Dometic CC 05 Operating And Installation Instructions

Text of Dometic CC 05 User Guide:

• Dometic CC 05, 2 Congratulations on your purchase of the Cramer gas glass ceramic cooktop CC05. You have chosen a cooking appliance that offers the convenience found in most modern-day households. A. Operating Instructions 1. Using the appliance 1.1 First-time use Before you use the appliance for the first time, make sure: - that the appliance has been installed by an authorized gas specialist with CORGI (Council for Registered Gas Installers) Registration. - that the correct type of gas has been connected! The glass ceramic cooktop is designed for liquid gas, i.e. butane, p

• Dometic CC 05, 3 Important: During initial startup and after replacing the gas cylinder, ignition may take longer than 15 seconds due to air in the gas lines. 1.2 Operation Important: the surfaces of the glass ceramic cooking zones become HOT during operation, even though no open flame is visible. Therefore, DO NOT ALLOW CHILDREN near the appliance! The appliance has two burners. The left burner is larger, with a diameter of 200 mm and a capacity of 1.8 kW. This burner is controlled by the knob in the back. The right burner has a diameter of 180 mm and a capacity of 1.5 kW. This burner is controlled by the knob in the front. Behind each burner there is a warming zone, whic

• Dometic CC 05, 4 2.2 Inspection of the liquid gas system: When are the inspections conducted? - before the first-time operation - at intervals of 2 years What inspection regulations apply? - EN 1949 - EN 1646-1 - EN 721 What else must be inspected? - the installation location together with the appliance - the gas seals of the system and appliance - burning safety - fresh air supply to the appliance and installation location - safety and control devices (especially the pressure regulator) - safety of exhaust system including roof and outer wall fans Who conducts the inspections? - authorized exper

• Dometic CC 05, 5 d) "cera-fix" or "Collo profi" The choice of what to use depends on how dirty the cooktop is: a) Light spills that are not burned on can be wiped off with a damp cloth. b) Larger, dried-on spills can be easily removed with the razor blade scraper. c) Calcium and water deposits, grease and metallic discolorations can be cleaned with a suitable product, e.g. Sidol "Stahlglanz" or "Stahlfix" or "cera-fix" or "Collo profi". Important: All cleaning products must be wiped off completely with a wet cloth. Afterward

• 6 Keep the original packing material. Complaints can be processed only if the appliance is sent in the original package. B. Installation instructions 1. Important The appliance must be installed by an authorized technician registered by CORGI (Council for Registered Gas Installers). Output of the appliance (Hs) High setting: 1.8 kW (left burner) + 1.5

• Dometic CC 05, 7 If the gas tap becomes sluggish or jammed, then it must either be replaced or the affected tap removed from the chamber, cleaned in benzine and lubricated with a special gas tap grease, e.g. type "Staburgas no. 32" from the Klüber company in Munich. This work must be carried out by a professional gas technician. The pressure regulators used between the gas cylinder and the appliance must comply with the categories in the following table: Appliance category Supply pressure Gas Rating of the pressure regulator I 3+ 28-30/37 m

• 8 3. Connection of the appliance to the gas supply Only gas-tight fittings may be used for connecting the appliance to gas lines, in accordance with EN 1949. The pipes for connecting the appliance should be made of galvanized iron or of copper. These pipes must be used with a gas-tight fitting. After the connection has been established, the gas lines should be checked by applying a soap

• Dometic CC 05, 9 6. Visual check of flame The burners of the Cramer glass ceramic cooktop burn beneath the glass ceramic panel. Due to the dark shade of the panel, the ignited burner is not visible until approximately 1 minute after ignition. Due to a patented feature of the burner, only part of the burner surface is red hot, resulting in a pattern similar to a cake from which every other piece has been eaten. - The flame must burn steadily and with an even color. - If the flame does not burn evenly, check to make sure that the inlet and outlet openings are unobstructed. Any obstructions must be removed. - If in doubt, consult a s

• Dometic CC 05, 10 9. Mounting the appliance For the installation of the appliance, there must be a free space as indicated in Fig. 1 – 6, depending on the individual model (see type plate on appliance). The installation location is limited only as follows: there must be a distance of at least 400 mm between the cooktop and any furniture above (e.g. hanging cabinets). The appliance rests on the frame in the kitchen furniture. It must be fastened firmly to the kitchen countertop using the included screws and 4 fastening elements (see Figure 1). Do not use the gas lines, taps or parts of the burner for fastening. Beneath the bottom of the appliance there must be a space of at least 10 mm in o

• Dometic CC 05, 11 Fig. 2 Exhaust gas and fresh air inlet flues, horizontal right rear (outside wall flue system, see Fig. 6) Cramer air inlet pipe 30 Truma flue pipe 80 Art.no. 39580-00 Art.no. 39320-00 Cramer outside double flue Truma flue pipe 55 Fig. 3 Exhaust gas and fresh air inlet flues, horizontal right side (outside wall flue system, see Fig. 6) Cramer outside double flue Truma flue pipe 55 Art.no. 39320-00 Truma flue pipe 80 Art.no. 39580-00 Cramer air inlet pipe 30

• Dometic CC 05, 12 Fig. 4 Exhaust gas and fresh air inlet flues, horizontal left side (outside wall flue system, see Fig. 6) Cramer outside double flue Cramer air inlet pipe 30 Art.no. 39320-00 Truma flue pipe 55 Truma flue pipe 80 Art.no. 39580-00 Fig. 5 Exhaust line, left vertical. Fresh air flue line, vertical from below through floor of vehicle Truma flue piper 55 Art.no. 39320-00 Truma roof flue Art.no. 30700-03 Truma flue pipe 80 Art.no. 39580-00 Cramer air inlet pipe 30 Cramer tube 30 Art.no. 39061-00 Truma floo

• 13 Fig. 6 Outside wall flue system The flue gas line through a flue pipe must never be installed at a slope. The maximum permissible length of the flue gas line is 2000 mm. The walls and elements located closer than 50 mm to the flue gas line must be covered or protected by materials of fireproof class M0 (see specified standards), e.g. TRUMA flue pipe ∅ 80, art. no. 3958

• Dometic CC 05, 14 The air inlet line, made of flexible metal pipe with a diameter of 30 mm (Cramer), must be fastened at the air inlet of the appliance and at the Cramer outside double flue according to Figures 2, 3 and 4 with a worm drive hose clip, 25 – 40 mm ∅ (Cramer). 10. Do not install the appliance near highly flammable materials. 11. Removing the appliance from the furniture - Close main gas valve - Remove fastening screws - Disconnect gas connection and any electric cables 12. Technical data and CE approval number a) Technical data: - Glass ceramic cooktop: model CC05 - Appliance category: I 3 - Output: 3.3 kW - Gas consumption: 240 g/h, propane/butane - Ele

Related Products and Documents (Cooktop):

Comparable Devices:

Similar Resources:

• Kenmore 66575832000 (17 pages) Table of Contents:Before you start ........................... 2Product dimensions ........................ 6Cabinet dimensions/requirements ............ 6Electrical requirements ................... 8-9Gas supply requirements .................. 10Installation steps ...................... 12-21Gas conversions ....................... 22-28If range does not ope …

• Bosch HGS5053UC-01 (24 pages) INSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER.IMPORTANT: SAVE FOR LOCAL ELECTRICAL INSPECTOR'S USE.READ AND SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.If the information in this manual is not followedexactly, a fire or explosion may result causing propertydamage, personal injury or death.FOR YOUR SAFETY:m Do not store or use gaso …

• IKEA ICS300RQ04 (20 pages) form ®byWHIRLPOOLCORPORATIONGASSEALEDBURNERCOOKTOPFor questions about features, operation/performance,parts, accessories or service, call: 1-800-253-1301.In Canada, call for assistance, installation and service, call: 1-800-807-6777or visit our website at www.ikea.comTABLEDECUISSON.A.BRULEURS.A.GAZ SCEL_SAu Canada, pour assistance, installation ou service, …

• Heartland 9200 (2 pages) 1Due to continuing product improvements, Heartland Appliances reserves the right to amend specifica-tions without notice. Please contact Heartland for the most up to date information, as it applies to prod-uct being purchased, or download latest Site Preparation Specifications from www.heartlandapp.com.Installation RequirementsAga-Heartland 1050 Fountain St …

• GE JBS03 (37 pages) GEAppliances.comOIJJSafety Information ............ ~-~Operating InstructionsAdjust the OvenThermostat .........................20Clock and Timer .................14, 15Oven............................11-13Oven Controls ....................9, 10Sabbath Feature ................18, 19Selecting Types of Cookware ........8Self-Cleaning ....................23, 24 …

• Gibson Oven Interior (16 pages) OWNER'SGUIDCoil Surface ElementsPorcelain Enamel orContinuous CleaningOven InteriorREAD AND SAVE THESE INSTRUCTIONSfContentsProduct Registration ......................................................... 2Versibn en espa_ol ........................................................... 2IMPORTANT SAFETY INSTRUCTIONS ............................... 3-4Settin …

Comments, Questions and Opinions: