Manualios.com

Samsung C100R Service Manual

Samsung C100R Manual Online:

3.05, 1673 votes
Samsung C100R User Manual
Samsung C100R User Guide
Samsung C100R Online Manual

Text of Samsung C100R User Guide:

  • Samsung C100R, SERVICE MICROWAVE OVEN CONTENTS MICROWAVE OVEN 1. Precaution 2. Specifications 3. Operating Instructions 4. Disassembly and Reassembly 5. Alignment and Adjustments 6. Troubleshooting 7. Exploded Views and Parts List 8. PCB Diagrams 9. Schematic Diagrams Manual C100R

  • Samsung C100R, PRECAUTIONS TO BE OBSERVED BEFORE AND DURING SERVICING TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY (a) Do not operate or allow the oven to be operated with the door open. (b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other microwave source, and make repairs as necessary: (1) Interlock operation, (2)properdoorclosing, (3) seal and sealing surfaces (arcing, wear, and other damage), (4) damage to or loosening of hinges and latches, (5) evidence of dropping or abuse. (c) Before tur

  • Samsung C100R,  1. Precaution Follow these special safety precautions. Although the microwave oven is completely safe during ordinary use, repair work can be extremely hazardous due to possible exposure to microwave radiation, as well as potentially lethal high voltages and currents. 1-1 Safety precautions ( ) 1. All repairs should be done in accordance with the procedures described in this manual. This product complies with Federal Performance Standard 21 CFR Subchapter J(DHHS). 2. Microwave emission check should be performed to prior to servicing if the oven is operative. 3. If the oven operates with the door open : Instruct the user not to operate the oven a

  • Samsung C100R,  1-2 Special Servicing Precautions (Continued) 17. When checking the continuity of the witches or transformer, always make sure that the power is OFF, and one of the lead wires is disconnected. 18. Components that are critical for safety are indicated in the circuit diagram by shading, or . 19. Use replacement components that have the same ratings, especially for flame resistance and dielectric strength specifications. A replacement part that does not have the same safety characteristics as the original might

  • Samsung C100R,  2. Specifications 2-1 Table of Specifications TIMER POWER SOURCE POWER CONSUMPTION OUTPUT POWER OPERATING FREQUENCY MAGNETRON COOLING METHOD OUTSIDE DIMENSIONS SHIPPING WEIGHT 99 MINUTES 230V 50Hz, AC MICROWAVE : 1,400W GRILL : 1,300W CONVECTION : 1,700W FROM 100 TO 900W(6 LEVEL POWER) (IEC-705 TEST PROCEDURE) 2,450MHz OM75PH(31) COOLING FAN MOTOR 517(W) x 310(H) x 511(D)mm 22.5 kg 24.5 kg

  •  517mm 369mm 3 1 0 m m 216mm 511mm 3. Operating Instructions 3-1 Control Panel 3-2 Features & External Views Door Ventilation Holes Light Safety Interlock Holes Control Pane Guide Roller Coupler Grill Rack Glass Plate Door Latches

  •  4. Disassembly and Reassembly 4-1 Replacement of Magnetron, Motor Assembly and Lamp Remove the magnetron including the shield case, permanent magnet, choke coils and capacitors (all of which are contained in one assembly). 1. Disconnect all lead wires from the magnetron and lamp. 2. Remove the bracket mounting. 3. Remove the magnetron supporter. 4. Remove t

  • Samsung C100R,  4-3 Replacement of Door Assembly 4-3-1 Removal of Door Assembly securing the upper hinge and lower hinge. The remove door assembly. 4-3-2 Removal of Door "C" Insert flat screwdriver into the gap between Door "A" and Door "C" to remove Door "C". Be careful when handling Door "C" because it is fragile. 4-3-3 Removal of Door "E" Following the procedure as shown in the figure, insert and bend a thin metal plate between Door "E" and Door "A" until you hear the ’tick’ sound. 1. Insertion depth

  • Samsung C100R,  4-3-6 Reassembly Test 1. When mounting the door to the oven, be sure to adjust the door parallel to the bottom line of the oven face plate by moving the upper hinge and lower hinge in the direction necessary for proper alignment. 2. Adjust so that the door has no play between the inner door surface and oven front surface. If the door assembly is not mounted properly, microwave energy may leak from the space between the door and oven. 3. Do microwave leakage test. 4-4 Replacement of Fuse 1. Disconnect the oven from the power

  • Samsung C100R,  4-6 Replacement of Control Circuit Board 1. Be sure to disclyarge any static electricity from your body, and avoid touching the "touch control" circuitry. 2. Disconnect the connectors from the control circuit board. 3. Remove screws securing the control box assembly. 4. Lift up the control circuit board from right side and remove the hooks holding the control circuit board to the box assembly. SCREWS

  • Samsung C100R,  5. Alignment and Adjustments 5-1 High Voltage Transformer 1. Remove connectors from the transformer terminals and check continuity. 2. Normal resistance readings are as follows: (Room temperature = 20°C) 5-2 Low Voltage Transformer 1.Thelowvoltagetransformerislocatedonthe Assy base plate. 2. Remove the low voltage transformer from the Assy base plate and check continuity. 3. Normal resistor reading is shown in the table. 5-3 Magnetron 1. Continuity checks can indicate only an open filament or a shorted magnetron. To diagnose an open filament or shorted magnetron

  • Samsung C100R,  5-4 High Voltage Capacitor 1. Check continuity of the capacitor with the meter set at the highest resistance scale. 2. Once the capacitor is charged, a normal capacitor shows continuity for a short time, and then indicates 9M  . 3. A shorted capacitor will show continuous continuity. 4. An open capacitor will show constant 9M  . 5. Resistance between each terminal and chassis should read infinite. 5-5 High Voltage Diode 1. Isolate the diode from the circuit by disconnecting its leads. 2. With the ohm-meter set at the highest resistance scale, measure across the diode terminals. Reverse the meter leads and

  • Samsung C100R,  5-8 Output Power of Magnetron The output power of the magnetron can be measured by performing a water temperature rise test. Equipment needed : * Two 1-liter cylindrical borosilicate glass vessel (Outside diameter 190 mm) * One glass thermometer with mercury column NOTE: Check line voltage under load. Low voltage will lower the magnetron output. Make all temperature and time tests with accurate equipment. 1. Fill the one liter glass vessel with water. 2. Stir water in glass vessel with thermometer, and record glass vessel’s temperature ("T1", 10±1°C). 3. After moving the water into another glass vessel, place it i

  • Samsung C100R,  5-9 Procedure for Measurement of Microwave Energy Leakage 1) Pour 275±15cc of 20±5°C(68±9°F) water in a beaker which is graduated to 600cc, and place the beaker in the center of the oven. 2) Start to operate the oven and measure the leakage by using a microwave energy survey meter. 3) Set survey meter with dual ranges to 2,450MHz. 4) When measuring the leakage, always use the 2 inch spacer cone with the probe. Hold the probe perpendicular to the cabinet door. Place the spacer cone of the probe on the door and/or cabinet door seam and move along the seam, the door viewing window and the exhaust openings moving the prob

  •  6. Troubleshooting 6-1 Electrical Malfunction PRECAUTION 1. CHECK GROUNDING BEFORE CHECKING FOR TROUBLE. 2. BE CAREFUL OF THE HIGH VOLTAGE CIRCUIT. 3. DISCHARGE THE HIGH VOLTAGE CAPACITOR. 4. WHEN CHECKING THE CONTINUITY OF THE SWITCHES OR TRANSFORMER, DISCONNECT ONE LEAD WIRE FROM THESE PARTS AND THEN CHECK CONTINUITY WITHOUT THE POWER SOURCE ON. TO DO OT

  • Samsung C100R,  6-1 Electrical Maltunction(continved) SYMPTOM CAUSE CORRECTIONS Oven lamp and fan motor turn on 1. Misadjustment or loose wiring of primary latch switch 2. Defective primary latch switch Adjust door and latch switches. Oven can program but timer does not start. 1. Open or loose wiring of secondary interlock switch 2. Off-alignment of primary interlock 3. Defective secondary interlock S/W Adjust door and interlock switches. Microwave output is low;. Oven takes longer time to cook food. 1. Decrease in power source voltage. 2. Open or loose wiring of magnetron filament circ

  • Samsung C100R,  7. Exploded Views and Parts List 7-1 Exploded Views MM01 MM52 MM67 MM42 MM21 MM08 MM09 MM62 MM31 MM32 MM125 MM106 MM105 MM103 MM104 MM93 MM27 MM30 MM29 MM14 MM22 MD01 MM18 MM19 MM20 MM641 MM642 MM16 MM35 MM65 MM87 MM58 MM28 MM17 MM63 MM61 MM68 MM60 MM69 MM72 MM66 MM73 MM07 MM03 MM05 MM55 MM551 MM06 MM10 MM71 MM17 MM88 MM56 MC01 MM59 MM57 MB01 MB05 MB03 MB02 MB04 MM50

  •  7-2 Main Parts List - S.N.A : SERVICE NOT AVAILABLE No. Code No. Description;Specification Q’ty Remark MB01 DE93-20020D ASSY BODY LATCH;M959/XSA,-,-,-,- 1 MB02 3405-000175 SWITCH-MICRO;250V,15A,200gf,SPST-NO 1 MB03 3405-000178 SWITCH-MICRO;250V,15A,200gf,SPST-NO 2 MB04 DE66-90054B LEVER-SWITCH;NYLON#66(2021SW),40G,M959/X 1 MB05 DE66-40021B L

  • Samsung C100R,  7-3DoorPartsList No. Code No. Description;Specification Q’ty Remark MD01 DE94-00644A ASSY DOOR;C100,P/WHT,1.0 CONV CK95(DESIG 1 MD02 DE64-40319A DOOR-A;PC,-,WHT,-,CK95,-,- 1 MD04 DE94-00075H ASSY DOOR-E(SEALANT);C100,SEALANT,3RD-1. 1 MD06 DE64-40012C DOOR-C;PBT,-,BLK,-,CK95,-,- 1 MD07 DE61-70148A SPRING-KEY;HSWR3,PI6.0,D0.8,L34.4,BLUING 1 MD08 DE61-80002A HINGE-UPPER;SCP1,T2.3,26,77,ZPC3,WHT,CE9 1 MD09 DE61-80003A HINGE-LOWER;SCP1,T2.3,26,77,ZPC3,WHT,CE9 1 MD10 DE64-00547A KEY-DOOR;C100,NYLON#66,-,-,-

  • Samsung C100R,  7-4 Control Parts List No. Code No. Description;Specification Q’ty Remark MC01 - ASSY CONTROL-BOX;-,C100-R/BWT,-,RUSSIA 1 S.N.A MC03 DE64-00369B CONTROL-PANEL;C100-R/BWT,PC,-,-,-,-,-,RUSSIA 1 MC06 DE67-40173B WINDOW-DISPLAY;RE-MF70,SAN-20%(CR5381G01 1 MC07 RC-C100-00 ASSY PCB PARTS;C100/XEF,230V50HZ 1 MC09 DE64-00370A KNOB;CK95(VI),PC,-,-,-,-,-,-,1 BOARD PCB 1 MC13 DE94-00647B ASSY CONTROL-PANEL;C100-R/BWT,-,RUSSIA 1 MC141 DE64-00373A BUTTON-SELECT(A);CK95(VI),PC,-,-,-,1 BOA 1 MC142 DE64-00375A BUTTON-SELECT(B);CK95(VI),PC,-,-,-,1 BOA 1 MC27 DE64-00374B BUTTON-CANCEL;C100-R/BWT,PC,-,-,-,RUSSIA

  • Samsung C100R,  7-5 Casing Parts List No. Code No. Description;Specification Q’ty Remark MA01 DE31-10171A MOTOR-CONVECTION;SMC-105EA,230V/50HZ,280 1 MA02 DE31-90019A BLADE-FAN;SECC,T0.6,-,-,-,-,- 1 MA02 DE31-90020A BLADE-FAN;ALSTAR,T0.6,W250,L250,-,-,- 1 MA03 DE47-70077A HEATER-CONVECTION;SHC-118E1,-,-,1680W,-, 1 MA04 DE60-40026B WASHER-PLAIN;ID5.5,OD12,T1.0,SBC1,ZNC3,- 1 MA05 DE62-90098B ADIABATIC-CASING;-,T8,W245,L336.8,CK95,- 1 MA06 DE72-30016A BUSH-MOTOR;-,MSWR3,L11.2,D5.6,RE-1300,-, 1 MA07 DE92-90487A ASSY-COVER CASING;CE115K,230V

  • Samsung C100R,  7-6 Standard Parts List Code No. Description Specification Q’ty Remark DE60-10012A SCREW-TAP TITE -,SWR10,M4,L10,TH,+,-,3,ZPC2,- 1 A-N-FILTER DE60-10012A SCREW-TAP TITE -,SWR10,M4,L10,TH,+,-,3,ZPC2,- 1 A-P-CORD DE60-10012A SCREW-TAP TITE -,SWR10,M4,L10,TH,+,-,3,ZPC2,- 3 B-PLATE DE60-10012A SCREW-TAP TITE -,SWR10,M4,L10,TH,+,-,3,ZPC2,- 1 C-B-EARTH DE60-10018A SCREW-ASSY MACHINE -,WS,MSWR10,SN1,PH,M4X0.7P,-,8,-,- 2 B-EARTH DE60-10034A SCREW-TH -,-,L10,STS304,TH,+,-,M4,-,- 1 SENSOR DE60-10045A SCREW-TAP PH -,-,FEFZY,-,PH,M3,-,L6,-,- 2 - DE60-10052A SCREW-TAP PH -,-,FEFZY,-,PH,M4,-,L8,-,- 2 A-

  •  8-2 P.C.B Parts List Code No. Description Specification Q’ty Remark 3501-001062 RELAY-POWER 24VDC,523.2mW,16A,1FormA,15mS, 1 RY02 3501-001068 RELAY-POWER 24Vdc,523mW,16A,1FormA,15mS,10 2 RY04,05 3501-001155 RELAY-MINIATURE 24VDC,200MW,3000MA,1FORMA,10MS,10MS 4 RY01,03,06,07 3601-001126 FUSE-CARTRIDGE 250V,1.6A,FAST-ACTING,CERAMIC,5x20mm 1 FUSE DE07-00031A LED DISPLAY CSQ-4258E

  • Samsung C100R,  9. Schematic Diagrams 9-1 Schematic Diagrams MAGNETRON FA F RED RED RED RED SYMBOL COLOR BRN BROWN BLK BLACK RED RED BLU BLUE WHT BLK HIGH VOLTAGE TRANSFORMER HIGH VOLTAGE CAPACITOR HIGH VOLTAGE DIODE TO CHASSIS H.V.FUSE

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 Metabo PowerMaxx BS Original instructions manual metabo/powermaxx-bs-UX4.pdf 26 Apr 2023 8
2 ThermoWorks TW-USB-1 Quick start manual thermoworks/tw-usb-1-V3I.pdf 21 Nov 2022 2
3 Milwaukee 1 Inch SDS PLUS Operator's manual milwaukee/1-inch-sds-plus-N34.pdf 04 Jan 2023 16
4 Haier AB182ACERA Service manual haier/ab182acera-V8H.pdf 19 Jun 2022 64 4.07 Mb
5 Panasonic KX-FT931LA-B Service manual panasonic/kx-ft931la-b-825.pdf 18 Aug 2023 173
6 Quatech DS-1000 Owner's manual quatech/ds-1000-B88.pdf 13 Feb 2023 27 0.07 Mb

Similar Resources:

  • Whirlpool

    MWF 863

    (22 pages)
    MODEL: MWF 863 Owner's Manual 用戶使用手冊 Please read these instructions carefully before installing and operating the oven. Record in the space below the SERIAL NO. found on the nameplate on your oven and retain this information for future reference. SERIAL NO. …
  • Samsung

    GW71E

    (80 pages)
    Кодов №: DE68-03485QМИКРОВЪЛНОВА ФУРНАИнструкции за собственика и готварски указателGW71EФурна......................................................................................... 2Принадлежности ...................................................................... 2К …
  • Sharp

    R-8ST

    (180 pages)
    R-82STMIKROWELLENGERÄT MIT GRILL UND HEISSLUFT - BEDIENUNGSANLEITUNGHORNO DE MICROONDAS CON GRILL Y COVECCIÓN - MANUAL DE INSTRUCCIONESFORNO MICROONDAS COM GRILL E CONVECÇÃO - MANUAL DE OPERAÇÕESFOUR A MICRO-ONDES AVEC GRIL ET CONVECTION - MODE D’EMPLOIFORNO A MICROONDE CON GRILL E FUNZIONE ARIA VENTILATA  MANUALE D’ISTRUZIONICOMBIMAGNETRON …
  • Samsung

    GE76V-BBH/XEU

    (28 pages)
    GE76Vimagine the possibilitiesThank you for purchasing this Samsung product. Please register your product atwww.samsung.com/registerMicrowave OvenOwner’s Instructions & Cooking Guide750WThis manual is made with 100 % recycled paper.GE76V-BBH_XEU_DE68-03928F_EN.indd 1 10/15/2012 1:45:22 PM …
  • Panasonic

    NN-SB646S

    (24 pages)
    Owner’s ManualMicrowave OvenHousehold Use OnlyModel No. READ ALL INSTRUCTIONS CAREFULLY BEFORE USING THE OVEN.Scan this code for special instructions and features. (U.S.A only) For microwave oven safety reference, please visit the FDA’s web page at: Para obtener instrucciones en español, por favor visite la página web en: Printed in ChinaNNSN744S_ …
  • Frigidaire

    MWV150K

    (24 pages)
    Microwave OvenOver-the-RangeREAD AND SAVE THESE INSTRUCTIONSWelcome..........................................2Important Safety Instructions .....3-6Features and Specifications ..........7Before Operating ............................8Manual Operation ..................... 9-14Convenience Operation ......... 15-16Cooking Charts ...................... 17-18Care …

Comments, Questions and Opinions: