANDWICHMAKERBedienungsanleitungSANDWICHERAInstrucciones de uso SANDWICH TOASTEROperating instructionsTOSTADEIRAManual de instruções TOSTIERAIstruzioni per l'uso
…
SSMW 750 C3(104 pages) |
Stirling
2 Slice ToasterPremium High Gloss Finish2 Slice CapacityToast up to 2 slices of breadPremium High Gloss FInishHigh quality stainless steel, finished to complement your kitchenAdjustable Browning ControlAdjust the level of browning to suit dierent breads and tastesSlice2Browning Settings
…
AP160051(2 pages) |
Alpina
EN SF-2511 Bread toaster Instruction for use DE SF-2511 Toaster Bedienungshinweise FR SF-2511 Grille pain Mode d`emploi IT SF-2511 Tostapane Manuale d´uso NL SF-2511 Broodrooster Gebruiksaanwijzing SW SF-2511 Brödrost Bruksanvisnin DK SF-2511 Brødrister Brugervejledning RU SF-2511 Хлебный тостер Ин� …
SF-2511(29 pages) |
Brandt
MANUELD’INSTRUCTIONFRINSTRUCTIONMANUALENMANUALDEINSTRUCCIONESESGEBRUIKSHANDLEIDINGNL ﺕﺍﺩﺎﺷﺭﻹﺍ ﻝﻳﻟﺩ ﺔﻳﺑﺭﻌﻟﺍ ﺔﻐﻠﻟﺍﻝﻳﻐﺷﺗﻟﺍﻭ Grille-pain Toaster Tostador Broodrooster ﺰﺒﺧ ﺔﺼﻤﺤﻣ GP1000EW
…
GP1000EW(50 pages) |
Toastmaster
Foodservice EquipmentJob Item# Toastmaster®10 Sunnen Dr. St. Louis, MO 63143• www.toastmastercorp.comToll Free: 1-800-264-7827 • Telephone: 1-314-781-2777 • Toll Free Fax: 1-800-264-6666 • Fax: 314-781-3636Models shown may ship UPSTP209/224TP409/424/430Solid-State Pop-Up ToastersBread & Texas Toast ToastersTP209, TP224, T …
TP209(2 pages) |
Parkside Drill PBH 1050 A1Drill PDF Operation and safety notes PBH 1050 A1, 46 |
Dell Laptop Inspiron Mini 9 910#61L5J3 Inspiron Mini 9 910: Dell Laptop Owner Documentation Inspiron Mini 9 910, 38 |
GE Telephone 26999GE1Telephone Specifications (GE 26999GE1) 26999GE1, 2 |
Epson Projector PowerLite 900Quick setup for Epson PowerLite 900 Projector PowerLite 900, 4 |
HP Switch AK241A - StorageWorks 8Gb Simple SAN ConnectionHP AK241A - StorageWorks 8Gb Simple SAN Connection Switch Cli manual AK241A - StorageWorks 8Gb Simple SAN Connection, 270 |
Helo Medical Equipment LXHelo LX User Guide (Doc Type: Medical Equipment Brief user's manual) LX, 29 |
Satel Control Panel PERFECTAQuick user manual for Satel PERFECTA Control Panel PERFECTA, 10 |
Alienware Monitor AW2210AW2210 Operation & user’s manual - E6W8SC AW2210, 32 |
VTech Telephone Accessories CS6509User Guide: VTech CS6509 (D5GH42, Upd.Wed 09.2023) CS6509, 10 |
AUTOTECH Automobile Accessories 10.199.023K10.199.023K Installation instructions - 4XWFAA 10.199.023K, 1 |
Trotec Multimeter BE50#F7UQUY: BE50 Multimeter Operating manual BE50, 304 |
PCM Engine 2006 5.0L MPIPCM 2006 5.0L MPI Guide (Owner's operation and maintenance manual), @Z562H8 2006 5.0L MPI, 78 |