Hunter Type 5 Series Installation And Operating Instructions Manual

Text of Hunter Type 5 Series User Guide:

• Hunter Type 5 Series, H E R A L D H E R A L DH E R A L D H E R A L D I N S E I N S EI N S E I N S E T 5 T 5T 5 T 5 M U L T I F U E L M U L T I F U E LM U L T I F U E L M U L T I F U E L S T O V E S T O V ES T O V E S T O V E Installation and Operating Instructions An accredited competent person must carry out the installation of this appliance; alternatively, your local Building Control Officer can approve the completed installation, should a non-accredited engineer undertake the installation. It is an offence,

• Hunter Type 5 Series, PLEASE READ THESE INSTRUCTIONS CAREFULLY Please check the suitability of any fireplace/surround for closed solid fuel appliances before installing this appliance. Hunter Stoves Ltd cannot be held responsible for any fault arising through incorrect use or installation. Fire surround back panels suitable for solid fuel are usually in three sections and slabbed. Many fire surrounds are suitable only for use with gas and electric fires and therefore not suitable for solid fuel. Important Warning This stove must not be installed into a chimney that serves any other heating appliance. There must not be an extractor fan fitted in the same room as the stove as this

• Hunter Type 5 Series, Assembly Instructions Fire Bricks The Fire Bricks, in this appliance, are factory fitted. The following set of diagrams show the removal sequence that you will need to employ when servicing your Hunter stove. Side Bricks Rear Brick Recouping Baffle To assemble these Fire Bricks, simply reverse the above procedure. Remove all central single - width Grate Bars, and outer Triple-width grate bars below the brick. Take hold of the front of the Side Brick and remove it from the Stove. Pull the top edge of the Rear Brick towards you, lift and remove. Lift the Ba

• Installation Instructions These instructions cover the basic principles to ensure satisfactory installation of the stove, although detail may need slight modification to suit particular local site conditions. In all cases the installation must comply with current Building Regulations, Local Authority Byelaws, European and national standards an

• Hunter Type 5 Series, Unpacking the stove contents The following items should be included in the stove’s box; • Herald inset 5 Multi-Fuel Stove • Ashpan • Riddling Tool (In-Ashpan) • Fixing Kit (inc. 3 Hilti Bolts) • Instructions Unpack the Herald inset 5 multi-fuel stove carefully (leave the plastic cover on if any building work is currently being carried out) and ensure that the black finish is protected from any damage, water, dust or fire cement. Chimney Please check the suitability of any fireplace/surround for closed solid fuel appliances before installing this appliance. Hunter Stov

• Hunter Type 5 Series, It is essential that all connections between the stove and chimney-flue are sealed and made airtight. Both the chimney and any flue pipe must be accessible for cleaning and if ANY parts of the chimney cannot be reached through the stove (with baffle removed), a soot door must be fitted in a suitable position to enable this to be done. Air Supply If a draught stabiliser is fitted, there should be an air opening and this should be at least 1500 mm 2 . Due consideration should be given to air requirements for any other appliances in the same room or space. Any air opening must be kept clear from blockage or obstruc

• Hunter Type 5 Series, Installing the stove Take the stove off the pallet. There are three fixing points (see fig. 1) on the stove’s body, which can only be seen before the stove is inset into the fireplace. To access these fixing points from inside the stove (see fig. 2) remove the following parts from the stove; • Grate bars • Side bricks • Cam bar • Catch bar • Ashpan and riddling tool • Rear Brick and casting Fig. 1 Fig. 2 Carefully move the stove into position inside the fireplace opening, being careful not to damage the hearth or paintwork on th

• Hunter Type 5 Series, Press a sufficient amount of fire cement around the base under the stove and the bottom of the fireplace opening, ensuring that all joints and connections are well sealed. Then seal up where the throat area meets the flue outlet of the stove. This will prevent fumes coming out of the stove and going back down behind it. Commissioning and Handover Upon completion of the installation, allow a suitable period of time for any fire cement and mortar to dry out. A small fire may

• Hunter Type 5 Series, Operating Instructions This appliance is not suitable for use in a shared flue This appliance should not be operated with the doors open Aerosol Sprays Do not use an aerosol spray on or near the stove when it is alight. Air Controls This stove has been designed to burn cleaner and more efficiently than a conventional wood burning stove. If used correctly this stove will burn far more efficiently than normal with the, obvious, notable feature of CLEAN GLASS. However, for this product to work properly it must be used correctly. It is essential that the stove has

• Multifuel Grate Your Hunter Stove is fitted with a locomotive type grate. So that de- ashing can be carried out cleanly and easily, it is riddled from the outside of the stove with the doors closed. The grate is designed to burn both wood and solid fuels. To burn solid mineral fuels place the operating tool over the riddling spigot and pull it

• Hunter Type 5 Series, Loading the Stove (Solid Mineral Fuel) Solid mineral fuel should be placed in the stove so that there is no more than a 30° incline of the fuel bed from front to back. It should not be stacked above the level of the rear firebrick as this may result in damage to the stove. With a full load of fuel, the stove will need to be refuelled approximately once every 4 hours. Air Controls (Solid Mineral Fuel) Solid mineral fuel burns most efficiently with the secondary air control in the closed positi

• Air Controls (Wood) Wood burns most efficiently with the primary control in the closed position and the secondary control approximately 50% open. Moving the secondary control will control the burn rate of the stove. The secondary air lever should not be completely closed unless the primary air lever is also in the closed position. Wood burns best on

• Hunter Type 5 Series, Important! – Do not fit an extractor fan in the same room as this appliance. IN THE EVENT OF A CHIMNEY FIRE • Raise the alarm to let others in the house know. • Call the Fire Brigade. • Reduce the appliance-burning rate by closing all air controls. • Move furniture and rugs away from the fireplace and remove any nearby ornaments. • Place a fireguard or spark guard in front of the stove. • Feel the chimney breast for signs of excessive heat. If the wall is becoming hot, move the furniture away. Ensure that the Fire Briga

• Hunter Type 5 Series, GENERAL MAINTENANCE NO unauthorised modification of this appliance should be carried out. This appliance requires regular maintenance by a competent engineer. Baffle This should be removed and cleaned at least once a month to prevent any build up of soot or fly ash that could lead to blocked flue ways and dangerous fume emission. If the baffle is removed the chimney/flue way can be swept through the appliance. Stove Body The stove is finished with a heat resistant paint and this can be cleaned with a soft brush. Do not clean whilst the stove is hot; wait until it has cooled down.

• Hunter Type 5 Series, Chimney and Flue ways It is important that the chimney, flue ways and any connecting flue pipe are swept regularly. This means at least once a year for smokeless fuels and at least twice a year for wood and other fuels. The baffle will need to be removed from its supports in order to sweep the chimney (see assembly instructions). Only wire-centred sweeps’ brushes fitted with a guide wheel should be used. If it is not possible to sweep all parts of the chimney through the

• Hunter Type 5 Series, STOVE SPARES Only Hunter Stoves authorised spares should be used with this stove. RIGHT HAND DOOR LEFT HAND DOOR Glass Clip (HHR08/046) Glass Clip Screw (FSJM05008SS) Left Hand Door (HHR06/080) Glass Clip (HHR08/046) Glass Clip Screw (FSJM05008SS) Door Glass (HH06/083) Glass Gasket (HH06/084) Door Slider (HHR06/098) Slider Knob (HHR08/045) Door Slider (HHR06/098) Slider Knob (HHR08/045) Door Glass (HH06/083) Glass Gasket (HH06/084) Door Knob (HCR06/059) M8 Full Nut (FNFM08) Catch Shaft (HHR08/111) Circlip (FLRX07) M8 Full Nut (FNFN

• Hunter Type 5 Series, STOVE BODY ASSEMBLY - PART SECTION - MULTIFUEL Side Brick (HHN05/019) Cam Bar (HHN05/007) Riddling Bar – Lower (HCR06/020) Riddling Bar – Upper (HCR06/019) Recouping Baffle (HHN05/024) Rear Brick – M/F (HHN05/018) Riddling Support (HHN05/015) Catch Bar – Drop in (HH06/085) Ashpan (HHN05/017) Triple Grate Bar (Side Plate) Left (HHN05/016A) Triple Grate Bar (Side Plate) Right (HHN05/016B)

More Instructions:

	Hunter Type 5 Series Owner's manual 23-12-2023 16	DOWNLOAD
	Hunter Type 5 Series Owner's manual and installation manual 19-02-2023 16	DOWNLOAD
	Hunter Type 5 Series Installation and operation manual 07-11-2022 12	DOWNLOAD
	Hunter Type 5 Series Owner's manual and installation manual 12-10-2022 15	DOWNLOAD

Related Products and Documents (Cooktop):

Comparable Devices:

Similar Resources:

• Jenn-Air 36" (40 pages) JENN-AIR_ 86 (91,4 CM) WALL-MOUNTCANOPY RANGE HOODHOWE DE CUISINIERE JENN-AIR ® POUR_ 1MONTAGE MURAL 36 (9 ,40M)For questions about features, operation/performance, parts, accessories, or service in the U.S.A., call:1-800-JENNAIR (1-800-536-6247} or visit our website at www.jennair.com.In Canada, call: 1-800-JENNAIR (1-800-536-6247}, or visit our website at …

• SEVERIN KP 1071 (84 pages) www.severin.comDE GebrauchsanweisungGB Instructions for useFR Mode d’emploiNL GebruiksaanwijzingES Instrucciones de usoIT Manuale d’usoDK BrugsanvisningSE BruksanvisningFI KäyttöohjePL Instrukcja obsugiGR O RU   Kochplatte 4Electric …

• Drolet DB03060 (19 pages) INSTRUCTIONS & OPERATIONS MANUAL DROLET COMPAK EPA EXEMPT US ENVIRONMENTAL PROTECTION AGENCY 28A CERTIFIED WOODSTOVES Verified and tested following UL 1482 Standards by: Manufactured by : STOVE BUILDER INTERNATIONAL INC. 1700, Leon-Harmel, Quebec (Quebec) G1N 4R9 Tel : ( 418 ) 527-3060 Fax : ( 418 ) 527-4311 www.drolet.ca READ AND KEEP THI …

• Frigidaire FGGC3045K (3 pages) frigidaire.comDrop-In CooktopsFGGC3045K S / W/ B30" GasMore Easy-To-Use FeaturesSealed Burner ( 12,000 BTU )Sealed Burner ( 9,500 BTU )Stainless Steel Recessed CooktopBlack / White Porcelain CooktopOverall Exterior DimensionsHeight 5"Width 30"Depth 21-3/4"Available in:Signature FeaturesStainless (S)White (W)Black (B) …

• Whirlpool YIES366RS0 (40 pages) ELECTRIC RANGEUse & Care GuideFor questions about features, operation/performance,parts, accessories or service, call: 1-800-253-1301.In Canada, call for assistance 1-800-461-5681, for installationand service, call: 1-800-807-6777or visit our website at www.ikea.comCUISINIÈRE ÉLECTRIQUEGuide d’utilisation et d’entretienAu Canada, pour assistance, c …

• Thermador PRD484EEHU (64 pages) INSTALLATION MANUALFor Thermador Professional ®PRO-HARMONY TM Dual Fuel RangesMANUEL D'INSTALLATIONPour toutes les cuisinieres mixtesThermador Professional ® PRO-HARMONY TMModels/Modeles /PRD30PRD36PRD48 …

Comments, Questions and Opinions: