Eagle Portable Electric/Gas Compressor Operating Instructions Manual
|
Eagle Portable Electric/Gas Compressor, 3 TABLE OF CONTENTS Safety Precautions Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Extension Cords. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Air Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Safety Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Eagle Portable Electric/Gas Compressor, 4 SAFETY PRECAUTIONS Please familiarize yourself with the following information to prevent damage to your compressor unit and injury to the operator. The air compressor motor and/or engine will get hot while in operation. Never touch the discharge tubing, engine, motor or compressor pump while in operation. The compressor operates automatically while the power is connected and turned on, or the engine is running. Compressed air from the unit may contain hazardous fumes. Air produced by this compressor is not suitable for breathing purposes. Always use a respirator when spraying paint or chemicals, or when sandblasting. Always wear safety glasses or goggles when usi
Eagle Portable Electric/Gas Compressor, 5 Any replacement parts should be purchased with the same specifications as the original equipment. Please contact the authorized dealer for replacement parts or specifications. SAFETY VALVE This valve is factory installed to prevent over pressurizing of the air receiver. It is factory set at a specific limit for your particular model, and should never be tampered with. Adjustment by user will automatically void the warranty. INSTALLATION 1. INSTALLATION Proper care, maintenance and lubrication ensures longevity. The compressor should always be level for proper lubrication. Do not over tig
6 3. BEFORE OPERATING THE AIR COMPRESSOR, PLEASE CHECK THE FOLLOWING CAREFULLY: 1. Check to see that nuts and bolts are all snug. 2. Check if the quantity and quality of oil is correct. 3. If the intake filters are dirty, they should be replaced or cleaned. 4. COMPRESSOR LUBRICATION Recommended Oil: Eagle Compressor Oil #EAOIL10 (1 litre) #EAOIL40
Eagle Portable Electric/Gas Compressor, 7 5. FILLING COMPRESSOR WITH OIL 1. Remove the oil filler plug 2. Slowly pour the proper oil into the pump crankcase. 3. Always keep oil level in the middle of the sight glass. 6. ENGINE LUBRICATION (IF ENGINE DRIVEN) Check engine Owner's manual for lubrication and maintenance requirements. 7. OIL CHANGES INITIAL OIL CHANGE DUE AT 100 HOURS CHANGE OIL EVERY 300 HOURS OR 3 MONTHS, WHICHEVER COMES FIRST. 1. Remove the oil drain plug. Allow oil to drain completely. 2. Replace the oil drain plug. 3. Refill with the recommended oil to the proper level. 8. MAINTENANCE Before do
Eagle Portable Electric/Gas Compressor, 8 HOW TO INSTALL NEW BELT IF REQUIRED (If belt driven) 1. Disconnect power supply. 2. Remove belt guard. 3. Loosen motor bolts and slide motor toward compressor head just enough to allow old belt to be removed. 4. Install proper replacement belt. 5. Slide motor away from compressor head to provide recommended tension as shown in diagram on page 5. 6. Align belt using a straight edge ruler against pulley’s edge. 7. Fasten motor bolts. 8. Ensure motor and compressor pulley’s are secure. Re-check alignment. 9. Re
Eagle Portable Electric/Gas Compressor, 9 B) ELECTRIC DRIVE WITH DUAL CONTROL 1) Check unit for any damage. 2) Check compressor oil level, fill or add if necessary. 3) Pressure switch "Off/Auto" knob should be in "Off" position. 4) Plug in power cord to proper electrical outlet. 5 a) Stop/Start (pressure switch) control 1. Shut-off valve on pilot unloader should be closed ("knurled" knob on top of the pilot unloader should be turned all the way down). 2. Turn pressure switch "Off/Auto" switch to "Auto". Electric motor should now start and fill air receiver(s) with compressed air
Eagle Portable Electric/Gas Compressor, 10 5) Stop/Start (pressure switch) control Turn pressure switch "Off/Auto" switch to "Auto". Electric motor should now start and fill air receiver(s) with compressed air until cut- out pressure is reached. Compressor should stop and remain stopped until air receiver pressure reaches the cut-in pressure. The unit will continue to cycle in this automatic operation until the pressure switch is turned to the "Off" position. COMPRESSOR MAINTENANCE SCHEDULE DAILY OR BEFORE EACH USE • Check oil level • Drain
Eagle Portable Electric/Gas Compressor, 11 Will Not Start Low Pressure Oil In Discharge Compressor Overheats Compressor Loads and Unloads or Stops and Starts Excessively • Check power supply • Please refer to Manufacturers manual included • Safety valve leaks • Drain cock open • Loose tubes or fittings • Dirty or plugged air filter • Defective unloader valve • Improper oil viscosity • Too much oil in the crankcase • Compressor overheated • Restricted air filter • Worn piston rings • Clogged inlet filter • Dirty compressor, head, cylinder, intercooler • Operating pressure too high • Low oil or wrong oil being used •
Eagle Portable Electric/Gas Compressor, 12 Insufficient Output Low Discharge Pressure Motor Stalls Water In Crankcase Oil Break- ing Up Oil Gets Dirty, Rusty Valves or Cylinder • Clogged inlet filter • Leaks in air lines, air valves, fittings etc,.. • Drive belts slipping • Drain valve left open • Defective pressure gauge • Compressor incorrectly sized • Leaking head gasket • Dirty or plugged inter cooler tubes • Unloader pilot or pressure switch adjusted too low, or defective • Worn or defective compressor valves • Worn pis
Eagle Portable Electric/Gas Compressor, 13 Excessive Vibration Compressor Knocks Compressor uses too much oil Piston rings not seated • Loose compressor, motor, engine or guard • Excessive discharge pressure • Compressor not level • Leg bolts tightened too tightly to floor • Wrong oil being used • Loose flywheel, drive pulley or drive belts • Worn rods, wrist pin or main bearings • Compressor valves loose or broken • Inspect check valve, it may knock at low pressures • Clogged inlet filter • Wrong oil being used, wrong viscosity • Oil level too high • Crankcase breather valve malfunction • Compressor runs unloa
Eagle Portable Electric/Gas Compressor, 14 EAGLE STANDARD WARRANTY EAGLE PUMP & COMPRESSOR LTD. EAGLE COMPRESSOR LLC. Seller warrants products of its own manufacture against defects in workmanship and mate- rials under normal use and service as follows: COMPRESSORS: Twenty Four (24) months from date of start-up or Twenty Seven (27) months from date of shipment from factory or whichever comes rst. PARTS: Ninety (90) days from date of sale Eagle warrants repaired or replaced
DOWNLOAD |
Campbell Hausfeld FP202801 Air Compressor Operating instructions and parts manual
FP202801 |
Craftsman 919.167310 Air Compressor Operator's manual
919.167310 |
Eagle RECIPROCATING Air Compressor Manual
RECIPROCATING |
dbx 566 Air Compressor Brochure & specs
566 |
Wagan 2050 Air Compressor Operation & user’s manual
2050 |
Delta DLKC6580V2-1 Air Compressor Instruction manual
DLKC6580V2-1 |
Powermate 200-2467 Air Compressor Parts manual
200-2467 |
Eagle Portable Electric/Gas Compressor Air Compressor Operating instructions manual
Portable Electric/Gas Compressor |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Century | ES-8000 | Operation & user’s manual | century/es-8000-773.pdf | 03 Jul 2023 | 8 | 0.32 Mb |
2 | Panasonic | CQDPX85EU - AUTO RADIO/CD DECK | Operating instructions manual | panasonic/cqdpx85eu-auto-radio-cd-deck-YN5.pdf | 15 Sep 2023 | 32 | 2.36 Mb |
3 | Sennheiser | MKH 800 - 12-99 | User manual manual | sennheiser/mkh-800-12-99-A8X.pdf | 12 Aug 2022 | 19 | 0.7 Mb |
4 | Bushnell | 360300 | Instruction manual | bushnell/360300-U7I.pdf | 04 Jun 2023 | 12 | 1.13 Mb |
5 | Chevrolet | 1999 tracker | Maintenance manual | chevrolet/1999-tracker-498.pdf | 12 Mar 2023 | 376 | 3.01 Mb |
6 | Etón | ZoneGuard+ | Manual | eton/zoneguard-A63.pdf | 04 Sep 2023 | 2 | 0.31 Mb |
Master
DHA 10USER AND MAINTENANCE BOOKLIBRETTO USO E MANUTENZIONEBEDIENUNGS- UND WARTUNGSANLEITUNGMANUAL DE INSTRUCCIONES PARA EL USO Y MANTENIMIENTOMANUEL D’UTILISATION ET DE MAINTENANCEHANDLEIDING VOOR GEBRUIK EN ONDERHOUDVEJLEDNING OM BRUG OG VEDLIGEHOLDELSEKÄYTTÖ- JA HUOLTO-OHJEHEFTE FOR BRUK OG VEDLIKEHOLDANVÄNDAR- OCH UNDERHÅLLSHANDBOKINSTRUKCJA OBSŁUG …
DHA 10(105 pages) |
Rolair
- 1 - PORTABLE AIR COMPRESSOR OWNER’S MANUAL MANUEL D’INSTRUCTION FRANÇAIS – PAGE 16 MANUAL DE INSTRUCCIONES ESPAÑOLES – PÁGINA 31 MODEL: 3095HK18 SERIAL NUMBER: __________________ 606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com
…
3095HK18(47 pages) |
Sanborn Mfg
Single Stage, Belt Drive, Electric Air CompressorsCompresseurs d’air électriques à un étage à entraînement par courroieCompresores eléctricos de aire, de una sola etapa y accionamiento por correa200-2966_ Rev D_8/10/16200-2966Revision DOperator-Parts ManualManuel de l’opérateur - Manuel de piècesManual del operador - Manual de piezasProduct style …
P1682066.MN(32 pages) |
Scheppach
Nachdrucke, auch auszugsweise, bedürfen der Genehmigung. Technische Änderungen vorbehalten. Abbildungen beispielhaft!HC51VArt.Nr.5906125906AusgabeNr.5906125851Rev.Nr.16/12/2019 www.scheppach.com [email protected] +(49)-08223-4002-99 +(49)-08223-4002-58DEKompressorOriginalbetriebsanleitung4-11GBCompressorTranslation from the origina …
HC51V(32 pages) |
Wen
OPERATOR’S MANUAL10-Gallon Vertical Tank Air CompressorItem #2279®IMPORTANT:YournewWEN®tooland/orequipmenthasbeenengineeredandmanufacturedtohighstandardsfordependability,easeofoperation,andoperatorsafety.Properlycaredfor,itwillgiveyouyearsofrugged,troubl …
2279(19 pages) |
kincrome
RANGER 12V AIR COMPRESSOR RANGER12V AIRCOMPRESSORK13012ED1 July 2017 4.6MCOILEDAIRHOSE150PSIMAXWORKINGPRESSURE72LPMMAXIMUM ALL ACCESSORIESINCLUDED DEFLATORFUNCTION
…
Ranger(12 pages) |
dixell Thermostat WING XW60LPDF Guide (@EWIQN9), dixell WING XW60L Thermostat (15.01.2024) WING XW60L, 4 |
Sachtler Camera Accessories flowtech 75flowtech 75 (Camera Accessories ePDF User Guide, #791I25) flowtech 75, 20 |
Zanussi Washer/Dryer ZWD 14791 WUser Guide: Zanussi ZWD 14791 W (G69C59, Upd.08th Nov 2023) ZWD 14791 W, 36 |
Rimage Printer Producer III 7100Producer III 7100 Operation & user’s manual - PA79Z1 Producer III 7100, 120 |
Emerson Kitchen Appliances Micro Motion Elite Coriolis Micro Motion...#7695AC: Micro Motion Elite Coriolis Micro Motion... Kitchen Appliances Installation manual Micro Motion Elite Coriolis Micro Motion..., 38 |
XTZ Speakers 99.36 MKII Walnut#E7JV53 99.36 MKII Walnut: XTZ Speakers Owner Documentation 99.36 MKII Walnut, 13 |
Crown Coffee Maker ELTM-100Coffee Maker #52O1NK ELTM-100, 2 |
Dell Server PowerEdge R720 tPDF User Guide (@163658), Dell PowerEdge R720 t Server (03rd Oct 2023) PowerEdge R720 t, 62 |
Belkin Network Card BLUETOOTH USB ADAPERPDF Manual (@92DOA5), Belkin BLUETOOTH USB ADAPER Network Card (29.11.2023) BLUETOOTH USB ADAPER, 392 |
Daikin Heat Pump EHVH04S18CAEHVH04S18CA (Heat Pump ePDF Guide, #QNPOJ3) EHVH04S18CA, 28 |
Devolo Adapter 200 AVplusDevolo Adapter 200 AVplus Specifications 200 AVplus, 2 |
Vantec Docking Station DSH-300U3#4QA33X DSH-300U3: Vantec Docking Station Owner Documentation DSH-300U3, 15 |