Manualios.com

Whirlpool Personal Valet PVBN600 Service Manual

  • Personal Valet PVBN600 Laundry Appliance
  • maFu7CE.Y3rFQ
  • Service Manual
  • PDF / Adobe Acrobat Reader
  • 56

Whirlpool Personal Valet PVBN600 Manual Online:

3.35, 2388 votes
Whirlpool Personal Valet PVBN600 User Manual
Whirlpool Personal Valet PVBN600 User Guide
Whirlpool Personal Valet PVBN600 Online Manual

Text of Whirlpool Personal Valet PVBN600 User Guide:

  • Whirlpool Personal Valet PVBN600, 3-1 THEORY OF OPERATION THE PERSONAL VALET CLOTHES VITALIZING SYSTEM The Personal Valet Clothes Vitalizing System is designed to freshen any previously worn clothing so that it is “ready to wear.” It works for both dry cleaned and non-dry cleaned cloth- ing. One of the key components of the system is the special solution, called Presiva ® , that cap- tures odors, and removes wrinkles from the fabric. The solution is manufactured by Procter and Gamble ™ for use in the clothes vitalizing system. Presiva is made up of donut-shaped molecules that capture odor particles in the clothing, “surfactants” to spread the Presiva droplets over the fabric, and

  • Whirlpool Personal Valet PVBN600, 6-4 DOOR SWITCH Refer to page 5-10 for the procedure for ser- vicing a door switch. 1. Unplug the clothes vitalizer or disconnect the power. 2. Set the ohmmeter to the R x 1 scale. 3. Disconnect one of the wires from the door switch terminals. 4. Touch the ohmmeter test leads to each of the door switch terminals. The meter should indicate 0 Ω (closed circuit) with the actuator button out, and infinite resistance (open circuit) with the button pushed in. WARNING Electrical Shock Hazard Disconnect power before servicing. Replace all panels before operating. Failure

  • Whirlpool Personal Valet PVBN600, 8-1 WIRING DIAGRAM Line Neutral P6-5 P9 P10 P2-3 P2-4 P2-5 P8 CON 14-1 CON 14-2 P1 14-Pin Connector 2-Pin Connector P13 M M 880W Heater Fan Wax Motor Buzzer 440W Heater 5/400 Compressor TCO Opens @ 170°C/338°F Closes @ 136°C/277°F K2 K3 K1 Q3 Q2 Q1 P2-2 P7 Thermistor 50K Ω @ 25°C / 77°F Door Switch To Active Overlay To Active Overlay Electronic Control 120 VAC, 60 Hz WH BK N.C. LT. BU VT Door Switch BR BK GY RD YL WH BK/RD WH/RD OR

  • Whirlpool Personal Valet PVBN600, 2-4 10. To mount the clothes vitalizer to con- crete or concrete block: a) Align the lower edge of the mounting bracket assembly with the line you drew earlier. Select and mark a hole location on each side of the bracket. b) Set the bracket aside, and drill two anchor holes at the marks you made. c) Drive the wall anchors into the holes with a hammer. 11. Mount and secure the mounting bracket assembly to the wall with two lag bolts. Make sure that the bracket is level. 12. Space the inside edge of the mounting bracket nuts so they are approximately 3/8″ to 1/2″ from the mounting bracket ass

  • Whirlpool Personal Valet PVBN600, 4-8 CHANGING THE FILTER The filter at the end of the tube on the formula dispenser should be changed when it becomes clogged. The filter (#4396216) can be ordered by calling: 1-866-MYVALET. Two filters are in- cluded. To replace the filter: 1. Remove the formula container from the clothes vitalizer. Empty the formula from the container and place it on a flat surface. 3. Hold the clear tube and pull the old filter off the end, then install the new filter in its place. 2. Pull straight up on the nozzle pack and remove it from the container. 4. Install the filter pack on the formula con- tainer and reinstall it in the clothes vitalizer. remove & replace filter

  • Whirlpool Personal Valet PVBN600, - iii - TABLE OF CONTENTS GENERAL............................................................................................................................... 1-1 Safety First......................................................................................................................... 1-1 Model & Serial Number Designations ................................................................................ 1-3 Model & Serial Number Label And Tech Sheet Locations................................................. 1-4 Specifications..................................................................

  • Whirlpool Personal Valet PVBN600, 4-4 SLEEVE SHAPER The sleeve shaper is used on long sleeve shirts, blouses, coats, and jackets. The shaper removes wrinkles by providing horizontal ten- sion inside the sleeve. To use a sleeve shaper: • Remove the shapers from the black strap. • Insert the shaper into a buttoned long sleeve with the straight end of the shaper being inserted first. • Align one side of the shaper to the seam of the sleeve, and release the latch. • Insert the shaper until 1/4″ extends out of the cuff. • To remove the shaper, squeeze it, and re- move it from the sleeve. NOTE: When storing a sleeve shaper, use the black strap to keep it closed.

  • Whirlpool Personal Valet PVBN600, 7-1 NOTES: 1. When diagnosing this unit, always begin by checking for the correct line voltage, blown fuses, and failed components. 2. Any unit that fails within the first few days should be checked for loose connections. 3. All voltage and resistance checks should be made with a meter having a sensitivity of greater than 20,000 ohms-per-volt. Refer to the control panel layout at the bottom of the page for the location of each keypad and LED described in this section. STUCK KEYPADS The microprocessor will only operate when one keypad is pressed at a time. Therefore, if a keypad

  • Whirlpool Personal Valet PVBN600, 5-2 REMOVING THE TOP COMPONENT COVER NOTE: Sharp edges may be present. 1. Unplug the clothes vitalizer or disconnect the power. 2. Remove the twelve T-15 Torx screws from the top component cover and remove the cover from the unit. Top Component Cover Screw (1 of 12) Electrical Shock Hazard Disconnect power before servicing. Replace all panels before operating. Failure to do so can result in death or electrical shock. WARNING

  • Whirlpool Personal Valet PVBN600, 1- 2 Tip Over Hazard Do not use clothes vitalizer until com- pletely installed. Install lag bolts securely into wall studs. Use two or more people to move and install clothes vitalizer. Failure to follow these instructions can result in death or serious injury. WARNING Electrical Shock Hazard Connect green ground wire to ground screw. Failure to do so can result in death or electrical shock. WARNING IMPORTANT Electrostatic Discharge (ESD) Sensitive Electronics ESD problems are present everywhere. ESD may damage or weaken the elec- tronic control assembly. The new control assembly may appear to work well after repair is finished, but failure may occur at a

  • Whirlpool Personal Valet PVBN600, 5-6 REMOVING THE HEATER ASSEMBLY & THERMOSTAT NOTE: Sharp edges may be present. 1. Unplug the clothes vitalizer or disconnect the power. 2. Remove the twelve T-15 Torx screws from the top component cover and remove the cover from the unit (see page 5-2). 3. Disconnect the power connector from the wiring harness. 4. Remove the mounting screw and lift the heater assembly out of the unit. NOTE: The thermostat is part of the heater as- sembly and must be replaced as an assem- bly. Heater Elements Thermostat Heater Assembly Power Connector Electrical Shock Haza

  • 7-3 880-Watt Heater Test NOTE: The wax motor must be engaged for this test to avoid opening the heater thermal fuses. The wax motor and fan will remain on during this test, and the 880-Watt heater will turn on. The results will be displayed as follows: a)The “5” LED in the Time Bar will turn on to indicate that the test is in progress. All the other LEDs

  • Whirlpool Personal Valet PVBN600, 1-5 SPECIFICATIONS MODEL NUMBER PVWN600 PVBN600 Dispenser Nozzle Flow Rate 17 ml/Min. 17 ml/Min. Fan CFM 105 - 120 105 - 120 Fan Operation 20% Duty Cycle Until Dry 20% Duty Cycle Until Dry Compressor 1 CFM @ 15 P.S.I. 1 CFM @ 15 P.S.I. Container 890 ml/30 Ounces 890 ml/30 Ounces 5 - 9 Regular Cycle 5 - 9 Regular Cycle 3 Heavy Duty Cycle 3 Heavy Duty Cycle Presiva Bottle 1.5 Liter/50.72 Ounces 1.5 Liter/50.72 Ounces Operating Temperature 130 Degrees 130 Degrees Dimensions Height 59″ 59″ Width 35″ 35″ Depth (Overall with Handle) White Doors 13-3/4″ 13-3/4″ Biscuit Doors 13-3/4″ 13-3/4″ Wood Panel Doors

  • Whirlpool Personal Valet PVBN600, 5-3 REMOVING THE COMPRESSOR NOTE: Sharp edges may be present. 1. Unplug the clothes vitalizer or disconnect the power. 2. Remove the twelve T-15 Torx screws from the top component cover and remove the cover from the unit (see page 5-2). The component described on this page is shown below. 6. Mark the top hose of the compressor with pieces of tape, or use a marker, for iden- tification. 7. Cut the two hose clamps and pull the hoses off the compressor fittings. 8. Loosen the four T-15 Torx mounting screws. 9. Slide the compressor brackets so the large openings in the two keyhole slots are over the screw heads, and remove the com-

  • Whirlpool Personal Valet PVBN600, 7-4 THERMISTOR RESISTANCE CHARTKEYPAD MATRIX CHART Before replacing the electronic control board, check for the proper touchpad functioning, as follows: 1. Disconnect power from the unit. 2. Remove connectors P1 and P13 from the electronic control board. 3. Using the table below, measure the resis- tance across the switch when the touchpad is pressed. The meter must be connected with the proper polarity, as follows: • For an analog meter readout, the resis- tance reading should go from infinity, (open circuit), down to about 10 or 20 ohms. • For a digital meter readout, the resis- tance reading should go f

  • 6-3 WARNING Electrical Shock Hazard Disconnect power before servicing. Replace all panels before operating. Failure to do so can result in death or electrical shock. THERMISTOR Refer to page 5-4 for the procedure for servic- ing the thermistor. 1. Unplug the clothes vitalizer or disconnect the power. 2. Set the ohmmeter to the R x 10K scale. 3. Disconnect one of the wires from

  • Whirlpool Personal Valet PVBN600, 5-8 REMOVING A CABINET DOOR NOTE: Sharp edges may be present. 1. Unplug the clothes vitalizer or disconnect the power. Top Door Pin 2. Remove the screw and hex cap nut from the bottom pivot bracket. 3. Remove the two bottom door hinge bracket screws. Push down on the collector and pull the door and bracket out just far enough to clear the collector. Bottom Door Hinge Bracket 4. Slide the top door pin out of its pivot bracket and remove the door. Top Door Pin & Plastic Sleeve Collector Screws NOTE: If you are replacing the door, remove the plastic sleeve from the top pin for use on the r

  • 1-3 MODEL & SERIAL NUMBER DESIGNATIONS MODEL NUMBER SERIAL NUMBER M M M 27 10110 DIVISION RESPONSIBILITY M = MARION OHIO MANUFACTURING SOURCE M = MID-SOUTH ELECTRONICS YEAR OF PRODUCTION M = 2002 WEEK OF PRODUCTION 27th WEEK PRODUCT SEQUENCE NUMBER MODEL NUMBER P V W N 6 0 0 LW 00 INTERNATIONAL SALES IND. or MARKETING CHANNEL IF PRESENT PRODUCT GROUP P = PREP CLOTHING S

  • Whirlpool Personal Valet PVBN600, 4-7 LOADING THE CLOTHES VITALIZER The clothes vitalizer is designed for daily use by being able to handle one outfit at a time. Although the vitalizer can handle up to three articles of clothing, the best performance is ob- tained when no more than two articles of cloth- ing are loaded. Maximizing space around the clothing allows the formula to circulate between the clothes, which improves performance. Depending on the fabric and the amount of wrinkles, it may not be necessary to use the body shaper or the sleeve shapers. This is es- pecially the case with suit coats, blouses, and skirts. IMPORTANT: The fol

  • Whirlpool Personal Valet PVBN600, 6-1 COMPONENT TESTING Before servicing, check the following: • Make sure that the power cord is firmly plugged into a live circuit with the proper voltage. • Check for a blown household fuse or circuit breaker that has tripped. • Check the connections before replacing a component. Look for broken or loose wires, failed terminals, or wires that are not pressed into their connectors far enough. • Check for wire connectors that are not pressed tightly onto their termina

  • Whirlpool Personal Valet PVBN600, 4-6 CLOSET HOOK The closet hook is used with the clothes hanger and pant hanger. It allows clothes and pant hangers to hang in a standard closet. To use the closet hook, slide it into the oval opening at the top of the clothes or pant hanger. The closet hook is available in the Combina- tion Pak #4396281, and the Versatility Pak #4396280. There are several optional accessories for your clothes vitalizer that will allow more flex- ibility in loading your clothes. To order any of the accessory kits, listed below, call: 1-866-MYVALET You may also visit our website at: www.personalvalet.com OR Visit any retail store that sells the Personal Valet�

  • Whirlpool Personal Valet PVBN600, 3-4 CYCLE OPERATION Heavy Duty Cotton Poly Approximately a 54-minute cycle. This cycle is to be used for cotton and polyester clothes that are heavily wrinkled. RegularCare Cotton Poly Approximately a 34-minute cycle, and is to be used for cotton and polyester clothes that have light and medium wrinkles. This is the cycle to be used for bringing clothes back to a ready- to-wear state that have been previously worn. Wool Approximately a 35-minute cycle, and is to be used for all wool clothes, regardless of the amount of wrinkles. Delicate Approximately an 18-minute cycle and is to be used for all delicate fiber clothes, such a

  • Whirlpool Personal Valet PVBN600, 4-5 USING THE OPTIONAL ACCESSORIES HANGER EXTENDER The hanger extender provides best perfor- mance on men’s sizes 46+ for coats, 17″ neck sizes, and XXL shirt sizes. It increases width of the shoulder area to improve wrinkle removal performance for shirts and coats. To use a hanger extender: • Place the hanger extender opening over the oval head of the clothes hanger, and press it firmly into place against the hanger. The hanger extender is available in the Com- bination Pak #4396281, and the Versatility Pak #4396280. COMPACT HANGER The compact hanger is used on women’s sizes 4 and unde

  • PRODUCT SPECIFICATIONS AND WARRANTY INFORMATION SOURCES IN THE UNITED STATES: FOR PRODUCT SPECIFICATIONS AND WARRANTY INFORMATION CALL: FOR TECHNICAL ASSISTANCE WHILE AT THE CUSTOMER’S HOME CALL: THE TECHNICAL ASSISTANCE LINE: 1-800-253-2870 HAVE YOUR STORE NUMBER READY TO IDENTIFY YOU AS AN AUTHORIZED SERVICER FOR LITERATURE ORDERS: PHONE: 1-800-851-4605 IN CANADA: FOR PRODUCT SPECIF

  • 6-2 WARNING Electrical Shock Hazard Disconnect power before servicing. Replace all panels before operating. Failure to do so can result in death or electrical shock. BUZZER Refer to page 5-4 for the procedure for servic- ing the buzzer. 1. Unplug the clothes vitalizer or disconnect the power. 2. Set the ohmmeter to the R x 1 scale. 3. Disconnect one of the wires from the buzzer t

  • 3-2 MISTING MODE: Air Damper Open— Air Flows Through Vents Only During the misting cycle, the compressor pro- duces the Presiva mixture, and a fan creates a draft at the top of the cabinet to vent the used mixture. At the end of the misting cycle, the compressor turns off, and a heater is ener- gized, along with the fan, to dry the fabric. The Heater h

  • Whirlpool Personal Valet PVBN600, 2-3 Tip Over Hazard Do not use clothes vitalizer until com- pletely installed. Install lag bolts securely into wall studs. Use two or more people to move and install clothes vitalizer. Failure to follow these instructions can result in death or serious injury. WARNING MOUNTING THE CLOTHES VITALIZER 1. Lay the carton with the clothes vitalizer on its back. 2. Open the carton so you can access the front doors. 3. Remove the tape from the doors. 4. Open the doors and remove the contents from inside the unit. Important: Before the clothes vitalizer is installed on the wall, do not open the doors more than 90° to avoid damaging the door hinges. 5. Clos

Related Products and Documents (Laundry Appliance):

Comparable Devices:

# Manufacturer Model Document Type File Updated Pages Size
1 Panasonic AW?HE60HN Operating instructions manual panasonic/aw-he60hn-U89.pdf 11 Oct 2022 120
2 Ranger Products RFJ-3000AL Installation and operation manual ranger-products/rfj-3000al-LE5.pdf 10 Feb 2024 8
3 Bella 14768 Instruction manual bella/14768-3E9.pdf 05 Nov 2023 24
4 Nice RUN1800 Installation instructions manual nice/run1800-2Q9.pdf 08 Dec 2022 30
5 Suncoast G2p Owner's manual suncoast/g2p-8XS.pdf 11 Nov 2023 10
6 Traulsen UHT27 Owner's manual traulsen/uht27-36V.pdf 05 Dec 2023 16 0.2 Mb

Similar Resources:

  • GE

    GTUP240EMWW

    (3 pages)
    Dimensions and Installation Information (in inches) For answers to your Monogram,® GE Profile™ or GE® appliance questions, visit our website at geappliances.com or call GE Answer Center® service, 800.626.2000.360329GTUP240EM/240GM GE® 24" Unitized Spacemaker® Washer and DryerListed by Underwriters LaboratoriesSpecification Revised 2/11Electrical …
  • Samsung

    WD8704RJD

    (36 pages)
    Washing Machineuser manualimagine the possibilitiesThank you for purchasing this Samsung product.To receive a more complete service, please register your product atwww.samsung.com/registerWD8704EJ(A/D/F/G/H/Z)WD8702EJ(A/D/F/G/H/Z)WD8704RJ(A/D/F/G/H/Z)WD8702RJ(A/D/F/G/H/Z)WD8704JJ(A/D/F/G/H/Z)WD8702JJ(A/D/F/G/H/Z)WD8704RJ-02718A-03_EN.indd 1 2010-05-06 ¿ …
  • Asko

    D3350

    (2 pages)
    PROGPROG STARTSTARTSTARTSTOPSTOPSTOPESTARTSTARTENDENDQuick Start GuideWe know you’re excited about owning an ASKO dishwasher and you’re anxious to get started, so here’s a brief summary of the operationprocedures. The page references in this Guide refer to the Use and Care Guide. To get the most out of your dishwasher’s features, werecommend that you …
  • Frigidaire

    GLGT1142CS1

    (2 pages)
    Before Operating Your WasherRead your Owner's Guide. It has important safetyand warranty information. It also has manysuggestions for best washing results. To reduce the risk of fire, electricshock, or injury to persons, read the IMPORTANTSAFETY INSTRUCTIONS in your Owner's Guidebefore operating this appliance.Operating StepsRead Washing Procedure …
  • Milnor

    MWF125J7

    (112 pages)
    Published Manual Number/ECN: MPIMWF125JAE/2021366A• Publishing System: TPAS2• Access date: 09/03/2021• Document ECNs: LatestInstallation and ServiceMWF125J7, MWF125Z7PELLERIN MILNOR CORPORATION POST OFFICE BOX 400, KENNER, LOUISIANA 70063-0400, U.S.A. …
  • Samsung

    WF8604GEA

    (180 pages)
    Washing Machineuser manualimagine the possibilitiesThank you for purchasing this Samsung product.To receive more complete service, please register your product atwww.samsung.com/registerWF8604GE(A/C/D/F/G/H/R/S/T/V/W/Z)WF8602GE(A/C/D/F/G/H/R/S/T/V/W/Z)WF8600GE(A/C/D/F/G/H/R/S/T/V/W/Z)WF8608GE(A/C/D/F/G/H/R/S/T/V/W/Z)WF8502GE(A/C/D/F/G/H/R/S/T/V/W/Z)WF8500GE( …

Comments, Questions and Opinions: