Airpress LHR 215/5 Instruction Manual
|
Airpress LHR 215/5, Versie 02.2006 Please read this instruction manual carefully before use. (GB) Waste electrical products should not be disposed of with household waste. Please recycle where facilities exist. Check with your Local Authority or retailer for recycling advice. Importeur Airpress, P.O. Box 114, NL-8900 AC Leeuwarden www.airpress.nl
Airpress LHR 215/5, 2 TABLE OF CONTENTS ENGLISH 1. Prefatory notes page 25 2. Safety instructions page 26 3. Warnings page 27 4. Specifications page 29 5. Parts and features page 29 6. Installation and assembly page 30 7. Operating procedures page 32 8. Maintenance page 32 9. Storage page 34 10. Troubleshooting guide page 34 1. PREFATORY NOTES Buying your AIRPRESS compressor installation, you have become the owner of a compressor installation with a high performance and reliability level. Correct
Airpress LHR 215/5, 3 2.0 SAFETY INSTRUCTIONS Important: please read and observe the following safety instructions before using the machine. • Nobody must be allowed to use the compressor unless they have read the instruction manual and have been instructed in the regulations to follow for correct and safe use. • The machine must be used by adults only. Use of the compressor by apprentices of not less than 16 years of age must be supervised by an adult authorised to use the machine. • Keep children and visitors away from the working area. • Be cautious when using compressed air. Never aim the air flow
Airpress LHR 215/5, 4 excessive heat, oil and sharp objects. • Never leave the machine unattended with the power supply "on". Also disconnect the power cable when: - you leave the machine, even for a short time - not in use - carrying out maintenance work - changing attachment or moving the machine. • WARNING: the warnings, cautions and instructions discussed in this instruction manual cannot cover all possible conditions and situations that may occur. It must be understood by the operator that common sense and caution are factors which cannot be built into this product
5 tank may reduce the tank's strength and cause an extremely hazardous condition. Welding on the tank in any manner will void the warranty. Check the manufacturer's maximum pressure rating for air tools and accessories. Compressor outlet pressure must be regulated so as to never exceed the maximum pressure rating of the tool. High temperatu
Airpress LHR 215/5, 6 4. SPECIFICATIONS Order number 36646 Pump Oil-lubricated direct drive Motor 1,5 HP/1,1 kW Voltage Single Phase 230 Volt Air tank capacity 5 litres Oil tank capacity 0,25 litres Cut-in Pressure 6 bar Cut-out Pressure 8 bar Max. charge 30% per 60 minutes Sound pressure 77 dB(A)/7 m Air intake capacity 215 l/min. Weight 21 kg Model changes reserved. All compressors are provided with Euro-Norm (CE-Choice) 5. PARTS & FEATURES (page 1) Drain valve : used to
7 Wheels: roll the unit on its wheels to move it into position for use and storage Handle: use the convenient handle to move the air compressor into the desired position for use and storage. Tank: stores high pressure air from the air compressor pump. 6. INSTALLATION & ASSEMBLY WARNING The air compressor should be turned off and unplugged from the power source before an
Airpress LHR 215/5, 8 Location of the Air Compressor The air compressor should always be located in a clean, dry, and well-ventilated environment. The unit should have at minimum, 12 inches of space on each side. The air filter intake should be free of any debris or obstructions. Check the air filter on a daily basis to be sure it is clean and in working order. Grounding Instructions This product should be grounded. In the event of an electrical short circuit, grounding reduces the risk of lectric shock by providing an escape wire for the electric current. Th
Airpress LHR 215/5, 9 7. OPERATION PROCEDURES Daily start-up Procedures 1. Set the Auto-On/Off lever to the Off position. 2. Check the air compressor visually for any damage or obstruction. 3. Close the drain valve. 4. Check the oil level of the pump. 5. Attach the air hose to the quick coupler by pulling back on the outer sleeve of the quick. Release the outer sleeve and make sure the hose stays in place. 6. Plug the power cord into the proper receptacle. 7. Install the desired air accessory to the open end of the air hose before proceeding any further. Failure to do so will not allow any pressure to build up in the hose. 8. Turn the Auto-on/Off lever to the On-Auto position and t
Airpress LHR 215/5, 10 Check Tank Safety Valve X Overall Unit Visual Check X Check Oil Level X Change Oil X X Check Air Filter (more frequently in dusty or humid environments) X Drain Moisture From Tank X CAUTION To ensure efficient operation and longer life of the air compressor unit, a routine maintenance schedule should be followed. The following schedule is geared toward a consumer whose compressor is used in a normal working environment on a daily basis. If necessary, the schedule sh
Airpress LHR 215/5, 11 Cleaning Air Filter To clean the air intake filter, be sure to do the following: 1. Turn the unit off and unplug the power cord from the receptacle. 2. Allow the compressor time to cool if it has been in operation. 3. Open the drain valve to bleed all air from the tank. After the tank is empty, close the drain valve. 4. Remove the outer cap from the air intake filter assembly. 5. Remove the 'filter from the inside of the assembly. 6. Wash the filter in warm soapy water to remove any dirt or debris. 7. Dry the filter before re-inserting into the assembly. 8. Return the filter to
Airpress LHR 215/5, 12 Problem Possible Correction Air leaks at the check valve or at the pressure relief valve. A defective check valve results in a constant air leak at the pressure release valve when there is pressure in the tank and the compressor is shut off. Drain the tank, then remove and clean or replace the check valve. Air leaks between head and cylinder. Be sure of proper torque on head bolts. If leak remains, contact a service technician. Air leak from safety valve. Operate the safety valve manually by pulling on the ring. If the valve continues to leak when in the closed position, it should be replaced. Pressure reading on the regulated pressure gauge drops when an
Airpress LHR 215/5, 14 Vorstvrij opstellen Frostfrei aufstellen Frost-proof installation Installer à l’abri du gel Instalacion a prueba de heladas Pas op voor hete delen Heisse Teile Beware of hot parts Faites attention aux pièces chaudes Tenga cuidado con las piezas calientes Regelmatig oliepeil controleren Regelmäßig Ölstand kontrollieren Regularly check oil level Contrôler régulièrement le niveau d’huile Controlare regularmente el nivel de aceite Regelmatig condenswater aftappen Regelmäßig Kondenswasser ablassen Regularly drain condensation water Vidanger réguli�
Airpress LHR 215/5, 15 EC-declaration of conformity We, Airpress, P.O. Box 114, 8900 AC Leeuwarden, The Netherlands, taking full responsibility, declare that the products compressors LHR 215/5 to which this declaration refers, comply with the machinery directive 98/37/EC, the EMC directive 89/336/EC, the low tension directive 73/23/EC and the directive 2000/14/EC. The Netherlands, Leeuwarden, 28 th July 2005
Airpress LHR 215/5, EC-declaration of conformity We, Airpress, P.O. Box 114, 8900 AC Leeuwarden, The Netherlands, taking full responsibility, declare that the products compressors LHR 215/5 to which this declaration refers, comply with the machinery directive 98/37/EC, the EMC directive 89/336/EC, the low tension directive 73/23/EC and the directive 2000/14/EC. The Netherlands, Leeuwarden, 28 th July 2005 J.H. de Vries Directeur/Geschäftsführer/Managing director/dDirecteur général/Director gerente
Airpress H 85 Air Compressor Operating instructions manual
H 85 |
Black & Decker ASI500 Air Compressor Original instruction
ASI500 |
Airpress HL 340/90 Air Compressor Instruction manual
HL 340/90 |
CMi C-LK 262/50/8 Air Compressor Operating instructions manual
C-LK 262/50/8 |
EINHELL 200/40 OF Air Compressor Operating instructions manual
200/40 OF |
Airpress HL 310 Air Compressor Instruction manual
HL 310 |
Airpress HL 360/50 compact Air Compressor Instruction manual
HL 360/50 compact |
Airpress HLO 215/25 Air Compressor Operating instructions manual
HLO 215/25 |
# | Manufacturer | Model | Document Type | File | Updated | Pages | Size |
---|---|---|---|---|---|---|---|
1 | LEXIBOOK | TM230 | Manual | lexibook/tm230-KTN.pdf | 23 Feb 2024 | 44 | |
2 | MeLe | STAR CLOUD PCG03 PLUS | Quick start manual | mele/star-cloud-pcg03-plus-931.pdf | 29 Aug 2023 | 4 | |
3 | Staude | MULTI-FLY | Instruction manual | staude/multi-fly-889.pdf | 05 Aug 2022 | 76 | |
4 | Aastra | Meridian 5216 | Operation & user’s manual | aastra/meridian-5216-3TC.pdf | 11 Nov 2023 | 2 | 0.39 Mb |
5 | Thule | 1203 | Instructions manual | thule/1203-SCC.pdf | 03 Apr 2023 | 8 | |
6 | Panasonic | Viera TH-C46FD18 | Quick start manual | panasonic/viera-th-c46fd18-961.pdf | 04 Jul 2023 | 54 |
Mi-T-M
Mi-T-M® Gasoline Air Compressor Manual 1GASOLINE30/80 GALLON INDUSTRIALAIR COMPRESSOROPERATOR'S MANUALCAUTIONRISK OF INJURY! READ ENTIRE MANUAL BEFORE OPERATING! THIS MANUAL IS AN IMPORTANT PART OF THE AIR COMPRESSOR AND MUST REMAIN WITH THIS UNIT WHEN YOU SELL OR RENT IT!©Copyright 2008, Mi-T-M Corporation® Form #37-1033-E/S-12050 …
ABS 30(20 pages) |
Sealey
INSTRUCTIONS FOR:COMPRESSORS 270ltr BELT DRIVE 5.5 / 7.5 HP3PH 2-STAGEMODEL No's: SAC42755BLN, SAC72775BLNThank you for purchasing a Sealey product. Manufactured to a high standard this product will, if used according to these instructions and properly maintained, give you years of trouble free performance.IMPORTANT: PLEASE READ THESE INSTRUCTIONS …
SAC42755BLN(6 pages) |
Air-Zenith
AIR-ZENITH OB2 Owner’s Manual Congratulations! Thank you for purchasing the world’s fastest DC 12-Volt air compressor by AIR-ZENITH. Air-Zenith quality products are manufactured by the people who know pneumatic air suspension systems inside and out. Our R&D people take pride in doing it right the first time, every time. This installation manu …
OB2(4 pages) |
GEA Bock
GEA Bock EX-HG66eAssembly instructions96463-08.2019-GbTranslation of the original instructionsDevice category 2 Gacc. to directive 2014/34/EUEX-HG66e/1340-4 EX-HGX66e/1340-4 EX-HG66e/1340-4 HCEX-HG66e/1540-4 EX-HGX66e/1540-4 EX-HG66e/1540-4 HC EX-HG66e/1750-4 EX-HGX66e/1750-4 EX-HG66e/1750-4 HC EX-HG66e/2070-4 EX-HGX66e/2070-4 EX-HG66e/2070-4 HCEX-H …
EX-HG66e Series(52 pages) |
nuair
Manuale istruzioni ..........................5Instructions for use manual ......7Manuel utilisateur ...........................9Betriebsanleitung ......................... 11Manual de instrucciones ........13Manual de instruções ................15Gebruiksaanwijzing ....................17Brugsanvisning ..............................19Instruktionsmanual .... …
RevolutionAIR Boxy(62 pages) |
RIDGID
OF25150AOperAtOr’s MAnuAl2.5 GAllOn twin stAck pOrtAble Air cOMpressOr!WARNING:To reduce the risk of injury, the user must read and understand the Operator’s Manual before using this product. IN625301AV 6/09
…
OF25150A(5 pages) |
Saeco Coffee Maker TALEA GIROTALEA GIRO Operation and maintenance manual - BFM24C TALEA GIRO, 26 |
HP Laptop Presario CQ71-300 - Notebook PCOperation & user’s manual for HP Presario CQ71-300 - Notebook PC Laptop Presario CQ71-300 - Notebook PC, 33 |
Agilent Technologies Measuring Instruments 35670A#C1D745 35670A: Agilent Technologies Measuring Instruments Owner Documentation 35670A, 322 |
Peavey Music Mixer PV 8Manual: Peavey PV 8 (99UM1E, Upd.11.10.2023) PV 8, 72 |
Canon All in One Printer imageRUNNER ADVANCE C2030imageRUNNER ADVANCE C2030 (All in One Printer ePDF Manual, #A2YS52) imageRUNNER ADVANCE C2030, 24 |
Goodman Heat Pump CONDENSING UNITHeat Pump PDF Installation & service reference CONDENSING UNIT, 24 |
Sony Stereo Receiver STR-DE805G - Fm/am Stereo ReceiverSTR-DE805G - Fm/am Stereo Receiver Operating instructions manual - 9D9UM4 STR-DE805G - Fm/am Stereo Receiver, 200 |
GRE Receiver PSR-500GRE Receiver Owner's manual (File: gre-psr-500-owner-s-manual-138, 17.09.2023) PSR-500, 138 |
Zanussi Cooktop ZCG7550ZCG7550 Instruction booklet - HNBDE5 ZCG7550, 56 |
Dymo Label Maker Rhino 3000 Industrial Label PrinterDymo Label Maker Rhino 3000 Industrial Label Printer Operation & user’s manual Rhino 3000 Industrial Label Printer, 30 |
Philips Portable DVD Player PD7040/05Philips PD7040/05 User Manual (Doc Type: Portable DVD Player Quick start manual) PD7040/05, 2 |
Space-Ray Heater RSCA3Space-Ray Heater Installation and operation instructions manual (File: space-ray-rsca10-heater-18, 02/10/2023) RSCA3, 18 |