Blitz DZNT series Operating Instructions Manual

Text of Blitz DZNT series User Guide:

• Blitz DZNT series, Operating instructions OIL FREE PISTON COMPRESSORS TYPE DZNT, GZNT, GZNTS GKTE, GKTZ, GKTZH IDENT NR.: 50140-980 25.03.2003 BLITZ M. SCHNEIDER WERKZEUG- UND MASCHINENFABRIK GMBH HÜFINGER STRASSE 55, D-78199 BRÄUNLINGEN, PHONE 07 71 / 92 33 - 0, FAX 07 71 / 92 33 - 99

• Blitz DZNT series, Operating instructions 2 1 : control flange 7 : belt guard 2 : manometer 8 : motor 3 : safety valve 9 : compressor block 4 : pressure switch 10 : air receiver 5 : condensate drain 11 : electric control unit 6 : air outlet 12 : cooler with relief valve

• Blitz DZNT series, Operating instructions 3 INTRODUCTION Blitz piston compressors are the result of many years of experience. Their high quality level and superior design are your guarantee for their reliability, long service life, and economical operation. In order to avoid any unnecessary damage or danger, please read these instructions carefully and always follow them at all times. PROPER USE This compressor has been designed and built in accordance with the latest state of the technical art and the acknowledged safety regulations. However, its use could cause potential danger to the life and li

• Blitz DZNT series, Operating instructions 4 • Work on electrical machinery or drives must not be carried out except by a qualified electrician, or persons with the necessary training under the supervision of a qualified electrician, and in com- pliance with the regulations applicable to electri- cal equipment. • Please note that for units with combustion engine special safety preventions have to be observed. • Always switch the machine off when it is not in use. • If you are working at any height above your normal working height, use suitable ladders and platforms that meet the relevant safety instruc- tions. Do not use any part of

• Operating instructions 5 CONNECTION TO THE COMPRESSED AIR MAINS Warning! - Pressure in the mains The compressed air mains might be under pressure, and working on mains that are under pressure can result in injury. Therefore, first shut the mains off from all sources of pressure and let the air out. Compressed air connection with flexible hosepipes Use a suita

• Blitz DZNT series, Operating instructions 6 SWITCHING THE MACHINE OFF CAUTION! Mistakes when switching off Avoid causing damage to the electric motor, and only ever switch the machine off at the starter switch. Do not use the lockable master switch for this purpose, and never pull the main plug out when the machine is switched off. ⇒ Set the starter switch to the “0” position. • The motor and the compressor will now switch off. • The compressed air line between the compressor and the storage tank w

• Blitz DZNT series, Operating instructions 7 Oil inspection window SUITABLE TYPES OF OIL Mineral oils Synthetic oils Single-grade oil Multi-grade oil Actro EP VDL 150 Actro EP VDL 100 Regis SAE 20W-20 Xenic EP VDL 100 BP Energol RC 150 BP Energol RC 100 BP Energol HD-S SAE 20 W 20 BP Energol RC-S100 Shell Corena Öl H150D Shell Corena Öl H100D Shell Rotella X 20 W 20 V-Öl 7010 Compressor oil 3022 N Compressor oil 3021 N Essolube HDX Plus + 30 Mobil Rarus 429 Mobil Rarus 427 Mob

• Operating instructions 8 DRIVE BELT Units of type DZNT, DZNDT and GZNT have a second V-belt which drives the separate cooling fan for the crankshaft housing. CHECKING THE DRIVE BELT After every 500 operating hours, check the condition and tension of the drive belt. If there are any cracks in it, or if it looks brittle, replace it. Tighten up the tension on it if it i

• Blitz DZNT series, Operating instructions 9 RECTIFYING MALFUNCTIONS Malfunction Cause Remedy • Oil level rises • Drops of water in oil • Oil has milky colour Water has collected in the crank housing. Operating temperature is not being reached because the switch-on times are too short. Change oil at once Use a smaller compressor if neces- sary Water has collected in the crank housing because the machine is installed in a damp place. Change oil at once Select a dry place for installation • Motor cut-out has been triggered Ambient temperature is too high Ventilate the room or choose a cooler place for installation

Related Products and Documents (Air Compressor):

Comparable Devices:

Similar Resources:

• Becker DX 4.40K (4 pages) NJOEV""MAX.PRESSUREMAX.Vm /h3mbarMade in GermanyyearNomin-1kWm /h3mbartypespeedpower requiredinlet capacitymax. pressureHzfrequencyMAX. PRESSUREMade in GermanyyearNomin-1kWm /h3mbartypespeedpower requiredinlet capacitymax. pressureHzfrequencyMAX. V+pL = 67 dB(A) - 50Hz L = 70 dB(A) - 60HzK = 3 dB( …

• Omron NE-C30-E (26 pages) Compressor NebuliserModel NE-C30-E• Instruction Manual• Mode d’emploi• Gebrauchsanweisung• Manuale di istruzioni• Manual de instrucciones• Gebruiksaanwijzing• РУКОВ ОДС ТВО ПО ЭКСПЛУАТАЦИИTM35IM-NE-C30-E-02-11/06ENFRDEITESNLARRUNE-C30.book Page 1 Monday, October 23, 2006 3:11 PM …

• Scheppach HC06 (120 pages) Nachdrucke, auch auszugsweise, bedürfen der Genehmigung. Technische Änderungen vorbehalten. Abbildungen beispielhaft!HC06DEKompressorOriginalbedienungsanleitung4FRCompresseurTraduction des instructions d’origine14ITCompressoreTraduzione delle istruzioni originali23SKKompresorPreklad originálu návodu na obsluhu32CZKompresorPřeklad originálního návod …

• California Air Tools IndUSTRIAL Series 2010ALFC (17 pages)        …

• Porter-Cable CPLDC2541S (23 pages) Direct DriveOil LubePortable Air CompressorCPLDC2541STo learnmoreabout pbrtei;_Cbbievisitour website atiIMPORTANTPlease make certain that the person who isto use this equipment carefully reads andunderstands these instructions beforestarting operations.The Model and Sehal No. plate is located on the frame,Record these numbers in the spaces below and retain f …

• Kobalt VT636201 (30 pages) 1IN636102AV 3/1660 GALLON STATIONARY AIR COMPRESSORITEM #0054284MODEL #VT636201Français p. 31Español p. 61 KOBALT® and the K Design® are registered trademarks of LF, LLC. All Rights Reserved.Questions, problems, missing parts? Before returning to your retailer, call our customer service department at 1-888-3KOBALT (1-888-356-2258), 8 a.m. - 8 p.m., EST …

Comments, Questions and Opinions: