LG LGXXXN1CW-A3 Installation Instructions Manual
|
Monocrystalline Solar Module LGXXXN1C(W, K)-A3 LGXXXN1C(W, K)-B3 A minimum slope of 5 in/ft. for installation over a roof, is required to maintain the fire class ratings. The array frame shall be grounded in accordance with NEC Article 250. Installation Instructions MFL68783801
LG LGXXXN1CW-A3, 2 Table of Contents Revisions Table 1. Safety 3 2. Before & After Installation 4 3. Electrical Installation 5 4. Mechanical Installation 6 5. Product Specifications 9 6. Disclaimer of Liability / Disposal 10 7. Transporting and Storage 10 8. Appendix 11 Date Version RemarkDescription of change 2013.08.13 2014.02.07 2014.09.24 2014.10.14 2014.10.20 2014.11.13 1.0 (1 st edition) 2.0 3.0 4.0 5.0 6.0 Add B3 Model(LGXXXN1X-B3) Add 305/310W Power output Model Add Appendix Contents Edit to description of Mechanical Installatio
3 Safety Do not scratch the coating surface of the frame. Scratches may decrease the total solar output due to corrosion of the frame. Do not artificially concentrate sunlight on the solar module surface. Failure to comply may result in product damage or failure. Do not apply a shock to the junction box of the module or pull the cable. Do not remove the labels attached to the
LG LGXXXN1CW-A3, 4 Electrical Installation Before & After Installation • Dirt build-up on the surface of the panel may cause active solar cells to be shaded and electrical performance to be impaired. • Always keep the back surface of the panel free from any foreign objects or structural elements which could come into contact with the panel. After Installation • Plug in the connector tightly and ensure that the wiring properly works. • Conduct periodic inspection of the panels for damage to front glass, back sheet, frame, junction box, or external electrical connections. • Check electrical connections for loose connections and corrosion. • Removal of d
LG LGXXXN1CW-A3, 5 -- Parallel connection for more current Electrical Installation Parallel Connection • The solar modules may be combined in parallel to produce the desired current output. • When modules are combined in parallel, the total current is equal to the sum of currents from each module. • The voltage of each module connected in parallel should be the same. • When connecting plural strings of modules in parallel every series string or solar module must be fused prior to combining with other strings. • Abide with all applicable federal, state, and local codes for additional fusing requirements and limitations on the maxi
LG LGXXXN1CW-A3, 6 Mechanical Installation Module Mounting • The LG Electronics’ (LGE) Limited Warranty for solar modules is contingent upon modules being mounted in accordance with the requirements described in this section. • Any module without a frame (laminate) shall not be considered to comply with the requirements of UL 1703 unless the module with hardware that has been tested and evaluated with the module under this standard or by a field inspection certifying that the installed module complies with the requirements of UL 1703. Site Consideration LGE solar modules should
LG LGXXXN1CW-A3, 7 Mechanical Installation Bolt Flat washer Flat washer Nut Support Mounting by using frame bolts holes • Secure the solar module to the structure by using the factory mounting holes. • Four M6 stainless steel bolts, four nuts, four spring washers, and eight flat washers are recommended per solar module. • The module may be fastened to a support by using both the outer and inner bolt holes of the frame. • Each module should be securely fastened at a minimum 4 points on two opposite sides. • Specific information on the solar module dimensions and location of mounting holes is provided in ‘Product Specifications’. •
LG LGXXXN1CW-A3, 8 Mechanical Installation LGXXXN1C(W, K)-A3 LGXXXN1C(W, K)-B3 Mounting Type Clamping Type (Long Side) Clamping Type (Short Side) 270mm 270mm Use four mounting holes on two opposite sides. Use four clamps on the long frame. Use four clamps on the short frame and two clamps at the center of long Frame. Clamping Range (230mm) Use four clamps on the Short frame. This method is not tested by IEC/UL. This installation is allowed in the following cases: 1. Slope roof: If module is installed parallel to the rooftop. 2. Flat roof: If installed with an additional stand such as wind shield or deflector. Clamping Range: From module Edge to
LG LGXXXN1CW-A3, 9 Product Specifications - Electrical and Mechanical Properties (Rated electrical characteristics are within 10 percent) Standard Test Condition(STC) : Irradiation 1,000W/m 2 , Cell temp. 25°C, 1.5AM - Dimensions of Modules Note : * Relative efficiency reduction by respect to irradiance ** MC4 formal name : PV-KST4 / 6II-UR, PV-KBT4 / 6II-UR *** A safety locking clip (MC PV-SSH4) may be required per article 690 of NEC 2008. Note :*Holder is for the convenient connection of junction box cable,but that do
LG LGXXXN1CW-A3, 10 Disclaimer of Liability / Disposal Disclaimer of Liability • By beginning the installation process the installer represents the he/she has read and completely understands this Installation Manual. He/She further represents if he/she had any questions regarding this installation manual he/she would have contacted LG with any questions or concerns. By installing an LG Solar module, I discharge, and cove nant not to sue LG, its affiliated companies, successors, or assigns, its administrators, directors, agents, officers, volunteer and employees, other participants in any activity conn
LG LGXXXN1CW-A3, 11 Appendix WILEY Compatibility • LG modules have been confirmed by Burndy LLC that the below model number designations have been evaluated with the Burndy WEEB line of products : For Verification of Compatibility LG modules have been Compatibility, tested by UL. The test samples of Rails and WEEBs are included in the following tables. ( Torque : 8~12Nm ) LG Model : LGxxxS1C(W,K)-A3, LGxxxS1C(W,K)-B3, LGxxxN1C(W,K)-A3, LGxxxN1C(W,K)-B3 Rails and WEEBs’ Test sample for UL test UGC-1* : Top Mounting UniRac, Inc. Grounding Clips No. Rail Washer
13 Appendix A portion of the grounding devices indicated on this page is not evaluated by UL. If such devices want to be used to meet the requirement in UL 1703, some adequate tests shall be conducted in accordance with UL1703 additionally. Important Notes 1. The NEC section 690.43 states, “Exposed non-current carrying metal parts of module frame, equipment and co
LG LGXXXN1CW-A3, LG Electronics U.S.A Inc. 1000 Sylvan Ave, Englewood Cliffs, NJ 07632 Contact : [email protected] http://www.lgsolarusa.com This document is subject to change without notice. LG, LG logo and Life's Good are trademarks of LG Electronics, Inc. worldwide. Trademarks and intellectual properties of LG Electronics, Inc. are protected by international copyright laws. Document : II-A3(N)-UL-V5-EN-201308
Sharp ND-235(R1J) Solar panel Installation manual
ND-235(R1J) |
sylber SILOS 300 M Solar panel Installation manual
SILOS 300 M |
LG LG280N1C-G4 Solar panel Installation manual
LG280N1C-G4 |
DX3 DX3-3001S Solar panel Installation manual
DX3-3001S |
LG LG270N1C(W)-G3 Solar panel Installation instructions manual
LG270N1C(W)-G3 |
Kyocera KD130GX-LP Solar panel Installation manual
KD130GX-LP |
LG MonoX ACe Solar panel Troubleshooting manual
MonoX ACe |
Siemens M65 Solar panel Operation & user’s manual
M65 |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Healthrider | R65 HRTL71830 | Operation & user’s manual | healthrider/r65-hrtl71830-5WN.pdf | 22 Dec 2022 | 34 | 1.5 Mb |
2 | Oasis | OASIS-30 | Operation & user’s manual | oasis/oasis-30-R1T.pdf | 19 Jul 2022 | 13 | |
3 | ITEAD | Iteaduino Plus | Manual | itead/iteaduino-plus-SU3.pdf | 10 Oct 2023 | 15 | |
4 | Freecom | Data Tank Gateway WLAN | Specifications | freecom/data-tank-gateway-wlan-U1I.pdf | 03 Sep 2023 | 3 | 0.53 Mb |
5 | Graco | SLIMFIT | Instruction manual | graco/slimfit-DHI.pdf | 28 May 2023 | 112 | |
6 | Global Technology Associates | GB-2000X | Specification sheet | global-technology-associates/gb-2000x-O19.pdf | 01 Jul 2023 | 2 | 0.23 Mb |
Viessmann
VIESMANNVITOSOLVITOSOL 200-F, 300-F Flat-plate collector, type SV and SHfor installation on flat and pitched roofs as well as for roof inte-gration and freestanding installation,type SH also for installation on wallsLarge area flat-plate collector, type 5DIfor roof integration on pitched roofs with tile coverVITOSOL 200-T Type SD2 and SD2ADirect flow v …
VITOSOL SERIES(140 pages) |
Nature Power
SAVE THESE INSTRUCTIONS Solar KitUser Manual WARNING: Read carefully and understand all ASSEMBLY AND OPERATIONINSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions may result in serious personal injury. V1.1-M 1Jun2018124 557015570255704
…
55701(10 pages) |
NOMA
75 W SOLAR PANELInstruction Manualmodel no. 011-2033-4Toll-free: 1-866-827-4985IMPORTANT: Please read this manual carefully before using this solar panel and save it for reference.
…
011-2033-4(16 pages) |
Jinko Solar
-1- 1. General Information 1.1 Overview Thanks for choosing Jinko Solar PV modules. In order to ensure the PV modules are installed correctly, please read the following installation instructions carefully before modules are installed and used. Please remember that these products generate electricity and certain safety measures need to be taken t …
JKM PP-60 Series(18 pages) |
SONARAY
SunBrite Solar Installation GuideTECHNICAL PARAMETERSATTENTIONINSTALLATION CONSIDERATION1. Do not install solar modules near power lines, trees, shaded areas, or any obstructive areas. 2. Regularly check for loose mounting connections to prevent any potential accidents. Re-tighten screws and bolts as needed.3. When installing the solar panel, the face of the …
SunBrite Solar(2 pages) |
Nature Power
SAVE THESE INSTRUCTIONS 8 Watt Semi Flex Solar Panel User ManualItem # 56808V1.1-M 19Jul2019WARNING: Read carefully and understand all assembly and operation instructions before operating. Failure to follow the safety rules and other basic safety precautions may result in serious personal injury.
…
56808(8 pages) |
Xantrex Network Router C12Owner's manual for Xantrex C12 Network Router C12, 8 |
Yamaha Scooter YW50APUser Manual: Yamaha YW50AP (D47X3E, Upd.01.12.2023) YW50AP, 214 |
BESV Bicycle PS1Bicycle #PJ84SR PS1, 17 |
Maxford USA Toy Mentor-G V2Toy Instruction manual (Maxford USA Mentor-G V2) Mentor-G V2, 10 |
PLUSOPTIX Label Maker P12Label Maker PDF Operation & user’s manual P12, 7 |
Laney Musical Instrument Amplifier LC15-110Laney LC15-110 Guide (Doc Type: Musical Instrument Amplifier Operating instructions manual) LC15-110, 20 |
Omron Software CX-SupervisorSoftware #95PG9M CX-Supervisor, 334 |
ETI Sound Systems, INC Subwoofer B-52 LX-18EV2#9PHQRT: B-52 LX-18EV2 Subwoofer Owner's instruction manual B-52 LX-18EV2, 4 |
Polycom Network Card Real-Time Media Conferencing Platform RMX 2000Network Card #QY1VIK Real-Time Media Conferencing Platform RMX 2000, 8 |
Aplex Touch Panel AEx-815PTouch Panel Operation & user’s manual (Aplex AEx-815P) AEx-815P, 77 |
Iiyama Monitor ProLite E2208HDSProLite E2208HDS Operation & user’s manual - H4Z24C ProLite E2208HDS, 28 |