Baxi Fires Division Memphis 5 Operating & Installation Manual

Text of Baxi Fires Division Memphis 5 User Guide:

• Baxi Fires Division Memphis 5, Baxi Fires Division, Wood Lane, Erdington Birmingham B24 9QP Memphis 5 & 7 Gas Stoves Operating & Installation Manual PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE FOR USE IN COUNTRIES GB & IE REV 1 (Memphis 7 Gas Stove) Memphis 5 G.C No. 0504401 Memphis 7 G.C No. 0504411

• Baxi Fires Division Memphis 5, Memphis 5 & 7 Gas stoves 19 SERVICING DOOR TRIM Memphis Fire doors are fitted with a brushed steel finish trim as standard. The trim is secured using 3 off tabs and located in the slot section of the trim and secured with 3 off nuts. (See Fig. 11a below.) Fig. 11a Location of the 3 off tabs Note! To fit a tracery the trim must first be removed. The fire door can only be fitted with one item at a time. REPLACEMENT OF THE DOOR TRIM Ensure the appliance is cold. Step 1 Remove the fire door. This i

• Baxi Fires Division Memphis 5, Should you have any questions about your Memphis Gas Stove that is not covered in this manual please contact your Wonderfire retailer. Please keep all repair receipts safely. Please ensure you have this manual available when an engineer visits as they will complete the service record chart. Memphis 5 & 7 Gas stoves 27 SERVICE RECORD Date of Visit Company Work Carried Out Signature

• GENERAL COMPONENTS Spare parts can be obtained by contacting the original supplier of the fire or Wonderfire. Fire Body Ancillary Components. Only use genuine Wonderfire parts. ACCESSORIES AND OPTIONS Paint- Matching aerosol paint to tone in any connecting flues, pipes or surrounding metalwork Tracery or Trim - Note: When fitted one replaces the other. Add on Canopies Memphis 5 - L

• Baxi Fires Division Memphis 5, LIGHTING & CONTROLLING THE FIRE Under no circumstance must the fire be operated if the glass is cracked or broken. Open the gas control access door situated at the bottom of the appliance. Always use the control door HANDLE. Step 1a. To ignite the pilot push the control knob in, turn anti-clockwise towards the spark position and hold in for 15 seconds. (Fig 5a) The pilot can be viewed through the L/H & centre front slots in the base matrix. Fig 5a Step 1b. Keep the control knob pressed in and turn anti-clockwise to the pi

• Baxi Fires Division Memphis 5, 24 Memphis 5 & 7 Gas stoves SPARE PARTS 1. Memphis 7 Coal Set - AFGS1075 AFGS1074 - AFGS089 AFGS089 AFGS090 AFGS090 AFGS091A AFGS091 AFGS1073 AFGS1073 AFS047 AFS047 1a. Memphis 5 Coal Set 2. Co-pilot assembly 3. Elbow Injector 4. Gas Control Valve 5. Magnetic Catch for Wonderfire Gas Fires. 6. Hinge Kit To Fit either Door. Comprises 2 Hinges & 4 Fixings Per Set. Part Description Visual Aid (not to scale) Memphis 5 Part No. Memphis 7 Part No.

• Baxi Fires Division Memphis 5, HEARTH REQUIREMENTS To comply with current Building Regulations the fire must stand on a fireproof hearth, which has an upper fireproof layer of 12mm non-combustible material. If the rear of the fire is to be pushed up against a surface it must be of a non-combustible material. The hearth must protrude at least 25mm in front of the glass window and 150mm either side. The hearth must not be capable of inadvertent covering by a carpet or rug. This should be achieved by either: The hearth being 50mm above the level of the room floor. A 50mm hi

• Baxi Fires Division Memphis 5, References in this manual to British Standards and Statutory Regulations and Requirements apply only to the United Kingdom. For Ireland the rules in force must be used. Before installation, check that the local distribution conditions, nature of the gas, pressure and the adjustment of the appliance are compatible. The manual is an important part of the appliance and must by law be handed to the end user on completion of the installation. SAFETY NOTICES • Do not attempt to burn rubbish or any other material in this appliance. • This fire must only be operated with the fire door shut and secur

• FIRE TESTING Flame failure device testing Step 1 Ignite the appliance in accordance with page 9 and run for 60 seconds. Step 2 Turn the appliance off to extinguish the pilot, listen for a snap at the control valve. This should occur within 60 seconds of the pilot flame being extinguished. The snap sound will be the magnet disengaging, and thus shutting off the flow of gas

• Baxi Fires Division Memphis 5, ARRANGING THE COALS Safety Notice - Please see SAFETY NOTICES ref. Coal set page 4. Warning: The coals and the coal matrices are fragile ensure they are handled carefully. Ensure location is correct. Do not force the matrix into position. If the coals and/or the coal matrices are damaged they must be replaced with genuine Wonderfire replacement sets. Warning: An incorrect coal layout may cause soot to build up inside the fire and therefore invalidate the guarantee. Ensure the appliance is cold. Step 1 Place the base matrix on the matrix plate centrally between the

• Baxi Fires Division Memphis 5, FITTING THE LINING PANELS Memphis 7 only. The lining panels supplied are to be installed into the fire before the coal matrix is fitted. Note: The lining panels are reversible (brick or plain pattern) Ensure the appliance is cold. With the fire door open, the glass retaining frame and the coal set removed, proceed as follows: Do not force the linnings into position. 1. Position the rear lining face down at the rear of the fire. Ensure the arched cutout faces the rear of the fire. Fig. 3a Positioning the rear lining 2. Locate side lining

• Baxi Fires Division Memphis 5, FINAL FACTORY CHECK LIST Model.................................. Serial No............................. I’ve checked it and it’s O.K. Assembled by............................. Checked by ................................ Date of Purchase.................................... Name and address of supplier....................................................................... ....................................................................................................................... ....................................................................................................................... * Please ensure installer completes INSTALLATION CHECK LIST details on p

• Baxi Fires Division Memphis 5, Memphis 5 & 7 Gas stoves 17 INSTALLATION CHECK LIST CHECKLIST Hearths, Fireplaces, Flues and chimneys This checklist is to ensure hearths, fireplaces, flues and chimneys are satisfactory, and to show what you have done to comply with the requirements of The Building Regulations 2000 Approved Document J 2002. 1. Building address, where work has been carried out....................................................................................................................................... .............................................................................................

• Baxi Fires Division Memphis 5, HELPLINES THE BAXI FIRES & STOVES HELPLINES You can expect the very highest standards of service from Baxi. For fires and stoves after sales service please call 0870 6061064. a.) Your Post Code b.) Type of Fire c.) Model/Name d.) Serial Number e.) The Fault, Problem or Request Memphis 5 & 7 Gas stoves www.baxifires.co.uk Baxi Fires Division Wood Lane, Erdington, Birmingham B24 9QP To help us quickly help you, please try to have the following information available before you contact us:

• Baxi Fires Division Memphis 5, Fig. 7b. Fig. 7c FIRE LOCATION The appliance must not be installed in a room or space, which contains a bath or shower. This fire is designed for use with either top or rear flue outlets and must be mounted on a hearth with a minimum of 12mm non-combustible material thickness. There must be a minimum of 200mm clearance from the sides of the fire to any combustible sidewalls. Fig7a. For clearance from the top of the fire to any combustible shelf. Fig 7b. (See Graph 1). There must be a minimum of 230mm from the

• Baxi Fires Division Memphis 5, Fig 5d Fig 5e Step 3. To turn the main burner off while keeping the pilot alight, rotate the operating knob back to the PILOT position. (Fig 5e) Fig 5f Step 4. To extinguish the pilot, turn the control knob to the OFF position. (Fig 5f) Incorporated into the pilot assembly is a flame failure device designed to shut off the gas supply in the event of the pilot flame being extinguished while the fire is unattended. Should the pilot flame blow out accidentally or intentionally whilst the fire is running, no attempt should be made to re-light the gas for at least three minutes. To restart the fire turn the control knob to the off

• Baxi Fires Division Memphis 5, 6 Memphis 5 & 7 Gas stoves OPERATING INSTRUCTIONS FIRE DIMENSIONS Category I 2H For use in GB and IE at a supply pressure of 20mbar TECHNICAL DATA Memphis 5 Natural Gas Memphis 7 Natural Gas Main Burner Injector Max. Heat Setting Heat Input (net) 3.7 kW 5.0 kW Gas Rate 0.391m 3 /hour 0.529m 3 /hour Cold Setting Pressure 1.5mb 3.5mb Min. Heat Setting 2.4 kW 3.3 kW Bray 82-700 Bray 82-700 Aeromatic AC13/112511 (mod 334) Aeromatic AC13/112511 (mod 334) Heat Input (net) Gas Rate 0.254 m 3/ hour 0.349 m 3 /hour NOx CLASS CLASS 4 CLASS 4 Fig. 2

• Page INTRODUCTION Safety Notices 4 General Information 4 Statutory Requirements 5 OPERATING INSTRUCTIONS Technical Data 6 Fire Dimensions 6 Fitting the Lining Panels 7 Arranging the Coals 8 Lighting & Controlling The Fire 9-10 INSTALLATION Installing The Fire 11 Fitting The Feet 11 Flue System 11-13 Fire Location 13 Combustible Shelf Clearances 14 Hearth Requir

• Baxi Fires Division Memphis 5, DETAIL OF PILOT ASSEMBLY It is strongly recommended to leave the pilot on permanently. This will keep the fire and its components, including the ceramic coal set in a warmer state and assist ignition to the burner. This in turn will reduce condensation in the chimney and any associated flue problems. The pilot can be viewed through the L/H & centre front slots in the base matrix. Fig. 10 18 Memphis 5 & 7 Gas stoves SERVICING

• Memphis 5 & 7 Gas stoves 25 SPARE PARTS AFGS1085 AFGS1085 AFGS1076 AFGS1077 AFGS080 AFGS080 AFS094A AFS095 AFGS1078 AFGS1079 AFGS1080 AFGS1081 7. Control Door Handle Assembly 8. Burner & Fixing 9. Pipe Set Complete With Connectors 10. Decorative Door Surround (Trim) 11. Fire Door Assembly complete with Magnet Lock and Trim 12. Glass Replacement Kit with Gasket & Fixing

• Baxi Fires Division Memphis 5, IMPORTANT NOTICES A qualified gas engineer must carry out the installation and servicing of this appliance in accordance with these instructions and in compliance with current Building Regulations. Such person must be a registered CORGI engineer. This appliance is designed to run on natural gas only. Warning - Only use the appliance with the specified gas. The fire is fitted with a safety device to shut down the appliance if there is inadequate flue draw. If the fire shuts down for no apparent reason check chimney and air inlets to the room. In all cases the fire must no

• Baxi Fires Division Memphis 5, BURNER ASSEMBLY To remove the burner assembly proceed as follows; Ensure the appliance is cold. Step 1 Turn off the gas supply at the gas service cock. Step 2 Disconnect the supply inlet pipe at the rear of the fire. Step 3 Open door and remove the glass frame and glass gasket assembly. Step 4 Remove the coal set and fire box linings. Step 5 Remove the matrix location plate. Undo the three retaining nuts and lift out. Step 6 Remove the heat shield. Undo the two retaining nuts located on the left hand side of the shield. Slid

Related Products and Documents (Cooktop):

Comparable Devices:

Similar Resources:

• Samsung DG68-00297A (46 pages) imagine the possibilitiesThank you for purchasing this Samsung product. To receive more complete service, please register your product atwww.samsung.com/global/registerElectric Rangeuser manualFE-R400SXFE-R400SWFE-R400SBFE-R400_XAC_DG68-00297A.indd 1 2010-03-23  5:47:01 …

• Whirlpool GS773LXSB1 (10 pages) COOKTOP PARTS1For Models: GS773LXSQ1, GS773LXSB1, GS773LXSS1 (Designer White) (Black) (Stainless Steel)12−07 Litho in U.S.A. (mo)Part No. W10181236 Rev. A30" GAS FREESTANDINGSELF CLEAN RANGESEALED BURNERGOLD LINEIllus. PartNo. No. DESCRIPTIONIllus. PartNo. No. DESCRIPTIONIllus. PartNo. No. DESCRIPTIO …

• Jenn-Air PRO-STYLE 8112P342-60 (36 pages) JENN-AIR PRO-STYLE ® SEALED GAsCOOKTOPSTABLE OF CONTENTSImportant Safety Instructions .....................................]-3Using Your Cooktop ......................................................4-6Care & Cleaning ..............................................................7-8Troubleshooting ........................................................ …

• Whirlpool Ranges (20 pages) SELF-CLEANINGELECTRIC RANGESUse & Care GuideFor questions about features, operation/performance,parts, accessories or service, call: 1-800-253-1301.In Canada, call for assistance 1-800-461-5681, for installationand service, call: 1-800-807-6777or visit our website at...www.whirlpool.com or www.whirlpoolappliances.caTable of Contents...................... …

• Falcon 350 (4 pages) T100699 Ref.1E350/30FOUR HOTPLATE RANGEUSERS INSTRUCTIONSFalcon Foodservice EquipmentHEAD OFFICE AND WORKSWallace View, Hillfoots Road, Stirling. FK9 5PY. Scotland.SERVICELINE CONTACT -PHONE - 01438 363 000 FAX - 01438 369 900SECTION 1 - GENERAL DESCRIPTIONSECTION 2 - CONTROLS and OPERATIONSECTION 3 - COOKING HINTSSECTION 4 - CLEANING and MAINTENANCEThis app …

• GE JGP329 (32 pages) 1BEFORE YOU BEGINRead these instructions completely and carefully.• IMPORTANT ³ Save these instructions for local inspector’s use.• IMPORTANT ³ Observe all governing codes and ordinances.• Note to Installer – Be sure to leave these instructions with the Consumer.• Note to Consumer – Keep these instructions for future reference.• Produc …

Comments, Questions and Opinions: