Alpine Z4 Installation Manual
|
Alpine Z4, Please initial and route to the following for information before filing X Service Manager X Warranty X Service Technicians - Initial Below X Service Advisor Parts Mgr. X Service Advisor Body Shop X Shop Foreman PDI Dept. FIX IT RIGHT THE FIRST TIME, ON TIME, EVERY TIME 2002 BMW of North America, LLC by: Installation Instructions Page 1 of 12 July 31, 2002 Group Description Bulletin Number Product Development SUBJECT Alpine CD Changer Installation MODEL Z4 (E85) with / with
Alpine Z4, 2 PROCEDURE: CD Changer Preparation 1. Remove the three shipping transport screws (1) from CD changer. 2. Cover the holes where the shipping screws were installed with the 3 adhesive seals (1) supplied with the unit. 3. Adjust the CD changer mechanism pins for proper settings. Mechanism should be set to “H” on both sides of unit for horizontal mounting position.
3 4. Affix the locking squares (2) on the left and right sides of the CD changer chassis to firmly secure the pins (1) in place. For Z4 without Navigation continue below. For Z4 with Navigation continue on Page 9. Vehicle Preparation (Z4 Without Navigation) 5. Lower Soft Top. 6. Disengage Front Panel (1) from mounting points (indic
Alpine Z4, 4 9. Unscrew 2 Phillips-head plastic rivets (1) and remove clips from vehicle. 10. Remove 2 T20 Torx screws (2). 11. Unplug electrical connector attached to microswitch (3). Note: To complete the following steps it will first be necessary to disengage and lift the soft top (1) from its locked position by at least 3 inches. 12. Pull lower half of Upper Panel Cover (2) until it disengages from the lower mounting clips. 13. Pull upper half of Upper Panel Cover upwards until it can be removed from the vehicle. 14
Alpine Z4, 5 18. Remove Left Speaker Grille (1) by carefully pushing outwards (from the rear) or with a non-marring pry tool. Remove 5 T20 Torx screws from left panel (2). 19. Remove Right Speaker Grille (1) by carefully pushing outwards (from the rear) or with a non-marring pry tool. Remove 5 T20 Torx screws from Right panel (2). 20. Carefully remove Left seatbelt guide cover (1), then remove T20 screw (2) and seatbelt guide (3). 21. Remove rubber strips (1) around both left roll bars. Remove rubber cap (2).
Alpine Z4, 6 22. Carefully pull rearwards on rear panel cover (1) and remove from vehicle. Note: Begin to pull rear panel cover from its clip locations nearest to the center of the vehicle. It may be helpful to raise the convertible top to maneuver the cover from its location. 23. Remove 3 T20 screws (1). 24. Pull back drivers door weather-stripping (1) to expose edge of Left panel. 25. Carefully unclip lower Left panel (indicated by black arrow), then remove Left panel (1) from ve
7 26. Remove electrical connector (1) from lamp module. 27. Carefully unthread manual override cable from plastic loop (2). 28. Remove 2 upper T20 mounting screws (3). Remove 2 rubber caps (4), then remove 2 lower T20 mounting screws (5). 29. Carefully pull back on Right panel and maneuver the ABS storage unit out of the vehicle. Be sure to disconnect lamp module co
Alpine Z4, 8 35. Maneuver CD Changer into place, then insert bushings (1) into slots in left bracket assembly. 36. Insert and tighten 2 M5x14 bolts (2) provided in parts kit through Right Hand bracket into clip nuts. 37. Test CD Changer for functionality. 38. Install bracket cage (1) using 4 M5 clip nuts (2) and 4 M5x14 bolts (3) provided in parts kit. 39. Install lamp module (1) removed from ABS storage unit (see step 29) into new small oddments box (2). Thread Manual Override Cable to its lower
Alpine Z4, 9 Vehicle Preparation (Z4 With Navigation) 5. Lower convertible top. 6. Disengage Front Panel (1) from mounting points (indicated by black arrows) by carefully pulling panel towards front of vehicle while in the lowered position. 7. Slide seats forward. Remove left and right lower panel covers (1) and mounting screws (2). 8. Lift rearward and remove switch panel cover (1) to expose mounting screws. 9. Unscrew 2 Phillips-head plastic rivets (1) and remove cli
Alpine Z4, 10 Note: To complete the following steps it will first be necessary to engage the manual release (1) and lift the convertible top (2) from its locked position by at least 3 inches. 12. Pull lower half of Upper Panel Cover (3) until it disengages from the lower mounting clips. 13. Pull upper half of Upper Panel Cover upwards until it can be removed from the vehicle. 14. Remove 2 T30 Torx bolts (1). 15. Unplug electrical connector (2). 16. Rotate Manual Override Cable clip (1) counter-clockwise, then pull to disconnect from override lever.
Alpine Z4, 11 22. Using appropriate tools (1) (BMW P/N 90 88 6 655 400 or equivalent) remove Navigation Module (2) from mounting bracket. Disconnect cables from Navigation Module and remove module from vehicle. 23. Remove plastic bracket assembly (3) from vehicle. Caution: Be careful not to damage manual override cable! 24. Remove 4 M5x14 bolts (1), then remove Navigation bracket (2) from vehicle. 25. Remove LH speaker grille (1) by carefully pushing outwards (from the rear). 26. Remove 5 T20 Torx screws (2) to access open area behind rear panel. CD Changer Installation 27. Install 2 LH mount
Alpine Z4, 12 29. Insert 2 M5 Clip Nuts (1) as indicated. 30. Locate CD Changer Power and Audio leads (2). Connect CD Changer power and Audio leads to CD Changer. 31. Carefully pull back Left rear panel. Maneuver CD Changer into place, then insert bushings (1) into slots in left bracket assembly. 32. Insert and tighten 2 M5x14 bolts (2) provided in parts kit through Right Hand bracket into clip nuts. 33. CD Changer installation is complete. Test CD Changer for functionality. 34. Reinstall all parts removed in reverse order of installation.
Alpine CHA-1214 CD Player Owner's manual
CHA-1214 |
Alpine CHA-S634 CD Player Owner's manual
CHA-S634 |
Alpine DVA-5205P CD Player Setup manual
DVA-5205P |
Alpine CHM-S653RF CD Player Owner's manual
CHM-S653RF |
Alpine CDA-7990 CD Player Owner's manual
CDA-7990 |
Alpine CDE-136BT CD Player Owner's manual
CDE-136BT |
Alpine DHA-S690 CD Player Owner's manual
DHA-S690 |
Alpine DHA-S690 CD Player Owner's manual
DHA-S690 |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Avermedia | AVerTV Mobile iOS EW330 | Manual | avermedia/avertv-mobile-ios-ew330-A65.pdf | 02 Jul 2023 | 44 | |
2 | KLING & FREITAG | GRAVIS 15 | Operating instructions manual | kling-freitag/gravis-15-33R.pdf | 24 Mar 2023 | 32 | |
3 | NETGEAR | XAV1301v1/XAVB1301v1 | Asennusopas | netgear/xav1301v1-xavb1301v1-CG4.pdf | 18 Jan 2024 | 2 | |
4 | Avenview | FO-DVI-1080LC-Set | Operation & user’s manual | avenview/fo-dvi-1080lc-set-934.pdf | 16 Sep 2022 | 8 | 0.59 Mb |
5 | Intel | SL6NQ - Xeon 2.4 GHz/533MHz/512 KB CPU Processor 2.4GHz | Specification | intel/sl6nq-xeon-2-4-ghz-533mhz-512-kb-cpu-processor-2-4ghz-67F.pdf | 11 Oct 2022 | 56 | |
6 | Zenoah | G3300 | Owner's manual | zenoah/g3300-WOS.pdf | 27 Oct 2023 | 16 |
Harman Kardon
Technical ManualThe Harman KardonModel FL8380COMPACT DISC CHANGERDANGER: Invisible laser radiation when open and interlock failed or defeated.AVOID DIRECT EXPOSURE TO BEAM.CONTENTSParts and Service Office250 Crossways Park Dr., Woodbury, N.Y. 117971112-FL8350 P9603 1200 Printed in Hong Kong1. LASER BEAM SAFETY PRECAUTIONS ............. 22. CONTROL AND FUNCT …
FL 8380(70 pages) |
CMX
E-2WARNING: To reduce the risk of electric shock, do not remove cover (or back). No user-serviceable parts inside. Refer servicing to qualified service personnel. CAUTIONRISK OF ELECTRIC SHOCKDO NOT OPENThe exclamation point within the triangle is a warning sign alerting you of important instructions accompanying the product.The lightning flash and arrow …
CD-6800-PM3UC(6 pages) |
Philips
Audio CD RecorderCDR950/951•Instructions for use•Mode d'emploi•Instrucciones de manejo•Bedienungsanleitung•Instructions for use•Mode d'emploi•Instrucciones de manejo•Bedienungsanleitung•Gebruiksaanwijzing•Istruzioni per l'uso•Brugsanvisning•Bruksanvisning•Gebruiksaanwijzing•Istruzioni per l'uso•Brugsanvisning …
CDR950(26 pages) |
Philips
Portable CD PlayerAZT9240CLOCKRADIO•BANDPROGRAMSET••MODEDIGITAL DBBDIGITAL AUDIOCOMPACTDBBFMSTPERSETMINESPESPDIGITAL DYNAMIC BASS BOOSTDIGITAL DYNAMIC BASS BOOSTDBBFMSTPERSETMINAZT9240/01 eng 23/2/01 17:28 Page 1
…
AZT9240/00(81 pages) |
Reloop
10.FaderstartFalls Sie die Anschlussbuchsen -21- mit den Ausgangsbuchsenfür Faderstart Ihres Mischpultes verbunden haben, können Siedem jeweiligen Player vom Mischpult aus starten (beachten Siebitte hierzu die Bedienungsanleitung des Mischpultes).11. Ende der BenutzungBevor Sie das Gerät mit dem EIN/AUS Schalter -17- abschalten,überzeugen Sie sich davon, …
RMP-2660 b(8 pages) |
Sony
SERVICE MANUALMZ-N910Ver. 1.5 2006.05AEP ModelUK ModelE ModelAustralian ModelChinese ModelTourist ModelPORTABLE MINIDISC RECORDER9-877-146-06 Sony Corporation2006E16-1 Personal Audio DivisionC 2006.05 Published by Sony Techno Create Corporation– Continued on next page –US and foreign patents licensed from DolbyLaboratories.Model Name Using Similar Mecha …
MZ-N910(65 pages) |
Braun Electric Toothbrush Oral-B Smart seriesBraun Product User Manual: Oral-B Smart series PDF Quick start manual - ZL6A1Y Oral-B Smart series, 11 |
Carefree Kitchen Appliances MIRAGEUser Guide: Carefree MIRAGE (7M3YP9, Upd.11/01/2024) MIRAGE, 34 |
Sony MP3 Player NWZ-S774BT#S4264O: NWZ-S774BT MP3 Player Operation & user’s manual NWZ-S774BT, 2 |
Juniper Switch EX SeriesSwitch Complete hardware manual (Juniper EX Series) EX Series, 194 |
Fbt Subwoofer MODUS SUBSubwoofer PDF Reference manual MODUS SUB, 1 |
Novation Electronic Keyboard XioNovation Electronic Keyboard Xio Operation & user’s manual Xio, 83 |
Oase Water Filtration Systems BioTec ScreenMatic 12Water Filtration Systems Operating instructions manual (Oase BioTec ScreenMatic 12) BioTec ScreenMatic 12, 13 |
Oster Electric Steamer 111858Oster Electric Steamer 111858 Operation & user’s manual 111858, 23 |
Britax Other DECATHLON#Y4AI47 DECATHLON: Britax Other Owner Documentation DECATHLON, 23 |
HIKVISION IP Camera DS-2CD4025FWD-A#65QX29: DS-2CD4025FWD-A IP Camera Quick start manual DS-2CD4025FWD-A, 37 |
ASROCK Motherboard Z97 Pro4Manual for ASROCK Z97 Pro4 Motherboard Z97 Pro4, 159 |
Panasonic Cordless Telephone KX-TG8021EPanasonic KX-TG8021E Manual (Doc Type: Cordless Telephone Manual ) KX-TG8021E, 10 |