Electrolux ESF 475 Operating Instruction

Text of Electrolux ESF 475 User Guide:

• AW 445 AW 445 T AW 455 T AW 465 AW 475 Graphic project VISUAL DIVISION Milan Italy Operating instruction MANUAL Nilfisk-Advance Italia S.p.A Località Novella Terza 26862 Guardamiglio (Lodi) Italia Tel. +39 0377 451124 Fax +39 0377 51443 S31E47UKIN(1)99-01 S31E47UKIN(1)99-01

• Electrolux ESF 475, INDEX INTRODUCTION AND WARNINGS .......................................1 UNPACKING ......................................................................2 TECHNICAL SPECIFICATIONS ............................................3-5 MACHINE CONTROLS AND MONITORS ...............................6 PREPARATION FOR USE .................................................7-11 SCRUBBING AND DRYING OPERATION ........................12-17 CLEANING OR REPLACING THE BRUSHES ..........................18 MAINTENAN

• Electrolux ESF 475, INTRODUCTION AND WARNINGS 1 INTRODUCTION This manual is a guide to the efficient use of the machine and also contains practical information concerning the functioning, adjustments and user maintenance of your new scrubber/drier. Your machine has been designed and constructed to ensure maximum performarnce and ease of operation in a wide variety of applications. Before delivery, the machine has been tested in our factory and by our distributor to ensure that it is delivered to you in perfect condition. To maintain the machine in this condition and guarantee functioning without problems, it is essential that the periodic maintenance operations indicated in this manual are p

• Electrolux ESF 475, 2 Check that you have received the following parts together with the machine: 1 - Connecting hose for squeegee 2 - Plastic bag with cables for connection of batteries NOTE : Not supplied with mains cable versions of models AW445 , AW445 T and AW455 T . 3 - Squeegee 4 - Documents UNPACKING For models AW445 , AW445 T and AW455 T : Kit of cables to transform the machine from mains version to battery operated version. Mains unit (or transformer) to change the machine from the battery operated version to the m

• 3 TECHNICAL SPECIFICATION 22 OPTIONALS In addition to the normal accessories supplied with the machine the following optionals are available: Batteries: - For models AW465 and AW475: four 6 V batteries 240 amp.h wet type. - For models AW445 T and AW455 T: two 12 V batteries 140 amp.h wet type. - For model AW445 : two 12 V batteries 115 amp.h we

• Electrolux ESF 475, 4 21 Regularly inspect the squeegee for damage or wear to the lips. The lips may be easily replaced by unscrewing the retaining strips; remove the lips, replace with the new ones then screw the cover strips back again to retain them. The rear lip can be turned to be used on both upper and lower sides. MAINTENANCE TECHNICAL SPECIFICATION MODELS AW 455 T BATTERY AW 455 T CABLE Voltage 24V 220VAC-24VDC Drive motor 24V-120W 24V-120W Vacuum motor rating 540W-3 stages 540W-

• 520 MAINTENANCE Periodically remove the filter inside the dirty water tank, scrub it with a stiff brush under running water to remove any accumulated foreign matter. Note: This operation is very important to prevent the reduction of the suction (drying) capability of the squeegee. The plastic buffles can be easily removed for the best cleaning of the tanks. The three solenoid va

• Electrolux ESF 475, ON OFF MACHINE CONTROLS AND MONITORS 1 4 11 6 13 14 15 16 17 18 19 20 21 22 23 1 - Scrubbing detergent flow adjustment push button 2 - Suction motor operation indicator 3 - Scrubbing detergent tank empty indicator warning 4 - Scrubbing detergent flow monitor 5 - Scrubbing detergent flow: boost pump monitor 6 - Scrubbing detergent flow: boost pump on/ off push button * 7 - Multifunction display 8 - Push button for selection of runtime or battery voltage 9 - Brush release push button 10 - Master key switch 11 - Recovery tank full warning indicator 12 - Bru

• Electrolux ESF 475, 718 To replace the brushes (or to clean them) carry out the following sequence of operations: The machine must be switched on but all functions switched off; it means that the squeegee must be lifted. Raise the brush unit by pressing down the relevant pedal and latching it in its lowest position. Press the brush release push button A momentarily (1 or 2 seconds) and the brushes will be unloaded from the machine. Move the machine backward by rolling the drive control thumb wheels rearward until the brushes are visible in fro

• Electrolux ESF 475, + - + - - + + - 8 PREPARATION FOR USE For models working with batteries follow the instructions below, whereas in the case of mains operated models the transformer (or mains unit) has already been placed inside the machine and needs no further installation. The batteries are supplied without liquid, therefore they must be filled up with the appropriate acid solution (concentration greater than 30%) before they can be used. Take special care when handling the acid solution as it is corrosive. If it should come into contact with skin or eyes, wash abundantly with water and consult a doctor. The AW445, AW445 T and AW455 T models use two 12 Volt batteries connected in ser

• Electrolux ESF 475, 9 PREPARATION FOR USE After filling the batteries must stand for at least 1 hour and then they must be filled up if necessary. After one further hour the batteries must be recharged: remove the battery caps during the recharge operation. The new batteries will gradually “run in “ and will increase their capacity. The maximum capacity will be achieved in about 10 charge/discharge cycles. When necessary the batteries must be charged using an appropriate battery charger. Remove the battery caps during the charging operation. Check that the Volt and Hertz reading of the mains suppl

• Electrolux ESF 475, 10 A B ON OFF 15 For models equipped with parking brake: press pedal A to engage the brake. Press pedal B to disingage it. Drop the brushes roughly side by side in front of the machine; the actual position does not matter. Switch the machine on by turning the key switch a quarter of turn clockwise. Wait momentarily until the multifunction display lights showing the battery voltage. PREPARATION FOR USE Drive the machine forward by holding the hand- grips, then rolling the thumb wheels forward until the machin

• Electrolux ESF 475, 11 Drive the machine forward by holding the hand- grips, then rolling the thumb wheels forward until the machine moves completely over the brushes. To stop release the thumb wheels and they will return to a neutral position. This will ensure the brushes are fully located under the drive plates. NOTE: for the models without traction the machine must be pushed over the brush. Lower the brush unit by pushing the pedal to the right to unlatch it. Then allow it to rise as far as it will go. The brush motors will start automatically; the indicator will light and the motors

• Electrolux ESF 475, 12 SCRUBBING AND DRYING OPERATION Once the brushes have been locked on, raise the brush unit by pushing the pedal down and latching it at its lower position. Now the machine is ready for use. Open the tank lid. Fill the left tank with water to about 75mm (3”) from the top edge then add the scrubbing detergent in a quantity to make a dilution according to its instruction. Too strong a mix wastes detergent, too weak a mix will not work efficiently. The machine is now ready for use; so move off to the site to be cleaned. 13 The heig

More Instructions:

	Electrolux ESF 475 Installation and instruction manual 14-12-2022 20	DOWNLOAD
	Electrolux ESF 475 Installation and instruction manual 22-11-2023 20	DOWNLOAD

Related Products and Documents (Scrubber):

Comparable Devices:

Similar Resources:

• R.P.S. Corporation KODIAK K10 STANDARD Series (29 pages) Operating Instructions (EN)MODELS: 17'' - 20'' Disk Traction17'' - 20'' Disk Pad Assist 20'' Orbital Traction Imported From Wisconsin - USA®Read the Operators Manual before using the machine.Read the Safety Messages before servicing machine.www.kodiakequip.com1711 South StreetRacine, WI 53404 (USA)262-83 …

• CTM MIZAR (92 pages) ATTENZIONE: leggere le istruzioni prima dell’ utilizzo. WARNING: read the instructions carefully before use. ATTENTION: lire attentivement les istructions avant l’usage. ACHTUNG: die anweisungen bitte vor gebrauch sorgfältig lesen. ADVERTENCIA: leer atentamente las advertencias antes el uso de aparado. MI ZA RMI ZA RLAVASCIUGAPAVIMENTIFLOOR SCRUBBER …

• Minuteman ER26 (49 pages) For the ER26, ER2832SCV2832E, SCV2426,SCV280000 & ES2832Automatic ScrubbersService ManualFor the ER26, ER2832SCV2832E, SCV2426,SCV280000 & ES2832Automatic ScrubbersFor:TrainingTroubleshootingAdjustmentsRev. 11/2012 …

• FIORENTINI TERMINATOR-1000 (35 pages) ING. O. FIORENTINI S.R.L. INDUSTRIAL CLEANING MACHINES SCRUBBER MACHINE MOD. TERMINATOR-1000 USER MANUAL …

• LYSON MINIMA Series (30 pages) MANUAL CASSETTE HONEY EXTRACTORS MINIMA SERIES 720 – 800 MM CONTROLLER HE – 01 900 – 1000 MM CONTROLLER HE – 01M Przedsiębiorstwo Pszczelarskie Tomasz Łysoń Spółka z o.o. Spółka Komandytowa 34-125 Sułkowice, ul. Racławicka 162, Polska www.lyson.com.pl, email; [email protected] tel. 33/875-99-40, 33/870-64-02 Siedziba Firmy Klecza Do …

• HAKO Scrubmaster B 120 R (10 pages) Beschreibung Sachnummer PositionDescription Code no. Sheet Pos. Loc.TeilPartOrtBeschreibung Sachnummer PositionDescription Code no. Sheet Pos. Loc.TeilPartOrtBeschreibung Sachnummer PositionDescription Code no. Sheet Pos. Loc.TeilPartOrtBeschreibung PositionDescription Sheet Pos. Loc.TeilPartOrt Beschreibung PositionDescription Sheet Pos. Loc.TeilPartOrtVeri …

Comments, Questions and Opinions: