Columbia CR-10 Chariot Owner's Manual

Text of Columbia CR-10 Chariot User Guide:

• Columbia CR-10 Chariot, Preface Welcome, and congratulations on your choice of vehicle from Columbia ParCar Corp.! Your vehicle has been designed and manufactured to conform to applicable sections of ANSI B56.8. Your safe use and operation of your vehicle is important to us. Any alteration of your Columbia vehicle that results in the vehicle being in noncompliance with applicable ANSI standards is strictly prohibited. Columbia ParCar Corp. is not responsible or liable for any damage that results from any such alteration, and all warranties for any such altered vehicles are null and void. These vehicles are not designed for over-the-road use. They do not conform to Federal

• Columbia CR-10 Chariot, 6.0 VEHICLE STORAGE (over 6 weeks) 6.1 BATTERY PREPARATION Before storage make sure batteries are fully charged and the electrolyte is full in all cells per Section 4.2. Clean the batteries and connections per Section 4.3. Recharging will be necessary during storage. Frequency for recharging is as follows: STORAGE TEMPERATURE CHARGE AT Below 4 0 C (40 0 F) Every 6 months 4 0 C - 16 0 C (40 0 – 60 0 F) Every 2 months Above 16 0 C (60 0 F) Once a month The specific gravity of the electrolyte should be checked every 6 to 8 weeks using a hydrometer. See Section 4

• Columbia CR-10 Chariot, Your safety and the safety of others depend on your safe operation and maintenance of this vehicle. Prior to operation, you, the operator, must be thoroughly familiar with this and all other sections of this manual. 2.3 SAFETY WARNINGS For personal safety and to maintain stability and control, operate this vehicle under these conditions only. Failure to comply with these warnings may result in bodily injury and property damage.  Do not drive this vehicle unless you are a qualified and trained operator and familiar with the vehicle operational controls.  Never exceed the

• 1.0 INTRODUCTION This manual provides important safety information, operating instructions, model specifications and maintenance instructions for the CR-10 Chariot. The information in this manual is limited to care and maintenance information only. Information covering repairs and technical service is provided in detailed service manuals available from Columbia Deal

• Columbia CR-10 Chariot, 4.0 ELECTRIC SYSTEM 4.1 IMPORTANT INFORMATION The type of battery used in a Columbia vehicle has a service requirement which is quite different from that of an automotive battery. The electric vehicle battery supplies all of the power to drive the vehicle. During operation the power stored in the batteries is expended. While the amperage drain rate can vary greatly depending on the type of service, the duration of use and the number of "starts" and "stops" made during a day, the batteries nevertheless progress through each duty

• Columbia CR-10 Chariot, 3.0 OPERATIONS AND CONTROLS 3.1 INSPECTING THE VEHICLE Upon receipt of vehicle, perform a pre-delivery inspection of the vehicle. Also, before using the vehicle, there are checks that must be performed to ensure that it is in safe proper working order. NOTICE: Vehicle should be inspected immediately after delivery. Use the following guidelines to make sure there are no obvious problems. Examine the contents of all packages and accessories that may have come in separate packages with this vehicle. Make sure everything listed on the packing slip is there. Items should not be broken or damaged. Examin

• Columbia CR-10 Chariot, 5.0 SERVICING YOUR VEHICLE 5.1 MAINTENANCE GUIDELINES To ensure that the vehicle is kept in a safe and correct operating condition, it must be inspected and maintained on a regular basis. Proper lubrication, electrical control adjustments, safety feature checks, etc. performed at recommended intervals will help prevent damage or failure of the unit while providing optimum performance. Follow the guidelines below to assure proper maintenance.  Allow only trained maintenance personnel to maintain, repair, and

• Columbia CR-10 Chariot, TABLE OF CONTENTS 1.0 INTRODUCTION 1.1 SAFETY MESSAGES 1.2 VEHICLE DESCRIPTION 1.3 VEHICLE IDENTIFICATION NUMBER (VIN) 1.4 VIN MATRIX 1.5 VEHICLE SPECIFICATIONS 2.0 SAFETY 2.1 GETTING STARTED 2.2 SAFETY VEHICLE STATEMENTS 2.3 SAFETY WARNINGS 2.4 SAFETY CONCERNS 2.5 LIFTING INSTRUCTIONS 2.6 BATTERY DISCONNECT METHODS 2.7 BATTERY REMOVAL AND INSTALLATION 3.0 OPERATIONS AND CONTROLS 3.1 INSPECTING THE VEHICLE 3.2 WHAT TO DO IF YOU HAVE A PROBLEM 3.3 VEHICLE CONTROLS 3.3.1 KEYSWITCH 3.3.2 BATTERY STATE OF CHARGE METER 3.3.3 HORN BUTTON

• Columbia CR-10 Chariot, Owner’s and Operator’s Manual CR-10 Chariot Electric Vehicles PN 709642-03 5/2011

• 3.3 VEHICLE CONTROLS This section describes the operating controls of the vehicle. Figure 3.3.1 identifies the locations of many of these controls. 3.3.1 KEYSWITCH – Figure 3.3.1 Arrow A The keyswitch energizes the vehicle. Rotate the key to the right from vertical to turn the vehicle on, return to vertical to turn

• Columbia CR-10 Chariot, 2.0 SAFETY 2.1 GETTING STARTED For personal safety, before operating the vehicle, it is the operator’s responsibility to read, understand and follow the basic rules of operation and maintenance instructions in this manual. If you are responsible for the use of the vehicle, it is your responsibility to inform the person or persons using the vehicle about the following basic rules of operation for their personal safety. It is Columbia ParCar Corporation’s specific recommendation that the following warnings must be observed at all times. Not all are repeated throughout this manua

• Columbia CR-10 Chariot, 4.5.3 LOW BATTERY RESET SWITCH: This is used if the batteries are heavily over discharged. When the AC cord is connected, the RED light will turn on but will shortly turn off. To reactivate the charger, push the reset button for 10 seconds. This will restart the charger. Release the button and the charger will continue to charge. 4.5.4 TROUBLE SHOOTING CHART Symptom Repair or Replace AC Fuse AC Input Cord Loose wires on auto-start control Primary of transformer No transformer hum Auto-start control DC fuse DC connector shorted or open diode Transformer hums, but no ammeter deflection Defective ammeter Shorted AC cord AC fuse keeps blowing Shorted primary

• Columbia CR-10 Chariot, 3.4 VEHICLE OPERATING INSTRUCTIONS 3.4.1 DRIVING THE VEHICLE  Do not operate vehicle unless you are a qualified and trained operator.  Keep the vehicle under control at all times.  Drive only on level surfaces or on surfaces having an incline of no more than 10%.  Drive slowly when making a turn, especially if the ground is wet, slippery or when driving on an incline.  Do not drive this vehicle in hazardous areas unless this vehicle is approved and labeled for such operation.  Do not drive over loose objects, holes or bumps.  Observe all traffic regulations and speed limi

• Columbia CR-10 Chariot, 2.5 LIFTING INSTRUCTIONS Use extreme caution lifting or working on or around lifted vehicle. Vehicle should be on a flat, hard and level surface. When lifting the vehicle for service, remove key and use a sturdy lifting device such as a hoist or floor jack placed under the Chariot body. Always block wheels to prevent it from rolling. After the body is lifted 4 to 6 inches from the floor, place a suitable device under vehicle frame to support vehicle weight. An example is a 4” x 6” wooden block. If vehicle is raised while loaded, check that the load is secured befor

• Columbia CR-10 Chariot, NOTICE: In an effort to streamline product support, please ensure your vehicle is properly registered with Columbia ParCar. Registration allows for more effective product support including product updates and warranty processing. Please consult with your servicing dealer to verify or complete the registration process. CHANGE HISTORY DATE DESCRIPTION BY 5/9/2011 Issued – separated from Parts & Service TB iii

• Columbia CR-10 Chariot, Figure 3.3.2 When accelerating quickly, the needle will move to the left green region near the very far left red region. This is normal. If the needle continues past the green region into the very far left red region, it indicates that the batteries need recharging as soon as possible to avoid a shut-down of the vehicle. 3.3.3 HORN BUTTON – FIGURE 3.3.1 Arrow C The horn button is located on the left inside body panel and may be sounded by applying lateral pressure with the operator's left leg. 3.3.4 CHARGER RECEPTACLE – Figure 3.3.1 Arrow D The charger receptacle is for bat

• Columbia CR-10 Chariot, 5.4 MAINTENANCE SCHEDULE - QUALIFIED TECHNICIAN It is recommended that the following be performed by a trained qualified technician or your Columbia Dealer Item Operation Weekly Monthly Quarterly Semi- Annual Annual Drive Check treadle adjustment, motor mounting hardware, and drive chain adjustment * Test batteries * Electrical Inspect motor condition and operation. * Inspect brakes – clean, adjust, replace as needed. * Brakes Adjust brakes * Lubricate *

• Columbia CR-10 Chariot, 5.2 CLEANING Wash underside to remove all dirt and debris. Do not direct high pressure water at the speed switch or tops of the batteries. Wash body and seat with a mild detergent. Do not use abrasives (bodies are painted). Frequent washings with mild soap will preserve the finish of your vehicle. For stubborn and imbedded dirt, a soft bristle brush may be used. Tar, asphalt, creosote and the like should be removed immediately to prevent staining of paint. NOTICE: Do not use harsh detergents, abrasi

• Columbia CR-10 Chariot, 4.8 VEHICLE TROUBLESHOOTING PROBLEM CHECK Keyswitch on. Keyswitch is in desired direction. Keyswitch for loose wires or faulty switch. Batteries for loose terminals, corrosion, electrolyte level or state of charge. Will not move Motor for loose wires, open circuits. Batteries for loose terminals, corrosion, electrolyte level or state of charge. Brakes dragging Under inflated or flat tires. Runs slow Wheels for binding, do not spin freely. If these test procedures do not resolve your vehicle problem, contact your Columbia Dealer for service. 4-6

• 4.3 BATTERY CLEANING Acid-soaked dirt on the battery terminal connections causes current leakage, reduces battery efficiency, and battery life. Check that all vent caps are tightly in place before washing. Hose wash battery terminal connections periodically with clean low-pressure water to keep them free of acid spillage, dirt, and other debris. Do

More Instructions:

Columbia CR-10 Chariot Service manual 05-11-2023 23

DOWNLOAD

Related Products and Documents (Scooter):

Comparable Devices:

Similar Resources:

• Jetson Triton (24 pages) Triton Three Wheel Kick Scooter.A guide for your ride.IMPORTANT, RETAIN FOR FUTURE REFERENCE: READ CAREFULLYMODEL: JTRITNBLKDesigned in Brooklyn | Made in China …

• Flyer Upstreet6 (271 pages) DEFRITENNLFLYER Upstreet6TDCMEN 15194de Originalbetriebsanleitung FLYER Upstreet6fr Notice originale FLYER Upstreet6it Istruzioni originali FLYER Upstreet6en Original instruction manual FLYER Upstreet6nl Originele gebruiksaanwijzing FLYER Upstreet6 …

• Maplin N63LZ (15 pages) • Suitable for 5 years+• Maximum user weight: 25kg• Adult assembly requiredPlease keep this manual for future reference as it contains important information.Before first time use, charge the battery for at least 4-6 hours.OWNER'S MANUALRead and understand this entire manual before using!CHILDREN'SELECTRONIC TOY CAR …

• Razor Rift (28 pages) RIFT™4-261-2www.razor.comEN Read and understand this guide before using product.FR Lire et assimiler ce manuel avant d’utiliser le produit.ES Es imprescindible leer y comprender esta guía antes de usar el producto. DE Lesen Sie diesen Leitfaden vor Benutzung des Produktes aufmerksam.IT Leggere e comprendere tutti i punti del presente manuale prima di ut …

• X-TREME X-500 (14 pages) Page1 X-500 Electric Scooter Owner’s Manual Revised 10/10/09 PLEASE BE SAFE WHEN RIDING ALWAYS WEAR A HELMET AND OBEY ALL LAWS! X-Treme TM Electric Scooters …

• Sym Joyride 200 EFi (29 pages) THE ARTICLES MENTIONED BELOW ARE APPLICABLE ONLY FOR THE UNITED STATES AND CANADA. 1. NOISE EMISSION WARRANTY SANYANG INDUSTRY CO.,LTD. warrants that this exhaust system, at the time of sale, meets all applicable U.S. EPA Federal noise standards. This warranty extends to the first person who buys this exhaust system for purposes other than resale, and to …

Comments, Questions and Opinions: