Manualios.com

Enodis TEMPSTAR Technical Manual

Enodis TEMPSTAR Manual Online:

3.85, 2243 votes
Enodis TEMPSTAR User Manual
Enodis TEMPSTAR User Guide
Enodis TEMPSTAR Online Manual

Text of Enodis TEMPSTAR User Guide:

  • Enodis TEMPSTAR, 5. Attach the jumper wires to the wires that you removed from the old thermostat. 6. Slide the new imperial brass fitting from your kit onto the new thermostat. 7. Insert the new thermostat/brass fitting combination into the well and tighten down the brass fitting by hand. Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 5: SERVICE PROCEDURES RINSE REGULATINGTHERMOSTAT REPLACEMENT INSTRUCTIONS (CONTINUED) 29 Removing the imperial brass fitting. Attaching the jumper wires. Sliding imperial fitting onto new thermostat. Putting t

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION 71 DRAIN QUENCH ASSEMBLY From the existing drain, attach the two additional Tees using the 1-1/2” NPT Close Nipples. Tighten the Reducers into the Tees as shown above. Attach the Modified Compression Fitting into the 1-1/2” to 1/4” Reducer. Position the bulb of the thermostat so that it rests approximately 1/4” from the bottom of the Tee. Tighten the Modified Compression Fitting as required. Attach to the incoming cold water line. Use pipe dope or thread tape as required to prevent any leaks. Thermostat 05930-003-13-65 Solenoid Valve 04810-100-09

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 7: ELECTRICAL SCHEMATICS TEMPSTAR LT & TEMPSTAR NB (SIDE MOUNT) 208-230 VOLT - 50/60 HERTZ - SINGLE & THREE PHASE 81

  • Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION COIL ASSEMBLY 51 Stand C, Steam Coil Support 05700-002-08-52 Steam Coil Weldment 05700-021-41-38 Stand D, Steam Coil Support 05700-002-08-53 Stand B, Steam Coil Support 05700-002-08-51 Adapter, Steam Coil Nut 2 per assembly 05310-011-17-85 Washer, Steam Coil 2 per

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 7: ELECTRICAL SCHEMATICS TEMPSTAR LT & TEMPSTAR NB (TOP MOUNT) 208-230 VOLT - 50/60 HERTZ - SINGLE & THREE PHASE 83

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION SDS SIDE MOUNTED CONTROL BOX ASSEMBLY (CONTINUED) 40 ITEM QTY DESCRIPTION Mfg. No. 1 1 Control Box Cover Weldment 05700-021-60-43 2 1 Decal, Control Box Cover 09905-021-50-13 3 1 Light, Amber 05945-504-06-18 4 1 Light, Green 05945-504-08-18 5 1 Light, Red 05945-504-07-18 6 1 Manual Wash Switch 05930-301-46-00 7 2 Screw, 4-40 x 1/4" Phillips Panhead 05305-011-36-92 8 1 Cycle Counter 05990-111-

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 4: TROUBLESHOOTING COMMON PROBLEMS 16 WARNING: Inspection, testing and repair of electrical equipment should only be performed by a qualified service technician. Many of the tests require that the unit have power to it and live electrical components be exposed. USE EXTREME CAUTION WHEN TESTING THE MACHINE. Problem: Dishmachine will not fill after the door is close. Power “ON” light is illuminated. 1.

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 7: ELECTRICAL SCHEMATICS TEMPSTAR (TOP MOUNT) (UNIVERSAL TIMER) 380-440-460 VOLT - 50/60 HERTZ - THREE PHASE 79

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 7: ELECTRICAL SCHEMATICS TEMPSTAR (SIDE MOUNT) 440-460 VOLT - 50/60 HERTZ - THREE PHASE 75 09905-031-66-00

  • Enodis TEMPSTAR, A GO*BOX is a kit of the most needed parts for a particular model or model family to successfully effect a repair in the first call 90% or more of the time. The following components may be ordered together using the following Mfg. No.: 06401-002-15-00. ITEM QTY DESCRIPTION Mfg. No. 1 1 Contactor, Rinse/Wash Heater 05945-109-01-69 2 1 Contactor, Wash Motor 05945-109-03-69 3 1 Gauge, Pressure, 0-100 PSI 06685-111-88-34 4 1 Thermometer, 96" Capillary 06685-111-68-49 5 1 Thermometer, 48" Capillary 06685-111-68-48 6 1 Thermostat, Rinse Operating 05930-121-71-29 7 1 Thermostat, Wash Ope

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION WASH & RINSE ARM/MANIFOLD ASSEMBLIES 13 18 20 11 12 15 14 2, 3, 4 5 7 16, 8 6, 10 5 9 7 1 DETAIL “B” WASH ARMS & MANIFOLD DETAIL “A” FINAL RINSE ARMS & MANIFOLD 10 10 10 10 5 17 17 16 2, 3, 19 5 9, 17 9, 17 1 Rinse Injector Weldment 1 per machine 05700-021-47-65 Rinse Injector Gasket 2 per machine 05330-111-42-81 Plug, 1/8” NPT, Brass 3 per Rinse Injector 04730-209-07-37 61

  • Enodis TEMPSTAR, These dishmachines are equipped with electrical solenoid valves to allow for automatic fill and rinse. These valves are designed to specific tolerances and design aspects that must be met in order to function properly. Jackson offers repair kits for replacing some of the wear items associated with solenoid valves which will allow you to save money in that replacement of these parts can take place without removing the solenoid valve from the plumbing assembly. The instructions provided here are for maintenance personnel only. Unauthorized persons should not attempt any of the steps contained

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION CANTILEVER ARM/DOOR ASSEMBLIES (CONTINUED) 44 ITEM QTY DESCRIPTION Mfg. No. 1 1 Cantilever Arm 05700-031-50-67 2 2 Spring Pin, 1/4" x 1 1/8" 05315-407-06-00 3 2 Yoke Assembly 05700-000-75-77 3a 1 Cotter Pin 05315-207-01-00 3b 1 Yoke 05700-000-75-78 3c 1 Clevis Pin, 5/16” x 1 3/8” 05315-700-01-00 3d 2 Nylon Washer 05311-369-03-00 3e 1 Bushing 03120-100-03-00 3f 2 Locknut, 3/8”-16 S/S Hex Center 05310-256-04-00 4 2 Rod, Spring 05700-002-29-38 5 2 Spring 005340-109-02- 00

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION SDS SIDE MOUNTED CONTROL BOX ASSEMBLY 39 Cover, Dielectric Control Panel 05700-021-50-89 Bracket, Side Mount Electrical Box 05700-041-65-68 6 14 15 19 20 23 22 11 12 13 10 16 17 18 9 8 7 1 2 3 4 5 25 21 24 26 27

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION TEMPSTAR SDS INCOMING PLUMBING ASSEMBLY 59 ITEM QTY DESCRIPTION Mfg. No. 1 1 Gauge, Pressure, 0-100 PSI 06685-111-88-34 2 1 Valve, Ball, 1/4" NPT 04810-011-72-67 3 1 Tee, 1/4" x 1/4" x 1/4" Brass 04730-011-51-20 4 2 Nipple, 1/4" Close Brass 04730-207-02-00 5 1 Regulator, Pressure 06685-111-48-54 6 1 Gauge, Pressure, 0-100 PSI 1/8" 06685-011-48-32 7 1 Reducer, 1/4" Male x 3/8" Female Brass 04730-011-59-40 8 1 Fitting, 3/8" Y-Branch 04730-111-58-21 9 1 Valve, Solenoid, 3/4" NPT 04810-100-03-18 10 2 Nipple, Close, 3/4" NPT 0

  • Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 7: ELECTRICAL SCHEMATICS TEMPSTAR LT & TEMPSTAR NB (TOP MOUNT) (UNIVERSAL TIMER) 380-415-440-460 VOLT - 50/60 HERTZ - THREE PHASE 86

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION WASH MOTORS 53 The Tempstar models covered in this manual come supplied with various wash motor assemblies (a wash motor assembly includes the wash motor and the pump end), depending on the characteristics of the machine. To ensure that you order the correct wash motor assembly for the model you are servicing, please refer to the following table: Model Volts Hz Phase Wash Motor Assembly Temps

  • Enodis TEMPSTAR, 13. Slowly remove the valve bonnet. Note: The spring for the plunger is located directly under the bonnet and may come free if you are not careful. Remove the plunger, spring and valve bonnet and place to the side. 14. Remove the O-ring and inspect it. If it has any tears or cuts or excessive flat spaces, it should be replaced. 15. Examine the threads for the valve bonnet. Check them for scoring or signs of damage. Take a cloth and clean them out to remove any foreign particles that might get lodged in the threads and cau

  • Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 1: SPECIFICATION INFORMATION DIMENSIONS TEMPSTAR/NB/LT/S (TOP MOUNTED CONTROL BOX) 5 25 1/4” (64.1 cm) 32” (81.3 cm) 17 1/2” (44.5 cm) MACHINE OPENING 64 3/8” (163.5 cm) 34” (86.4 cm) TABLE HEIGHT 76” (193 cm) W/ DOOR OPEN 14 3/8” (36.5 cm) DRAIN TO FLOOR 61 3/4” (156.8 cm) WA

  • Enodis TEMPSTAR, Tempstar LT/NB/S/SDS Technical Manual 7610-011-86-35 Issued: 06-26-2006 Revised: N/A SECTION 6: PARTS SECTION STEAM TUB ASSEMBLY 47 12 10, 11 2 3 4 7 8 13 14, 11, 15 5 9 3 16 6 22, 2321 24 25 27, 28 24 26 1 29 17 16 18 19 20 Pump Support Bracket Complete Assembly 05700-002-00-46 Nut, 1/4”-20 Serrated Nut 05310-011-66-49 Bracket, Motor Support Weldment 05700-002-68-31 Pump Support Adjustable Bracket 05700-002-20-41 * Represents an item not shown.

Related Products and Documents (Dishwasher):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 NETGEAR DG834GT - 108 Mbps Super G Wireless ADSL Router Start here netgear/dg834gt-108-mbps-super-g-wireless-adsl-router-GL8.pdf 25 Sep 2022 2
2 Trotec IDS 20D Original instructions manual trotec/ids-20d-331.pdf 09 Oct 2023 15
3 Microchip Technology ay-3-8910 Data manual microchip-technology/ay-3-8910-F56.pdf 11 Jun 2023 56
4 Epson EMP EMP-1825 Operation & user’s manual epson/emp-emp-1825-54A.pdf 16 Jan 2023 111 6.79 Mb
5 Frigidaire FEFL77ASG Wiring diagram frigidaire/fefl77asg-791.pdf 24 Jul 2023 1
6 EastLink Champion 2025 Quick reference manual eastlink/champion-2025-C5I.pdf 30 Jan 2024 2

Similar Resources:

  • GE

    GSD1000 series

    (19 pages)
    ==W#=AiGa1ProS1AppliRegist2ReSe19CaanClea1RiAg6(Mm,CrysSterHSaInst3CycFeat4 !UsMainhst1DeterDete(h6WarB CDispeCu7WaTemp6EneSavSwi4WiSt1Energy-Ti2FroPanCoCha1Load8-ModanSerNum2Operahkstru4CycSelec5DryOpt4l?~SCRcy4 ! 7hilModel …
  • Hobart

    AM60E

    (23 pages)
    AM60E DISHWASHER INSTALLATION AND OPERATION INSTRUCTION HOBART FOOD EQUIPMENT CO.,LTD FORM 7153069XE V1.1 2012.08 …
  • Whirlpool

    W10133166A

    (20 pages)
    THANK YOU for purchasing this high-quality product. If you should experience a problem not covered in TROUBLESHOOTING, please visit our website at www.whirlpool.com for additional information. If you still need assistance, call us at 1-800-253-1301. In Canada, visit our website at www.whirlpool.ca or call us at 1-800-807-6777. You will need your model and s …
  • Miele

    G 6920

    (112 pages)
    Operating instructionsfor dishwashersTo avoid the risk of accidents or damage to the appliance, it is essentialto read these instructions as well as the installation sheet before it is in-stalled and used for the first time.en-GB M.-Nr. 10 384 690HG05 …
  • Hanseatic

    HGU4582D97710DI

    (80 pages)
    Unterbau-GeschirrspülerTeilintegrierbarer GeschirrspülerGebrauchsanleitungHGU4582D97710DIHGTI4582D97710DSAnleitung/Version:2001-01078_DE_20201102Bestell-Nr.: 14361369, 60697762Nachdruck, auch aus zugs wei se, nicht ge stat tet! …
  • Siemens

    SN Series

    (42 pages)
    5HJLVWHU\RXUSURGXFWRQOLQHVLHPHQVKRPHFRPZHOFRPHHQ'LVKZDVKHU%JTIXBTIFS2SHUDWLQJLQVWUXFWLRQV SN…SX…www.devicemanuals.eu/%JTIXBTIFSwww.devicemanuals.eu/%JTIXBTIFS …

Comments, Questions and Opinions: