Sanyo EM-X471S Service Manual Supplement
|
Sanyo EM-X471S, PRECAUTIONS PRECAUTIONS TO BE OBSERVED BEFORE AND DURING SERVICING TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY (a) Do not operate or allow the oven to be operated with the door open. (b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other microwave source, and make repairs as necessary: (1) Interlock operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and other damage), (4) damage to or loosening of hinges and latches, (5) evid
Sanyo EM-X471S, - 1 - (3) (a) Set cooking time to two (2) minutes. (“2 00” appears in display) (b) Touch “START” key and operate oven for exactly two (2) minutes. (4) (a) Take out the two bowls at once. (b) Stir both water with thermometer and measure the water temperature rise respectively. (5) (a) Get temperature rise by calculation the difference (water temperature after cooking minus initial temperature) in each bowl. (b) Then calculate average value(t) of both temperature rise in degrees centigrade. (c) Then work out : Power Output (watt) = 70 x ∆t Where ∆t is an Average Temperature Rise in degrees centig
- 2 - 3. CIRCUIT DIAGRAM Figure 1 WIRING COLOUR BK : BLACK BL : BLUE W : WHITE O : ORANGE Y : YELLOW R : RED NOTE : THE SIGN Parts marked with this sign are supplied with High Voltage exceeding 250V. THE SIGN Parts marked with this sign have special characteristics important for microwave leakage. When replacing any of these parts use only manufacturer’s specified parts.
CAUTION - DISCONNECT THE POWER SUPPLY CORD FROM THE WALL OUTLET WHENEVER REMOVING THE CABINET FROM THE UNIT. PROCEED WITH THE TESTS ONLY AFTER DISCHARGING THE HIGH VOLTAGE CAPACITOR AND REMOVING THE LEAD WIRES FROM THE PRIMARY WINDING OF THE HIGH VOLTAGE TRANSFORMER. (SEE FIGURE 2) A. TEST PROCEDURES COMPONENT CHECKOUT PROCEDURE RESULT 1) Check for resistance :
Sanyo EM-X471S, Measure the voltage : Between test points TP-1, TP-2, TP-3 or TP-4 and Ground between TP-5 and TP-6. (See Control Circuit Board on page 9). . NOTE - Proceed with the check of the Step-Down Transformer, to see if any one of the measured values is different from the specified values. Test Voltage Point TP-1 -5V DC TP-2 -22V DC TP-3 -25V DC TP-4 -37V DC TP-5/ 2.0V TP-6 AC COMPONENT CHECKOUT PROCEDURE RESULT Measure the resistance between terminals of FPC connector after removing it from S101. (Figure 6). NOTE - When reconnecting the FPC connector, make When checking “START” key
Sanyo EM-X471S, Key Part No. Description Q’ty No. 1 617 214 9172 Cabinet EM-X471S 1 1 617 224 2262 Cabinet EM-X471YS 1 1 617 224 2125 Cabinet EM-X471US 1 1 617 224 4082 Cabinet EM-X471SS 1 1 617 214 9998 Cabinet EM-X471BS 1 2 411 082 5201 SCR TPG TRS 4 x 10 Z1 8 3 411 160 6007 SCR TPG TRS + SRT 4 x 10 Z1 4 4 617 225 0724 Power Cord 1 5 6 617 204 9366 Oven Cavity*** (Not Service Part) 1 7 617 151 2458 Gear Motor 1 8 411 010 5808 SCR EVR PAN 4 x 10 Z1 2 9 617 138 5601 Bottom Plate*** (Not Service Part) 1 10 617 221 6089 Plastic Foot with Canoe Clip 4 5. EXPLODED VIEW AND PARTS LIST CAVITY PARTS
SWITCHES AND MICROWAVE PARTS Key Part No. Description Q’ty No. 18 411 082 5201 SCR TPG TRS 4 x 10 Z1 2 19 617 196 8507 Blower Fan 1 20 617 124 1181 Latch Lever*** 1 21 617 221 4078 Micro Switch,*** Primary Interlock 1 AM51630C53F2 22 617 221 4061 Micro Switch,*** Interlock Monitor 1 AM50620C53 23 617 221 4078 Micro Switch,*** Door Sensing 1 AM51630C53F2 24
Sanyo EM-X471S, Key Part No . Description Q’ty No. 4 617 124 0948 Choke Dielectric*** 1 5 617 124 0931 Door Sheet 1 6 411 054 1903 Nut Hex + Flg W / SRT 5*** 2 7 617 180 6151 Hinge, Upper*** 1 8 411 011 0802 Bolt Hex+SW+W 5 x 14 Z1*** 2 9 617 101 1494 Spring*** 1 10 617 179 2478 Door Latch*** 1 Key Part No. Description Q’ty No. 1 617 207 6294 Door Cover*** EM-X471S 1 1 617 224 2286 Door Cover*** EM-X471YS 1 1 617 224 2149 Door Cover*** EM-X471US 1 1 617 224 4105 Door Cover*** EM-X471SS 1 1 617 210 7271 Door Cover*** EM-X471BS 1 2 617 210 7592 Door Panel*** 1 3 617 205 7163 Door Main Frame*** (Also order 1 Door Sheet when replacing Door Main Frame) - 7 - DO
Sanyo EM-X471S, - 8 - Key Part No. Description Q’ty No. 617 225 9956 Carton Box Comp. EM-X471BS 1 617 224 8158 Name Plate EM-X471S 1 617 225 1899 Name Plate EM-X471YS 1 617 225 1950 Name Plate EM-X471US 1 617 225 2001 Name Plate EM-X471SS 1 617 225 9871 Name Plate EM-X471BS 1 PRINTED MATTER (Items Not Illustrated) CONTROL PANEL PARTS *** ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Key P
Sanyo EM-X471S, Key No. Order Part No. Description Q’ty RESISTORS. R101, 107, 401 012 5609 Carbon, 1K Ohms 8 114, ±5%, 1/4W. 123 ~ 127 R15, 102, 401 012 6903 Carbon, 10K Ohms 5 108, 109, 116 ±5%, 1/4W. R128, 130, 401 012 8006 Carbon, 100K Ohms 3 131 +-5%, 1/4W. R16, 52, 401 013 6308 Carbon, 12K Ohms 4 55,58 ±5%, 1/4W. R13, 14 401 016 2505 Carbon, 220 Ohms 2 ±5%, 1/4W. R105 401 016 3700 Carbon, 2.2K Ohms 1 ±5%, 1/4W. R104, 106 401 016 4707 Carbon, 22K Ohms 2 ±5%, 1/4W. R111, 112 401 016 9603 Carbon, 27 Ohms 2 ±5%, 1/4W. R115 401 017
Sanyo EM-Z2000S Microwave Oven Instruction manual and cooking manual
EM-Z2000S |
Sanyo EM607TW Microwave Oven Service manual
EM607TW |
Sanyo EM-V5404SW - Full Size Microwave Oven Microwave Oven Service manual
EM-V5404SW - Full Size Microwave Oven |
Sanyo EM-S8588V Microwave Oven Instruction manual
EM-S8588V |
Sanyo EM-S2588B Microwave Oven Service manual
EM-S2588B |
Sanyo EM-SL50GRILL Microwave Oven Instruction manual
EM-SL50GRILL |
Sanyo EM-G5595S Microwave Oven Service manual
EM-G5595S |
Sanyo EM-S1577W Microwave Oven Instruction manual
EM-S1577W |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Haier | HL22K3 | Operation & user’s manual | haier/hl22k3-OGN.pdf | 12 Jun 2023 | 25 | 5.53 Mb |
2 | Planet | FGSW-2620 | Operation & user’s manual | planet-technology/fgsw-2620-E4M.pdf | 26 Aug 2023 | 13 | |
3 | Speco | VL-67/W | Specification sheet | speco/vl-67-w-I99.pdf | 13 Jun 2023 | 1 | 0.15 Mb |
4 | Intek | AR-109 | Owner's manual | intek/ar-109-QB4.pdf | 11 Mar 2024 | 40 | |
5 | Fisher-Price | B1503 | Owner's manual | fisher-price/b1503-X13.pdf | 04 Nov 2023 | 32 | 0.73 Mb |
6 | Epson | CMOS 32-Bit Single Chip Microcomputer S1C33L03 | Technical manual | epson/cmos-32-bit-single-chip-microcomputer-s1c33l03-P21.pdf | 17 Mar 2024 | 631 | 3.64 Mb |
Hotpoint
k.“-w&.Z~—-— ---@_;@-.-—-—-— —— —— ——--,—-—= —=—== .—-——=—=- ~==-–-=-——!!——————-EI.-... ,...—‘*.w
…
Counter Saver RVM 42(16 pages) |
Viva
[fr] Mode d’emploi .......................................................................2[en] Instruction manual .............................................................. 15[de] Gebrauchsanleitung ........................................................... 28[nl] Gebruiksaanwijzing ............................................................ 41VVM1 …
VVM16O3250(56 pages) |
Samsung
Микровълнова фурнаИнструкции за собственика и Ръководство за готвенеGW711KGW712KGW713Kпредставете си възможноститеБлагодарим ви за закупуването на този продукт на Samsung. За да получите по-пълно обслужва� …
GW711K(196 pages) |
Electrolux
EMC2895................................................ .............................................EN MICROWAVE OVEN USER MANUAL 2LV MIKROVIĻŅU KRĀSNS LIETOŠANAS INSTRUKCIJA 21LT MIKROBANGŲ KROSNELĖ NAUDOJIMO INSTRUKCIJA 40PL KUCHENKA MIKROFALOWA INSTRUKCJA OBSŁUGI 59Downloaded From Microwave-Manual.com Manuals
…
EMC2895(80 pages) |
Morphy Richards
INSTRUCTION MANUALModel: MRINV34BLK / MRINV34WTERead these instructions carefully before using your microwave oven.STORE THESE INSTRUCTIONS CAREFULLYMicrowave Ovenwww.morphyrichards.com.au
…
MRINV34BLK(11 pages) |
Samsung
MICROWAVE OVENRefer to the service manual in the GSPN(see rear cover) for the more information.1. Precaution2. ProductSpecication3. Disassembly and Reassembly4. Troubleshooting5. Exploded Views and Part List6. PCB Diagrams7. Wiring Diagrams8. Schematic DiagramsCONTENTSMICROWAVE OVENBASIC: CP1395ESTMODEL: CP1395E-SMODEL CODE: CP1395E- …
CP1395E-S(54 pages) |
Bostitch Nail Gun D16-2ADOperation and maintenance manual for Bostitch D16-2AD Nail Gun D16-2AD, 6 |
Radio Shack VCR 66VCR Owner's manual (Radio Shack 66) 66, 56 |
Nikon Digital Camera Coolpix L29Digital Camera Reference manual (Nikon Coolpix L29) Coolpix L29, 156 |
Victron energy Measuring Instruments BMV-700Measuring Instruments #IP3HLL BMV-700, 4 |
Lantronix Server XPortProLantronix Server Operation & user’s manual (File: lantronix-xportpro-operation-user-s-manual-154, Thursday 31-08-2023) XPortPro, 154 |
Mercury Outboard Motor 4.5Mercury Outboard Motor Operation & maintenance manual (File: mercury-45-operation-maintenance-manual-21, Tuesday 15-08-2023) 4.5, 21 |
Robert Juliat DJ Equipment Dalis-862SRobert Juliat Dalis-862S Manual (Quick start manual), @HSMPDS Dalis-862S, 5 |
CONIA Dryer CCD4501PDF Manual (@T1T297), CONIA CCD4501 Dryer (Mon 10.2023) CCD4501, 8 |
ProRac Automobile Accessories FGWR054-1AAutomobile Accessories Installation instructions (ProRac FGWR054-1A) FGWR054-1A, 2 |
Roland Stereo Equalizer PQ-3BRoland Product Guide: PQ-3B PDF Instructions manual - 49HF21 PQ-3B, 6 |
Horizon Fitness Laboratory Equipment FCSU-023Laboratory Equipment PDF Instruction manual FCSU-023, 2 |
IBM Desktop 51105110 Basic reference manual - M327PR 5110, 255 |