Pioneer DEH-5200SD/XNEW5 Service Manual
|
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 3 5 678 56 7 8 C D F A B E [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine part
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 70 1234 1234 C D F A B E 11.2 KEYBOARD UNIT B SIDE A B KEYBOARD UNIT 1 1 1 1 11 1 1 1 1 1 1 5 1 5 10 15 1 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 1 1 5 10 1 5 1 CN1921 C1924 C1925 C1926 C1927 R1900 C1928 R1901 R1902 R1903 R1905 R1906 R1907 R1910 R1912 R1913 R1928 R1929 R1930 R1931 X1871 CN1811 JA1806 C1841 C1842 C1843 C1844 C1845 C1846 C1847 C1848 C1851 C1852 D1841 D1842 D1843 D1844 D1
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 38 1234 1234 C D F A B E 8.3 PCL OUTPUT CONFIRMATION PCL output In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode cancelled), shift the TESTIN IC601(Pin 61) terminal to H. The clock signal is output from the PCL terminal IC601(Pin 37). The frequency of the clock signal is 625.0 kHz that is one 32th of the fundamental frequency. The clock signal should be 625.0 kHz(- 10 Hz, + 15 Hz). If the clock signal is out of the range, the X'tal (X601) should be repl
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 24 1234 1234 C D F A B E 6. SERVICE MODE 6.1 CD TEST MODE [Key] Contents Display [BAND] Power On (T.Offset is adjusted) TRK MIN SEC 00 00 00 [2] RF AMP Gain switching GG GG GG *1 [3] Focus Close S curve check TRK MIN SEC 91 91 91 [6] Focus Mode switching 0X 0X 0X *2 [1] Tracking Servo Close 00 00 00 or 99 99 99 [<] CRG + [2] Self-adjusting switching TRK MIN SEC ?? ?? ?? *3*8 [>] CRG - *8 [BAND] Power Off TRK MIN SEC
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 66 1234 1234 C D F A B E 11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP ASSY A A TUNER AMP ASSY Capacitor Connector P.C.Board Chip Part SIDE B SIDE A NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams 10 20 30 40 50 60 70 X 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y 1 E 1 E E 51 1 5 E E E 1 1 5 1 1 1 1 25303540 E 1 1 1 E E E 1 E 1 5 10 1 1 5 E E 1 1 1015 15 20 1 E E 1 E 1 1 E IC151 D751 Q851 Q852 Q853
DEH-5200SD/XNEW5 56 1234 1234 C D F A B E A-a A-b A-b 2/2 MEDMUTE SHtoSYS SYStoSH MEDMUTE DACMUTE DEEMPH USB5V SYS8V VDSENS MEDSTBY DM DP CDL CDRDACLRCK DACDATA DACSCK DACCLK DEEMPH DACMUTE FORMAT FORMAT VDD5V C182 CCG1192-A 10u/10 C183 NM C184 CCG1192-A 10u/10 C185 NM C186 NM C187 0.1u/10 C188 0.1u/10 C181 NM C545 1u/6.3 0.1u/10 C533 0.1u/10 C532 0.1u/10 C531 0.1u/10 C530 0.1u/10 C529 0.1u/10
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 36 1234 1234 C D F A B E 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT F E REFO1 CD CORE UNIT Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU un
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 11 5 678 56 7 8 C D F A B E Head unit 1 1 1 1 2 2 2 2 1 5 5 5 5 3 3 3 3 4 5 4 4 4 6 6 6 6 7 7 7 7 9 9 9 9 8 8 8 8 a a b c c c c d d d d e e e e f f f f g traPtraP 1 SW/ BASS 9 AUX input jack (3.5 mm stereo jack) 2 SRC / OFF a USB port 3 (list) b / iPod 4 S.Rtrv c / LOC 5 Disc loading slot d DISP/ / SCRL 6 (eject) e MULTI-CONTROL (M.C.) 7 CLK / DISP OFF f BAND / ESC 8 Detach button g SD memory card slot You can see the SD memory card slot if you remove the front panel. CAUTION Use an optional Pioneer USB cable (CD-U50E) to connect the USB audio playe
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 43 5 678 56 7 8 C D F A B E (1) EXTERIOR(1) SECTION PARTS LIST (2) CONTRAST TABLE DEH-5200SD/XNEW5, DEH-5250SD/XNES, DEH-5250SD/XNES1 and DEH-5290SD/XNID are constructed the same except for the following: Mark No. Description Part No. 1 Cord Assy See Contrast table (2) 2 Holder CND3598 3 Panel CNU1016 4 Detachable Assy See Contrast table (2) 5 Screw BPZ20P100FTC 6 Button(DETACH) CAI2699 7 Button(TA[EW5], SW[ES, ES1, ID] ) CAI2700 8 Button(EJECT, CLK) CAI2701 9 Button(S.Rtrv, iPod, LOC) CAI2702 10 Spr
DEH-5200SD/XNEW5 53 5 678 56 7 8 C D F A B E A-bA-a A-a 1/2 A-b 1/2 IP_RX IP_TX ASENB0 ASENS PEE SYNC FLG LDET CE2 USBCTL FLG DI CK CE1 DO DPDT KYDT KYDT DM DP DPDT DPDT SYStoSH SHtoSYS FLPILM VDCONT TELIN MEDRST MEDSTBY MEDMUTE USBCTL DALMON DALMON KEYD KEYD RWCLK RWCLK SYSPW SYSPW RDSDT SL RCK RDSLK USB5V TUNL TUNR AUXL AUXG AUXR RDS57K CN801 CKS6188- 1 2 3 4 5 6 7 8 9 10 11 12 13 14
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 10 1234 1234 C D F A B E 2.3 PANEL FACILITIES Head unit traPtraP TA / NEWS AUX input jack (3.5 mm stereo jack) SRC / OFF USB port (list) / iPod S.Rtrv / LOC Disc loading slot DISP/ / SCRL (eject) MULTI-CONTROL (M.C.) MUTE / CLK BAND / ESC Detach button SD memory card slot You can see the SD memory card slot if you remove the front panel. CAUTION Use an optional Pioneer USB cable (CD-U50E) to connect the USB audio player/USB memory to the USB port. Since the USB audio player/USB memory is projected forward from the unit, it is dangerous to connect directly. Do not use the unauthorized product. Optional
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 8 1234 1234 C D F A B E WAV signal format ................ Linear PCM & MS ADPCM (Non-compressed) USB USB standard specification ............................................... USB 2.0 full speed Maximum current supply .... 500 mA USB Class............................... MSC (Mass Storage Class) File system.............................. FAT12, FAT16, FAT32 MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3 WMA decoding format ........ Ver. 7,7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 8.2 and
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 58 1234 1234 C D F A B E A-bA-a A-a 2/2 A-b 2/2 VDSENS DACMUTE DEEMPH SD_DATA2 SD_CMD SD_DATA3 SD_CLK SD_DATA0 SD_DATA1 SD_WP SD_CD CDRST CPRST CPPWR CDSRQ CDSTBY DACCLK CDSKIP CDWAIT CP_SCL CP_SDA CD_SDA CD_SCL BUP SD_DATA1 SD_DATA0 SD_CMD SD_DATA3 SD_DATA2 VDCONT CDSRQ CDSTBY CD_SCL CDSKIP CD_SDA CDRST CDWAIT SD_WP SD_CD VDD3.3 CDDATAIN CDLRCKIN CDSCKIN PD13 PD11 PD12 PD10 PD9 PD8 CDLRCKIN CDSCKIN CDDATAIN SD_CLK FORMAT RSPCK0 SSL00 MOSI0 MISO0 PD15 PD14 DACDATA DACLRCK DACSCK SDCTL CN701 VKN1192- 1 WAIT 2 PGND 3 GND 4 LRCK 5 BCLK
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 25 5 678 56 7 8 C D F A B E 6.2 DISPLAY TEST MODE Display Test Mode Restarted pushing reset while pushing the SRC+RDM key then the screen is changed to the display test mode. To the display Test Mode selection screen. SRC+RDM key REPEAT key Display Test Mode Service Display Test Mode To the display of version information REPEAT key To the display of ROM correction version information REPEAT key To all turning REPEAT key To all turning off REPEAT key Screen ROM connection confirmation REPEAT
DEH-5200SD/XNEW5 26 1234 1234 C D F A B E To all turning If a noise is observed on the screen: The display microcomputer may have an error, or the connection between the display microcomputer and the OEL driver may have a problem. If nothing is displayed on the screen: There may be a problem with the communication, or the display microcomputer may have an err
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 21 5 678 56 7 8 C D F A B E 5. DIAGNOSIS 5.1 OPERATIONAL FLOWCHART Vcc = 3.3 V Pin 14 BSENS Pin 16 ASENS Pin 18 DSENS Pin 17 BSENS = L ASENS = L Starts communication with Grille microcom p uter. SWVDD <- H Pin 47 Source keys operative Source ON SYSPW <- H Pin 36 500 ms 500 ms In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 500 msec, the oscillator may be defective. Completes power-on operation. (After that, proceed to each source operation) Power ON
Pioneer DEH-5200SD/XNEW5, DEH-5200SD/XNEW5 64 1234 1234 C D F A B E 10.5 WAVEFORMS - Waveforms Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65 V) 500 ms/div5 V/div 5 V/div 5 V/div 10 V/div 1DSCSNS 5CLCONT 4LOEJ 6VD 5 V/div 5 V/div 5 V/div 5 V/div 1DSCSNS 28SNS 4LOEJ 3HOME 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div1DSCSNS 28SNS 4LOEJ 3HOME 500 mV/div 500 mV/div 200 ms/divcTE dFE 200 mV/div 2 V/div 2 V/div 500 ms/divaFIN b RFOK(MONI_3) 7SIN 1 V/div 500 mV/div 500 mV/div 2 s/div 500 ms/div 7SIN 8CIN 9TIN 2 V/div 500 mV/div 5 μs/diveMDX 7SIN 2 V/div 500 mV/div 50 ms/diveMDX 7SIN 500
Pioneer DEH-P7850BT Car Receiver Installation manual
DEH-P7850BT |
Pioneer KEH-P580 Car Receiver Service manual
KEH-P580 |
Pioneer DVH-P500UB Car Receiver Operation manual
DVH-P500UB |
Pioneer Premier DEH-P960MP Car Receiver Operation manual
Premier DEH-P960MP |
Pioneer SPH-DA02 Car Receiver Important information for the user
SPH-DA02 |
Pioneer SX-3800 Car Receiver Service manual
SX-3800 |
Pioneer DEH-P6000UB - Radio / CD Car Receiver Operation manual
DEH-P6000UB - Radio / CD |
Pioneer AVH-X5590BT Car Receiver Owner's manual
AVH-X5590BT |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | Agri-Fab | 45-02153-131 | Owner's manual | agri-fab/45-02153-131-365.pdf | 04 Dec 2022 | 8 | 0.67 Mb |
2 | Philips | HC5450/83 | Manual | philips/hc545083-525.pdf | 31 Aug 2022 | 126 | |
3 | Trinamic | TMCM-1181 | Manual | trinamic/tmcm-1181-D7O.pdf | 25 Jan 2024 | 74 | |
4 | Ripmax | Wots Wot FOAM-E | Instruction manual | ripmax/wots-wot-foam-e-I36.pdf | 16 Dec 2022 | 12 | |
5 | Asus | P5P43TD PRO | Operation & user’s manual | asus/p5p43td-pro-TRW.pdf | 02 Feb 2024 | 62 | 3.45 Mb |
6 | Liebert | EXL | Installation manual | liebert/exl-JJ2.pdf | 13 Mar 2024 | 72 |
Blaupunkt
OWNER’S MANUAL Mobile Audio System MILANO 170 BT/AUGSBURG 170 BT ALICANTE 170/ESSEN 170 Instruction manual Bedienungsanleitung Mode d’emploi Manual de instrucciones Handleiding Manuale di istruzioni Instruktionsbok Käyttöohje Brugsanvisning Instrukcja obsługi Manual de instruções Használati utas …
MILANO 170 BT(213 pages) |
Aiwa
• BASIC TAPE MECHANISM: CDS-522AV• TYPE: YZSTEREO CARCASSETTE RECEIVERCT-FR929MS/M Code No. 09-993-408-5R1REVISION PUBLISHINGThis Service Manual is the "Revision Publishing" and replaces "Simple Manual"(S/M Code No. 09-993-408-5T1).
…
CT-FR929M(20 pages) |
Panasonic
WMA MP3 CD Player/Receiver Model: CQ-RX450U Operating Instructions DISPDISPVOL PUSH SELFOLDERFILESCROLL RANDOM SCAN REPEATAUXPWR/APMUSBUSBTEXT¡ Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product and keep this manual for future reference.Safety Information Notes on Di …
CQ-RX450U(2 pages) |
Axxess
GMOS-MOST-01INSTALLATION INSTRUCTIONSAxxessInterfaces.com © COPYRIGHT 2018 METRA ELECTRONICS CORPORATION REV. 9/28/18 INSTGMOS-MOST-01Attention! Let the vehicle sit with the key out of the ignition for a few minutes before removing the factory radio. When testing the aftermarket equipment, ensure that all factory equipment is connected before cycling th …
GMOS-MOST-01(8 pages) |
Aiwa
SERVICE MANUALNSX-AJ10SPEAKERSYSTEMCDCASSEIVERREMOTECONTROLLERNSX-SZ10CX-NAJ10 SX-NAJ12CX-NSZ10 SX-NSZ15 RC-ZAS02COMPACT DISC STEREOCASSETTE RECEIVERBASIC TAPE MECHANISM : ZZM-2 PR1NM / PR1NCBASIC CD MECHANISM : AZG-1NSX-AJ10NSX-SZ10NSZ-SZ10EULHHAS/M Code No. 09-003-424-8R1REVISION• If requiring information about the CD mechanism, see Service Manual of A …
NSX-AJ10(12 pages) |
Pioneer
Precautions when handling magazines• Do not put the magazine in a place where it will be exposed tohigh temperatures or direct sunlight.• Do not disassemble the magazine.• Take care not to drop the magazine or knock it against anything.• Do not use cracked or warped trays.• Never insert anything other than discs. Do not attach a label ortape to a d …
CDX-P1270(18 pages) |
Motorola Baby Monitor MBP9Motorola Baby Monitor MBP9 Quick start manual MBP9, 2 |
Nxg Speakers PRO 6222Nxg Speakers Owner's manual (File: nxg-pro-6222-owner-s-manual-4, Mon 11.2023) PRO 6222, 4 |
Silverline Sander 243009Silverline 243009 Manual (Doc Type: Sander Manual ) 243009, 40 |
Hofmann Tyre Changers monty 4400Hofmann monty 4400 Manual (Operation manual), @479IIF monty 4400, 76 |
Unicorn Computer Motherboard ENDAT-9401F/HPDF Guide (@Q421WZ), Unicorn Computer ENDAT-9401F/H Motherboard (21st Sep 2023) ENDAT-9401F/H, 27 |
Onkyo Receiver TX-SR444Receiver PDF Basic manual TX-SR444, 88 |
Wilo Water Pump FKT 20.2FKT 20.2 (Water Pump ePDF Manual, #V3NY17) FKT 20.2, 60 |
Sirona Medical Equipment CerecOperating manual for Sirona Cerec Medical Equipment Cerec, 33 |
Sony Cassette Player WALKMAN WM-FX808PDF User Manual (@V892M8), Sony WALKMAN WM-FX808 Cassette Player (Sun 12.2023) WALKMAN WM-FX808, 27 |
Cressi Watch NEWTON#OD22AE NEWTON: Cressi Watch Owner Documentation NEWTON, 23 |
Lenovo Laptop ThinkPad SL500Lenovo Laptop Setup manual (File: lenovo-thinkpad-sl300-setup-manual-2, 25th Jan 2024) ThinkPad SL500, 2 |
Sony Laptop VGN-AR620E - VAIO AR Digital StudioSony VGN-AR620E - VAIO AR Digital Studio User Manual (Doc Type: Laptop Specifications) VGN-AR620E - VAIO AR Digital Studio, 2 |