Dexter Laundry OPL Stack Express Owner's Booklet

Text of Dexter Laundry OPL Stack Express User Guide:

• Dexter Laundry OPL Stack Express, P/N 8514-197-001PR STACK EXPRESS 30 LB (13kg) CAPACITY COMPUTER CONTROL OPL WASHER DEXTER LAUNDRY,

• Dexter Laundry OPL Stack Express,   WASH CYCLE Door locks when machine starts, and remain s locked until cycle is completed. If power is interrupt ed, there will be a 3 Select desired wash C YCLE with and buttons. 2 to 3 minute delay befo re the door can be opened. Load clothes, latch door securely. 5 If bleach is required, add when 4 Press START button.   1 2 Add fabric (Optional) softener. if required, into dispe nser on front of machine (see diagram at right). Put detergent and fabric softener, ADD BLEACH light comes on. Add detergent Bleach Add WASHER INSTRUCTIONS RINSE MODE LIGHTS FLUSH WASH

• Dexter Laundry OPL Stack Express, 30 LB STACK EXPRESS WASHER/DRYER DEXTER LAUNDRY, INC. INSTALLATION INSTRUCTIONS This washer may have been purchased as part of a stacked washer/dryer. In addition to thesr instructions, please also refer to the installation instructions that accompany the dryer when installing this product. All washers must be installed in accordance with all local, state and national building, electrical, plumbing and other codes in effect in the a

• Dexter Laundry OPL Stack Express, Water supply hoses are furnished with each machine. Separate hot and cold water lines must be provided, maintaining 30 P.S.I . (207 kPa) to 120 P.S.I. (827 kPa) water flow pressure. A 140F (60C) degree hot water supply is recommended for best washing results. DRAIN The drain outlet tube at the rear of the machine is 3 inches (76 mm) in diameter. Any drain hose used must be lower than the drain valve to assure proper draining. ELECTRICAL 208-240V/1PH/50/60HZ OR 208-240/3PH/60HZ WARNING SHUT OFF POWER AND WATER BEFORE OPENING ANY SERVICE PANELS.

• Dexter Laundry OPL Stack Express, The washer control may be programmed to send 120V (60Hz) or 24V (50 Hz) output signals for a chemical injection system. The signals are not intended as a power source and must be limited to less than 100 milliamps of current. There is a separate terminal block for connection of the external injection signals. For the injection sources, program codes 0 through 6 are as shown in the table below. Dexter Recommended Connections Controller Programmed Signals Injection Terminal Block Circuits Detergent 1 A Bleach 2 B Starch 3 C Sour/Softener 4 D 5 A and B 6 C and D 0 None

• Dexter Laundry OPL Stack Express, SPECIFICATONS MODEL STACK WASHER/DRYER 30LB EXPRESS WASHER CAPACITY CYLINDER SIZE ELECTRICAL DRIVE SYSTEM WASH SPEED INTERMEDIATE EXTRACT FINAL EXTRACT MACHINE CONTROL WATER INLET DRAIN VALVE 30LBS/4 CUBIC FT. (13.6 kg/113 L) 25” DIA X 14 1/8” DEEP (63.5cm X 36cm) 208-240 VAC, 60 HZ, 1 OR 3 PHASE OR 208-240 VAC, 50HZ, 1 PHASE SOFT START REVERSING INVERTER DRIVE, 2 HP MOTOR 50 RPM 411 RPM (60 G’S) SZ MODEL - 750 RPM (200 G’S) ST MODEL - 532 RPM (100 G’S) PROGRAMMABLE COMPUTER WITH 6 STANDARD CYCLES. 2 SOLENOID OPERATED VALVE

• Dexter Laundry OPL Stack Express, STARTING THE WASHER A. Load the clothes into the cylinder and latch the door securely. Be sure clothing does not get caught between the door gasket and tub front when closing the door. Maximum load is 30 pounds (13.6kg) clothes, dry weight. Do not load the washer with more than 30 lbs. (13.6kg). B. Select the appropriate cycle number (1 through 6) using for the load being washed. See the cycle descriptions in the programming section. Use the UP and DOWN keys to change the cycle number. C. If not using a chemical injection system, add low-sudsing

• Dexter Laundry OPL Stack Express, PROGRAMMING INSTRUCTIONS: Programming can be accomplished manually using the machine controls or by connecting to the machine control using a PDA (personal digital assistant). For instructions on using a PDA with this washer control, please contact your local Dexter distributor. Please read below for manual programming instructions. The keypad layout for the washer control is shown above. WASH CYCLE PROGRAMMING: 1. Turn on the power to the washer. 2. Turn the Run/Program key to the Program position. Display will show “C O” and the “ADD BLEACH” will blink and will continue to blink during the programming mode. 3. Press t

• Ct ** Tumble Time Two-digit amount of time in minutes. t ** Water Temperature HH for hot, CH for warm, CC for cold and EE for no water. L ** Water Level Lo for low, Hl for high. dF * Type of Fill d for delayed fill, t for timed fill. 1 S ** Spin Time Two-digit amount of time in minutes. IS * Injection Source Single digit code indicating injector signal(s).

• Dexter Laundry OPL Stack Express, Cycle 1 Sheets & Pillowcases (Health Care) Bath Bath Cycle Time (min.) Water Temp. Water Level Delay Fill Spin Time (min.) Injection Source Flush 3 CH HI d Prewash 2 CH HI d Wash 7 HH LO d 1 (Detergent) Rinse 1 7 HH LO d 2 (Bleach) Rinse 2 2 CH HI d 1 Rinse 3 2 CH HI d Rinse 4 Final Rinse 4 CH LO d 4 4 (Sour/Soft) Cycle 2 Towels / Pads / Diapers (Health Care) Bath Bath Cycle Time (min.) Water Temp. Water Level Delay Fill Spin Time (min

• Dexter Laundry OPL Stack Express, Cycle 3 White Towels (Hotel / Motel) Bath Bath Cycle Time (min.) Water Temp. Water Level Delay Fill Spin Time (min.) Injection Source Flush Prewash Wash 7 HH LO d 1 (Detergent) Rinse 1 1 HH HI d Rinse 2 7 HH LO d 2 (Bleach) Rinse 3 2 CH HI d 1 Rinse 4 2 CH HI d Final Rinse 4 CH LO d 5 4 (Sour/Soft) Cycle 4 Guest Laundry (Hotel / Motel or Health Care) Bath Bath Cycle Time (min.) Water Temp. Water Level Delay Fill Spin Time (min.) Injection

• Dexter Laundry OPL Stack Express, Cycle 5 Rags & Mops (Hotel / Motel) Bath Bath Cycle Time (min.) Water Temp. Water Level Delay Fill Spin Time (min.) Injection Source Flush 3 CH HI d Prewash 2 CH HI d Wash 2 CH HI d Rinse 1 7 HH LO d 1 (Detergent) Rinse 2 2 HH HI d Rinse 3 7 HH LO d 2 (Bleach) Rinse 4 2 CH HI d 1 Final Rinse 2 CH LO d 5 Cycle 6 Colored Cotton Linen (Food & Beverage) Bath Bath C

• Dexter Laundry OPL Stack Express, RAPID ADVANCE MODE To enter the Rapid Advance mode, turn the key counter-clockwise (CCW). The Rapid Advance setting is not marked next to the key, but turning the key CCW until it stops selects this mode. The Rapid Advance mode can be entered from either the Idle mode or during the cycle. If the cycle has not yet started, press the “START” button. To rapid advance to the next step in the wash cycle, push both the “UP” and “START” buttons at the same time. The display will show an “Ad” (advance) in t

• WASHER ERROR CODES Fault # (F #) Description Customer Action 1 The door failed to close and lock or the door failed to remain locked after three tries of latching the door and starting during the cycle. Turn off the power to the washer. Check wire connections to door /lock switches. Check wire connections from switches to controller. If necessary the

• Dexter Laundry OPL Stack Express, 11 The drive size setting has changed. Turn off the power to the washer. Check to ensure all the harnesses are properly connected to the controller. Check to ensure the drive horsepower is proper for this size of washer. Turn on power to the washer. (See Note) If problem reappears, contact your Dexter representative. 12 Washer controller internal error Turn off the power to the washer. Wait one minute. Turn on the power to the washer. (See Note) If problem reappears, contact your Dexter representative. 13 The control cannot communicate with the drive Turn the power off to the washer. Check the data cable between the c

• Dexter Laundry OPL Stack Express, ACCESSORIES INSTALLATION: (Furnished) QTY. 9990-027-011 Hose, Water Supply 2 8641-242-000 Washer, Inlet Hose 2 9565-003-001 Strainer, Inlet Hose 4 Contact your distributor or Dexter Laundry, Inc. if a steel-mounting base is required. © 2010, Dexter Laundry, Inc. 2211 West Grimes, Fairfield, IA 52556 U.S.A. 1-800-524-2954 www.dexterlaundry.com

Related Products and Documents (Washer/Dryer):

Comparable Devices:

Similar Resources:

• AEG 12710 14710 (60 pages) DRYINGCOLD403060403060 E604030MINIPROGRAMM50RINSEHOLD1200900700500STARTPAUSEDRYINGTIMEWAS HTIMEDELAYSTARTSTAIN QUICKSPINSPEEDPRE-WAS HEASYIRONRINSECLEANFILTERPREWASHWAS HDRYENDDRAINSPINCOTTONEASY-CARE50DRYINGDELICATESWOOLRESETSPINDRAINSOFT-ENERRINSESSOAK95L 12710 VIT3040ON/OFF5 mmWasher-DryerInstruction BookletPERFEKT IN FORM UND FUNKTIONLAVAMAT TURBO 12710 …

• Maytag Commercial MLG22PR (32 pages) INSTALLATIONINSTRUCTIONSORIGINAL INSTRUCTIONSCOmmeRCIAL STACked WASheR/dRyeR GASwww.maytagcommerciallaundry.com W11295154AMLG22PRMLG22PDMLG22PN4IMPORTANT SAFETY INSTRUCTIONSprecautions, including the following:WARNING: Read all instructions before using the dryer.Keep a minimum clearance of 100 mm (4 in.) between therear of the dryer and any wall. The oper …

• Haier 650 (20 pages) Service-650Twin-tub Washing Machine Names of the parts.............the 2nd coverSafety precautions ...............................1Installation and adjustment ..................3Introduction of the major functions .......5Preparation before washing ................6The musts in washing .........................7Usage of the detergent ...................... …

• Indesit IWC 6125 S (84 pages) GB1ContentsInstallation, 2-3Unpacking and levellingConnecting the electricity and water suppliesThe first wash cycleTechnical dataDescription of the washing machineand starting a wash cycle, 4-5Control panelIndicator lightsStarting a wash cycleWash cycles, 6Table of wash cyclesPersonalisation, 7Setting the temperatureSetting the spin speedFunctionsDetergen …

• Smeg STA161S1 (9 pages) ISTRUZIONI DI MONTAGGIO DELLE LAVATRICI INTEGRABILI IT ASSEMBLY INSTRUCTIONS FOR BUILT-IN WASHING MACHINES EN MONTAGEANLEITUNG FÜR EINBAUBARE-WASCHMASCHINEN DE INSTRUCTIONS DE MONTAGE DES LAVE-LINGE INTÉGRABLES FR INSTRUCCIONES DE INSTALACIÓN DE LAS LAVADORAS INTEGRABLES ES INSTRUÇÕES DE MONTAGEM DAS MÁQUINAS DE LAVAR ROUPA INTEGRÁVEIS PT …

• Indesit IWDC 6145 (60 pages) GB1ContentsInstallation, 2-3Unpacking and levellingConnecting the electricity and water suppliesThe first wash cycleTechnical dataDescription of the washer-dryer andstarting a wash cycle, 4-5Control panelIndicator lightsStarting a wash cycleWash cycles, 6Table of wash cyclesPersonalisation, 7Setting the temperatureSetting the drying cycleFunctionsDetergent …

Comments, Questions and Opinions: